Owner-reported complaints naming the powertrain system, filed with NHTSA
Data refreshed
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials. Every record below is an owner-reported complaint about the 2022 Acura TLX submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Transfer case failure, leakage, discovered after warranty expired. Took vehicle in describing seeming loss of AWD and tech informed me it was “normal” I Later discovered, during an oil change, a leak From the transmission or transfer case that covered the lower skid plate, which looking up, was directly related to a known failure of the Type S’s transfer case/Transmission causing a loss of traction to the rear wheels.
The transfer case splines sheared off in the transmission. The car is safe to drive but went from AWD to FWD as there is now no power being transmitted through the transfer case to the rear wheels. The dealership confirmed the issue was the transfer case by lifting the car and seeing if the rear wheels were getting power. They then tore down the transmission and found the splines were all gone from the transfer case. The component was not inspected by the manufacturer, police, insurance, or anyone else. There were no warnings or symptoms to the problem before the failure.
Went to the Acura dealer for an oil change. Was told I have a leak in the transmission and transfer case and that both will need to be replaced.
The transfer case spines have stripped and I no longer have all wheel drive only front wheel drive. This is a huge safety hazard for me .
Accelerated and heard a loud noise and felt like I had driven through wood and one got stocked to the whelle. There was a lot of traffic so I was driving slow. The noice I heard was like something was stuck inside the wheel, like it was grinding. Dealer diagnosed a bad transfer case and transmission and they replaced both under warranty.
Was changing the oil on my car and noticed grease running out from between the transfer case and transmission and also fluid build up on the transfer case higher up a little below the driveshaft. The car has 41k miles on it, there should be no leaks. My concern is the transfer case/transmission spline failure issue.
My vehicle has less then 35000 miles, I was doing a oil change when I noticed that my transfer cases has a slight oil residue from the bottom, which I suppose it’s just gonna get worse overtime, at this mileage I don’t think this is right that’s why I’m submitting this complaint.
While accelerating from 0 to 40 miles per hour, I experienced a loud bang come from the car. Turns out the splines were stripped between my transmission and transfer case. This was due to the drive shaft spinning while in park mode, as well as an opening between the transmission and transfer case that was spooling. My powertrain system was severely compromised; who knows what could've happened if I had kept driving the car in this condition? Something was waiting to inevitably fail beyond what had happened. Thankfully, this happened on an empty road close to home, but it could have happened anywhere. There were no warnings, lights, or anything, which was the strangest part. Thankfully, this $10k+ bill was covered under the manufacturer's powertrain warranty, but it seems to be a common issue with many newer Acuras. Acura is well aware of the issue (spline failure) and should issue a recall to correct this design flaw within the powertrain.
Transmission jerks at low speeds, Car jerks when it is downshifting. The car only has 14,000 miles. Dealership refusing to do any work due to car not having any codes. The car feels like it is having a misfire.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .