2020 Alfa Romeo Stelvio Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2020 Alfa Romeo Stelvio, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine828.6%
- Electrical621.4%
- Fuel system517.9%
- Powertrain (other)310.7%
- Driver assistance27.1%
- Steering13.6%
- Other / unspecified13.6%
- Seat belts13.6%
- Airbags13.6%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
Engine light came on. I was told by the first dealership that the coolant was mixing with the engine oil. There was also a vehicle at the shop there for the same issue. after doing some research online, it appears that this is a bigger issue. I bought the car at 20,000 miles and this began happening around 52000 miles. Given the low mileage, this is something that should not be happening to a newer car.
The contact owns a 2020 Alfa Romeo Stelvio. The contact stated that while driving on two occasions at undisclosed speeds, the check engine, oil, and the Automatic START/STOP System Unavailable warning lights illuminated. The vehicle was taken to a dealer twice; however, on the first occasion, the failure was not duplicated. During the second visit, the contact was informed that the coolant was mixing into the engine oil, which caused the engine failure. The contact was informed that several unstated parts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 44,000.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The contact owns a 2020 Alfa Romeo Stelvio. The contact stated that while driving on two occasions at undisclosed speeds, the check engine, oil, and the Automatic START/STOP System Unavailable warning lights illuminated. The vehicle was taken to a dealer twice; however, on the first occasion, the failure was not duplicated. During the second visit, the contact was informed that the coolant was mixing into the engine oil, which caused the engine failure. The contact was informed that several unstated parts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 44,000.
The contact owns a 2020 Alfa Romeo Stelvio. The contact stated that while the vehicle was parked, the vehicle became inoperable and failed to start with no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed that the ground strap had failed due to corrosion and needed to be replaced. The vehicle was repaired. The dealer informed the contact that if the corrosion had not been repaired in time, it could have caused a more severe vehicle failure. The manufacturer was made aware of the failure. The failure mileage was not available.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
Car stalled/ went into limp mode 4 separate times for fuel pressure issue. Is not drivable, does not accelerate, throws erroneous error codes. The recall Y91 covers this issue for 2020 Stelvio. When I contact Mopar they say it is not open on my vin. How is this possible?
The contact owns a 2020 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle, and the vehicle was jerking. The failure was intermittent. The vehicle was taken to the dealer, where it was diagnosed with a fuel system failure. The manufacturer was not notified of the failure. The approximate failure mileage was 86,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
The gear shifter broke. The button on the back that you compress in order to trigger a button inside of the shifter, broke off and then the button inside got stuck. I was not able to shift gears and even though there was no other issue with the vehicle, I was stuck in a parking lot blocking other people's ability to move around me. It creates a safety hazard by not being able to shift gears to move the vehicle out of harm's way or even to be able to be towed in a safe manner. The tow truck driver had to climb under my vehicle and find a way to put the vehicle into neutral because the gear shifter would not engage. No to the other questions. I sat for six hours waiting for a tow truck to come because the first one that was dispatched was not able to help due to the specific circumstances. From reading other online forums, this does seem to be a recurring issue with Alfa Romeo's.
Please be advised that Alfa Romeo vehicles are experiencing a very large number of gear shift selecting buttons that "POP OFF" during driving and while parked and can't be driven or moved!!! This is a know reported and COMMON ISSUE according to the ALFA ROMEO SERVICE MANAGER but not a reported recall issue!!! This is unsafe and very dangerous and should be considered a recall safety issue by the manufacture, owners and public immediately!!! This small piece of equipment that just unexpectedly "POPS OFF" can cause serious injury! 2020 ALFA ROMEO STELVIO - Miles: 69866
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
My Alfa Romeo Stelvio 2020 on Oct 29,2025 stop functioning all the ADAS system as well as the sunroof. Because of this a had a small accident with a gate as it did not advised me. I read in a few websites that I am not the only person having this same issue. This is a very serious issue that Alfa Romeo manufacturing should fix immediately before it can become a tragic event.
I was in an accident that was can be contributed to my lane keeping assistance. Once the car crashed into another vehicle my airbags failed to deploy.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
Upon starting the vehicle a number of warning lights illuminated including the battery light. Upon viewing the battery compartment the plastic enclosure surrounding the battery had a few inches of water inside. I do have videos showing the water inside the compartment and also video of water being vacuumed out of the compartment. We did some research and found that this exact same issue sparked a recall in the same model vehicle in 2018. Very dangerous and i hope this is not happening to others, based on our research it is.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
ALFA ROMEO IN DETROIT, MI HAS BEEN CONTACTED, AND THE REPLY AFTER A ONE-DAY WAIT THAT THE TEAM CONCLUDED THAT THE TIRE ON THE CAR IS GOOD EVEN TRIED TO EXPLAIN THAT THE TOP SPEED OF AN ALFA ROMEO STELVIO TI SPORT AWD CAN RUN EASILY 140 MPH. THESE CONTINENTAL TIRES RATING 'H' TOP SPEED IS 130 MPH. ALFA ROMEO'S SPOKESPERSON STATED THAT THE TIRE ON THE CAR CAME FROM ITALY WITH THESE TIRES, SO ALFA ROMEO WANTS ME TO CALL THE DEALERS AND WAIT AND SEE WHAT THEY SAY. I AM AFRAID SOMEONE COULD GET HURT OR KILLED FROM A TIRE BLOWOUT. THE TIRES ARE CONTINENTAL CROSS SECTION LX SPORT RATING 'H,' AND THE TOP SPEED OF THIS MAKER'S TIRE IS 130 MPH; HOWEVER, THIS MOTORCAR CAN AND HAS REACHED 144 MPH.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
I was in an accident that was can be contributed to my lane keeping assistance. Once the car crashed into another vehicle my airbags failed to deploy.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
I was in an accident that was can be contributed to my lane keeping assistance. Once the car crashed into another vehicle my airbags failed to deploy.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .