2005 Acura TL Suspension Problems

My wife, [XXX] , purchased a 2005 Acura TL on [XXX]. The car was not inspected, it had a hole in the oil tank, was leaking battery acid, had broken control arms, wore out rotors, wore out brake pads, bald tires, Vehicle Stability Control disabled, no AC, cracked dashboard where the passenger air bag is located, and the alignment was so bad that the car would try to pull very hard off of the road. Toxic hot fumes entered the cockpit during my wife's drive home from the car dealership. The fumes made her feel sick and gave her a horrible headache because of the leaking battery acid and perhaps the hole in the oil tank. It's a health and safety issue that needs to be taken seriously. The used car dealership (Premium Auto Outlet Inc.) is selling vehicles to customers and are not providing them with the title. My wife paid in full, yet she had to fight to receive the title. The employees scream at there customers, including my wife and also tell them to leave the property when asking for the title and when confronted about vehicle mechanical issues. The female employee even screamed over the phone at our mechanic (Delran Auto Repair) who tried to tell the employee that the car was not is sellable condition due to the safety and mechanical problems. Please review the Google reviews and Facebook reviews for more horrible customer experiences when it comes vehicles being sold in horribly unsafe mechanical condition, withholding titles, unlawfully repossessing, screaming at customers and ignoring customer complaints. The best resolution for my wife and I would be for the dealership to pay for all of the repair bills that accrued (roughly $4K) due to the car being sold in unsafe condition and most importantly the prevention of any health and safety issues due to the selling of unsafe mechanically condition vehicles to future customers. Please investigate this issue for the health and safety of people. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11678771

Incident

Jan 29, 2025

Ball joint purchased from Napa Auto Parts #260-1791was defective. Nut supplied with ball joint was too small. This caused the ball joint to separate from the steering knuckle. After driving a very short distance the front end of the car collapsed, causing the front axle to break. The car fell on the front fender damaging it. This is the same problem reported in 2011. [XXX] This is a serious safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11582401

Incident

Mar 30, 2024

I WENT TO GO AT A STOP LIGHT I GOT TO ABOUT 15 MPH AND MY CAR JUS LOST ALL POWER AND DIDN'T RESTART. WHEN I TRIED TO TURN THE KEY ON AND OFF AGAIN NO POWER AS WELL AS EVERYTIME I PUT THE KEY IN THE IGNITION IT MAKES THIS WEIRD BUZZING NOISE WHEN I TRY TO TURN IT OVER. *TR

NHTSA ID

11329095

Incident

Jun 7, 2020

Mileage

194,000 mi

TL* THE CONTACT OWNS A 2005 ACURA TL. WHILE DRIVING 5 MPH, THE LOWER BALL JOINT ON THE DRIVER'S SIDE LOOSENED AND CAUSED THE FRONT SUSPENSION TO FALL OFF. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 11E022000 (SUSPENSION). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 124,968.

NHTSA ID

11222988

Incident

Jun 25, 2019

Mileage

124,968 mi

FAILUER OF THE FRONT ALUMINUM FRAME WAS OBSERVED ON MY CAR DURING A STATE INSPECTION BY AN OBSERVANT TECHNICIAN. THE COMPLIANCE BUSHING IN THE FRONT STRUT ASSEMBLY FAILS WITHOUT GIVING THE DRIVER AN AUDIBLE OR DRIVING SIGNAL. THIS CREATES METAL ON METAL CONTACT BETWEEN THE STRUT AND ALUMINUM FRAME - WEARNIG THRU THE ALUMINUM FRAME ARM EXTENSION WHICH SUPPORTS THE METAL ROD TO THE WHEEL. THE ALUMINUM FRAME WILL EVENTALLY FAIL CAUSING LOSS OF VEHICLE CONTROL. THIS WOULD BE LIFE THREATENING AT HIGHWAYS SPEEDS. I HAD TO HAVE THE ENTIRE FRONT FRAME ASSEMBLY REPLACED TO MITIGATE THIS RISK.

NHTSA ID

11175866

Incident

Dec 12, 2017

Mileage

125,000 mi

MY VEHICLE WAS IN MOTION ON POWER INN AND CALVINE RD I WAS MAKING A LEFT TURN ONTO CALVINE RD MY RIGHT SIDE WHEEL WELL WHETHER HOLDS THE WHEEL HAD SNAP ON ME N I WAS STUCK THERE FOR AN HOUR TILL HIGHWAY PATROL CAME AN CALLED EAGLE TOWING.... BUT BEFORE THE OFFICER HAD ARRIVED I TRIED SHIFTING IT INTO PARK IT WOULDN'T LET ME I JUST BOUGHT THE CAR FROM OFFERUP AN THE PERSON HAD INFORMED ME HE REPLACED THE TRANNY ETC.... IDK I'M JUST STRESS ABOUT BUYING A NEW CAR AN NOW IT STUCK SITTING HERE IN MY GARAGE AND THE MOST HEADACHE ABOUT THIS SITUATION IS I NEED TO REGISTER INTO MY NAME N I CAN'T EVEN DO THAT NOW THAT HIS HAPPEN SIGH IF THERE'S ANYTHING YOU GUYS CAN DO FOR ME AND MY GIRL I'D HIGHLY APPRECIATE IT PLEASE AN THANK YOU *DATE OF INCIDENT ISN'T CORRECT I KNOW I WAS THE END OF MARCH OR BEGINNING OF APRIL I'M GOING TO HAVE MY GIRL CALL EAGLE TOWING OR HIGHWAY PATROL FOR ACTUAL INFORMATION

NHTSA ID

10979757

Incident

Mar 22, 2017

Mileage

147,678 mi

2005 ACURA TL FRONT SUSPENSIONS HAVE A DESIGN DEFECT WHICH PROMOTES FAILURE TO SUPPORT LOWER CONTROL ARMS AND LEADS TO LOSS OF STEERING. FIRST - THE COMPLIANCE BUSHING FOR THE LOWER CONTROL ARM FAILS ALLOWING THE STEEL CONTROL ARM TO CONTACT THE ALUMINUM SUB FRAME EXTENSION. THE SOFT SUB FRAME MATERIAL IS WORN OUT FROM CONTACT WITH THE HARD LOWER CONTROL ARM MATERIAL. EVENTUALLY, THE EXTENSION FROM THE SUB FRAME LOSES ITS ABILITY TO SUPPORT FORCES FROM THE LOWER CONTROL ARM AND FAILS. I WAS FORTUNATE TO AVOID A CATASTROPHIC EVENT WHEN THIS ISSUE WAS IDENTIFIED DURING AN ANNUAL STATE INSPECTION AND LEAD TO REPLACEMENT OF THE SUB FRAME AND COMPLIANCE BUSHINGS. FAILURE OF THE COMPLIANCE BUSHING IS NOT OBVIOUS TO THE DRIVER TO PROMOTE REPAIR ACTIONS; AS THERE ARE NO AUDIBLE OR DRIVING SIGNALS TO INDICATE THIS HAS OCCURRED. FAILURE OF THE COMPLIANCE BUSHING AND SUBSEQUENT FAILURE OF THE ALUMINUM SUB FRAME WILL LEAD TO LOSS OF STEERING. MY CAR WAS STATIONARY AND ON A LIFT WHEN THE ISSUE WAS OBSERVED.

NHTSA ID

10907360

Incident

Nov 24, 2015

Mileage

135,000 mi

TL*THE CONTACT OWNS A 2005 ACURA TL. WHILE DRIVING 20 MPH, THE CONTACT HEARD A LOUD POPPING AND GRINDING NOISE. HE EXITED THE VEHICLE AND NOTICED THAT THE DRIVER'S SIDE WHEEL WAS BENT OUTWARDS FROM THE HOOD. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE LOWER BALL JOINT FAILED AND CAUSED THE WHEEL TO COME OFF. THE VEHICLE WAS REPAIRED. THE MANUFACTURER ADVISED THE CONTACT TO CALL THE DEALER TO DETERMINE THE CAUSE OF THE FAILURE. AFTER FURTHER INVESTIGATION, IT WAS DETERMINED THAT THE DEALER WAS THE CAUSE OF THE FAILURE AND NO COMPENSATION WOULD BE MADE. THE FAILURE AND CURRENT MILEAGES WERE 21,000. UPDATED 04/24/09.*LJ THE CONSUMER STATED THE UPON DELIVERY OF THE VEHICLE, IT PULLED STRONGLY TO THE RIGHT WHILE DRIVING. THE DEALER DIGNAOSED THE VEHICLE WITHOUT EVEN LOOKING AT IT, BY SAYING IT WAS THE TORQUE STEER. ON ONE OCCASION, THE VEHICLE FAILED TO START. THE CONSUMER STILL CONTINED TO COMPLAIN ABOUT THE VEHICLE PULLING TO THE RIGHT. AT TIMES THE VEHICLE WOULD POP OUT OF OR GRIND INTO THIRD GEAR. THE LOWER BALL JOINT HAD FAILED. IT RIPPED OUT THE DRIVE SHAFT, BENT THE LOWER CONTROL ARM, DAMAGED THE BODY AND LEAKED TRANSMISSION FLUID ALL OVER THE ROAD. UPDATED 04/29/09.*JB

NHTSA ID

10255312

Incident

Jan 10, 2009

Mileage

21,000 mi

VEHICLE HAS CONSTANT SHIMMY IN STEERING WHEEL. ACURA REFUSES TO FIX CAR UNDER WARRANTY SAYING IT IS A CHARACTERISTIC. AFTER HAVING THE CAR INSPECTED BY A HONDA DEALER THE CAR IS FOUND TO HAVE A BAD AXEL. THE REPAIR ORDER AND INFORMATION WAS FAXED TO THE PRODUCT MEDIATOR AT AMERICAN HONDA WHO CONTACTED THE DISTRICT PARTS MANAGER WHO SAYS THAT HE REFUSES TO FIX THE CAR BECAUSE ITS A CHARACTERISTIC. THE CAR WAS INSPECTED BY A TRAINED ACURA MECHANIC AT THE HONDA DEALER. ACURA REFUSES TO FIX THE CAR WHICH COULD RESULT IN A CRASH. *TR

NHTSA ID

10198865

Incident

May 27, 2007

Mileage

33,000 mi

MY 2005 ACURA TL EL42 BRIDGESTONE REAR TIRES WENT COMPLETELY BALD ON A 3000 MILE TRIP(19000 MILES TOTAL) FROM DALLAS TO COLORADO AND BACK. IT APPEARS THAT THERE IS A SUSPENSION/TIRE PROBLEM WHERE THE REAR ALIGNMENT UNDER FULL LOAD OF 2 PASSANGERS AND LUGGAGE IN THE TRUNK DEGRADES AND CAUSES SEVERE TIRE WEAR. THIS CAUSES SEVERE LOSS OF CONTROL ON WET PAVEMENT WITH REAR HYDROPLANING AT EVEN <50 MPH. ACURA HAS A TSB AND REPLACE TIRES AT LOWERED COST BUT ONLY WITH THE SUSPECT EL42 TIRES. AFTER FURTHER INTERNET SEARCHES THIS SEEM NOT TO BE ISOLATED INCIDENT.

NHTSA ID

10163036

Incident

Jul 9, 2006

Mileage

19,000 mi

VEHICLE HAS A VIBRATION BETWEEN 52-64 MPH. FEELS LIKE YOU ARE DRIVING OVER RUMBLE STRIPS. THE DEALER AND FACTORY HAVE ATTEMPTED TO REPAIR 4 TIMES AND OVER 19 DAY IN SHOP AND STILL THE VIBRATION IS PRESENT. MY FEAR IS THE VEHICLE TRANSMISSION, DRIVE TRAIN, STEERING OR BRAKES COULD FAIL AT ANY MOMENT DUE TO PART FATIGUE. THERE SEEMS TO BE NO REPAIR IN PLAN TO RESOLVE THIS PROBLEM CAN YOU PLEASE HELP. *NM

NHTSA ID

10152051

Incident

Feb 6, 2006

Mileage

8,413 mi