Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 17 NHTSA owner-reported complaints for the 2020 Alfa Romeo Giulia. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–17 of 17
Just bought a 2020 Alfa Romeo Giulia from Carvana and two days later while driving the check engine light came on along with the electronic throttle light and the auto start/stop light. While driving the vehicle went into complete limp mode in a busy intersection and I had to pull off quickly to avoid being hit by other traffic. Engine codes came up fuel pressure related.
A persistent humming/whining noise occurs at highway speeds (around 60–70 mph). The noise has been present for more than two years and has continued through multiple major repairs. The sound appears to come from the drivetrain area and raises concerns about a potential driveline or mechanical failure at speed. The issue has been reproduced and confirmed by multiple authorized dealerships. The vehicle has undergone two rear differential replacements, a transfer‑case replacement, chassis ear testing, STAR engineering cases, and testing with OEM wheels and tires. The noise remains after all repairs. The manufacturer’s Area Representative test‑drove the vehicle and verified the noise. Despite this, the manufacturer has stated that no further repairs will be approved, and the vehicle was returned with the defect still present. The vehicle has been out of service for more than 100 days for attempts to diagnose and repair this issue. The unresolved noise at highway speeds creates a safety concern because it may indicate an underlying drivetrain problem that could worsen or fail while driving. There were no warning lights or messages. The only symptom is the persistent noise at highway speeds.
This is regarding a ABS unit that under the part number for this Vehicle it shows it meets the recall but it is not listed under vin number in order to get repairs correctly completed for this vehicle. Vehicle was diag. and confirmed issue at a local auto repair shop. ABS warning msg, is present on display, engine light on due to abs pump, as well braking issue is also present. When running part number from parts department for this vehicle part number matches recall 21V-309. a case has also been created CASE: 96026913 for this vehicle vin. part# for vehicle current pump 68505278aa.
The vehicle never had a problem with the backup camera until the recall, and they serviced the vehicle:Rearview Camera Failure (2025): Affects 2020–2025 Giulia and Stelvio, where the screen may not display the rearview image, increasing crash risk. Since the recall the back-upscreen failed to display camera numerous times. The car was brought in to fix camera/screen and they could not find a problem. I provided pictures of the screen displaying "CAMERA SYSTEM UNAVAILABLE" Still having Back-up screen failure's.
I was traveling along the San Francisco Oakland Bay Bridge on a normal commute day when the brakes started sticking early on after that point, by the time I reached the Caldecott tunnel after the incident on the Bay Bridge, the brakes locked up completely, forcing me to coast without using any brakes and subsequently the brakes started smoking. I had to exit the nearest exit to stop the car and tun it off. I had to have my car towed to the repair shop the following day. My car is now unusable for the past two weeks until I can get a resolution to the faulty brakes situation.
2020 Alfa Romeo Guilia Purchased 11/29/24 Miles : 22,710 [XXX] Issue: Safety 1st sign of issue car did not start leaving work one day about 7 attempts before it started. From than on it continued, one day driving to work stopped at a light the auto turn off but car did not restarted had to apply emergency hazard lights after several attempt it started up extremely dangerous and scary as I almost was rear ended several times. this continued to happen I took it back to dealer. On date 3/15/25 Mitsubishi where it was purchased they had for 2 days charged my $200 for diagnostics and said could not repair issue they said take it to Alfa Romeo. 03/15/2025TEST ELECTRICAL SYSTEM FOR PERFORMANCE AND ELECT. -DRAW - -27,877 miles Shortly after that car has turned off in the middle of the hwy ([XXX]) during stop and go traffic extremely dangerous took about 5 minutes and car finally started. Next day car did not start on my way to work had to have car towed around [XXX] to Alfa Romeo service in Ft. L. There they kept car about 4 days replaced battery and all relays charged me $1600. A week later the same issue stared again. Christian – Alfa Tech Cust serv Michael They asked me to take it back did offer a loaner this time. They had it for 3 days said it was the relay again. Few days continued to turn off this time I started to record my attempts to start sending them videos and they have ask me to drop it off again waiting for them to provide a loaner. This would be the 4th time having this issue worked on. But now they are not calling me back. I am afraid I am going to get In to a serious accident but I have no other means of transferportaion. I Call Alfa R. Customer relation Care agent 1 844 411 2532 Called on 8/21/25 open case. Alfa Romeo Case# [XXX] Beth - Alfa Romeo Premium Care Specialist 844-253-2872 Beth, Thank you for getting back to me. Today's update 8/26/25 I received a call from Haylie at Alfa Romeo Ft. L with a follow up INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5
Let me start by stating that this incident is just one of many occurrences that has happened to me with this vehicle. I was driving down a straight highway that was pretty heavily congested with traffic of other vehicles, when all of a sudden I felt a loss of power with the vehicle and some error codes came up on the dashboard indicating the engine needed to be serviced, start & stop was unavailable, and to service electronic throttle control. I also noticed that the vehicle driving mode had switched by itself from Dynamic to Natural mode. After a few short seconds, I felt the RPMs drop completely to zero and I felt a loss of the power steering as well because the engine had shut down completely in the middle of highway traffic. As I was driving on the left lane of a two lane highway, I had to immediately pull over to the right side shoulder, nearly being hit by vehicles behind me as the Alfa Romeo Giulia stalled and immediately cut my speed. I was parked on the right shoulder of the highway with my hazard lights on and put the vehicle into Park. When I tried to restart the engine, it just cranked over for a long time before finally turning on. The same error codes popped up on the dashboard indicating the problem was still there. I tried to continue driving down the highway but the engine kept on shutting itself off and the issue persisted. Eventually I had to call a local friend who has a trailer to help me tow my vehicle back home. The vehicle, when scanned, released the code P008A which indicates a low pressure fuel system error. I have read that this issue is currently being investigated by the NHTSA and would like to clarify and state that this is indeed a very dangerous safety issue and it should be dealt with accordingly.
Driving and stopped at a traffic light, car engin stopped then when I tried to start the engin burning smell and smoke came from under the hood. Took the car to the dealership and they advised me that the starter had been completely burned out but yet they don't know why or how. This incident had made me fearful for my kids, wife and my life, the starter is close to gas lines and that could have caused an explosion. I am not sure how can the starter burn in flames when there is a relay and fuses to protect the regulation of current going into the starter. Thanks
Around January 30, 2023 (need to verify the exact date). My vehicle went on limp mode, the engine light went on plus an additional warning light. I was driving on highway 99 when my car started to stall. It felt like the car put itself in neutral mode. It was frightening as it happens randomly & suddenly after being able to drive 60+ mph. It wouldn’t pick up speed. Driving 5 mph. It was frightening as I was far from the exit & the vehicles behind were honking and 1 swerved, thankfully the driver was able to change lanes. I tried my best to move to the slow lane, but it was extremely difficult as the car would not pick up speed. I finally made it to the slowest lane (no emergency lane avail.) I was anxiously hoping for an exit. It took a while, kept on my hazard lights. When I finally found an exit completely stalled, then after turning it on and off it picked up a bit of speed. Tt felt like it was on neutral. I parked and attempted to call a tow truck. The car kept struggling and it was raining that day. After hours, I was able to get assistance to take it home. I did call Alfa Romeo, which they towed it to their nearest dealership. They ran test but did not find anything wrong with the engine. They did find other things like the coolant leaking. They did fix those things. However, they did keep my vehicle for over 2 months! And I had to request the inspection because they did not send it or placed inside the vehicle like they normally do. The vehicle has only done it one additional time since then but this time it was minor, while trying to leave my house. I turned it off for a few minutes and then everything was fine. I have also notified Alfa Romeo of the infotainment turning off since I had this vehicle. The engine/throttle error (limp mode) is dangerous and scary for the us the driver and the drivers around us. On may 24, 2023 I received an email from Alfa Customer Retention Specialist, offering to buy back the vehicle due to Civil Code 1793.2(d)(2)(B).
The vehical is experiencing locked break calibers. Abs won't release.
vehicle had a head gasket blown and oil to coolant mixture due to head gasket and oil cooler failure this has will now be the 3rd engine 4th time I have to bring the car for warranty regarding the headgasket car has been in the dealership for months at times.
I noticed that the windshield is delaminating. I did a search on the internet to see if anyone else was having this issue and many other Alfa Romeo owners did notice that around the windshield you can see bubbles. Took the car to the dealership and they said it was not covered by warranty. I decided to go to their parking lot to check other client cars and sure enough i found other Alfa with the same problem. I think this could be a very dangerous problem for drivers. I'm afraid this issue will continue to get worst. Thank you
Around 715p, today, May 29, my wife was driving the Alfa Romeo Giulia, and we pulled into our driveway. I was in the passenger seat and had my right elbow resting on the window sill (the window was fully open) and my palm was resting against the window frame. My wife pressed the automatic window up button as she was turning off the car. As the window started up, my forearm was trapped between the sill and the window frame. the pain was extremely intense, particularly from where the window kept trying to close. I yelled at my wife several times to hit the window down button. I could not get my arm out. Finally, I was able to pull my arm out scraping the skin. I feel that, if there had been soft tissue such as a baby's neck where my arm was, the tissue would have been crushed. After I pulled my arm out, the window did not continue to raise.
2020 ALFA ROMEO GIULIA. CONSUMER WRITES IN REGARD TO ILLIMINATED SERVICE ENGINE LIGHT. THE CONSUMER STATED WHEN THE SERVICE ENGINE LIGHT APPEARS OTHER FUNCTIONS ARE INOPERABLE START/STOP AND D-N-A (PERFORMANCE MODES) AND COULDNT PASS NYS EMISSIONS AND SAFETY INSPECTION.
I was driving at highway speed when the glass sunroof exploded without warning. It had been functioning as expected prior to this. Some glass entered the vehicle, but there were no injuries. The vehicle is available for inspection and is scheduled to be inspected by an insurance rep. It has already been inspected by a dealer representative, who claimed damage was caused by debris striking the vehicle, however I have DASH CAM VIDEO that contradicts this version of events.( I will forward video upon request. ) Manufacturer has denied warranty coverage for repair which includes paint damage from broken glass.
inaccurate fuel gauge reading i have sent it to the dealer two times it still not reading correct the fuel gauge stays at three quarters. even i fill it to the top. the dealer told me to read the owner manual or i am not filling it correct.0608
BACKUP CAMERA IS VERY DIM ESPECIALLY ON THE VERY OUTSIDE OF THE VIEW. NOT BRIGHT ENOUGH TO DISCERN PEDESTRIANS WALKING BEHIND THE VEHICLE WHICH COULD POSSIBLY CAUSE BODILY HARM. DEALER SAYS IT IS WITHIN THEIR SPECIFICATIONS AND THERE IS NOTHING THEY CAN DO. I'VE FOUND SEVERAL FORUMS ON THIS VERY SUBJECT AND SOME CLAIM THERE IS A FIX USING A COMPUTER PROGRAM THAT LIGHTENS THE CAMERA TO A USEFUL LEVEL. I TOOK THIS ISSUE UP TO THEIR CUSTOMER CARE AND THEY SAY THE DEALER CAN'T DO ANY MORE AND THE CASE IS CLOSED. I HAVE HAD SEVERAL VEHICLES, ALL MAKES AND MODELS AND NOT ONE OF THEM HAD A CAMERA THIS DANGEROUS.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .