2011 Audi A3 Problems

Airbag warning light came on. Dealer said passenger seat occupancy sensor must be replaced, at cost of $1500-3000 since it's 5 months past my warranty. Numerous Audi models from 2012 onward have a recall for this sensor, but not my 2011 model (yet). Other automakers have extended their warranty for this safety-critical part -- BMW to 15 years, for example. Technicians could not tell me if the sensor error means all airbags are disabled, passenger airbag only is disabled, or passenger airbag is always-on (dangerous for children).

TL* THE CONTACT OWNS A 2011 AUDI A3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V082000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AUDI FLATIRONS (13321 W MIDWAY BLVD, BROOMFIELD, CO 80020, (866) 604-3244) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

MY SON WAS DRIVING MY 2011 AUDI A3 TDI TO THE GYM AT NIGHT WHEN HE CALLED ME THE CAR WOULD NOT ACCELERATE AND HAD A WARNING LIGHT COME ON. I TOLD HIM TO GOOGLE IT AND HE FOUND OUT IT WAS A GLOW PLUG INDICATOR. I TOLD HIM TO CONTINUE DRIVING IT IN THE LIMP MODE. THE CAR DIED WHILE MOVING AND MY SON WAS ABLE TO COAST INTO A PARKING LOT. THIS COULD OF BEEN A DIFFERENT STORY ON A BUSY INTERSTATE. I HAD TO PICK HIM UP AND HAD THE CAR TOWED IN THE MORNING. TO FIND OUT THIS CAR IS NOTORIOUS FOR CATASTROPHIC HIGH PRESSURE FUEL PUMP FAILURE AND THAT IS EXACTLY WHAT HAPPENED. WHEN I SAY CATASTROPHIC, METAL IS SHREDDED AND GOES INTO THE INJECTORS AND CONTAMINATES EVERYTHING THAT CARRIES FUEL. IT IS ABOUT A 7K TO 8K REPAIR. I HAVE USED NOTHING BUT LOW SULFUR DIESEL. IT'S RIDICULOUS A RECALL HASN'T BEEN ISSUED TO PREVENT THIS ISSUE. SINCE THIS HAPPENED I HAVE FOUND COMPLAINTS SCATTERED THROUGHOUT THE INTERNET.

I WAS AT THE TAIL END OF A 400 MILE TRIP-ALL FREEWAY DRIVING. AFTER EXITING THE FREEWAY, THE CAR WAS SLOWLY LOSING POWER. THE GLOW PLUG LIGHT CAME ON. CAR STALLED AFTER 1/2 MILE. I TRIED TO RESTART IT. IT WOULD NOT START. THE GLOW PLUG AND CHECK ENGINE LIGHT WERE ON. TOWED TO DEALERSHIP TO FIND THE HIGH PRESSURE FUEL PUMP SEND METAL INTO MY FUEL SYSTEM AND ENGINE. I HAVE JUST OVER 50,000 MILES ON THE CAR. THE REPAIR IS COVERED DUE TO THE FAULTY PART. AUDI SHOULD HAVE TO TAKE THE CAR BACK BECAUSE THEY KNEW ABOUT THIS PROBLEM. INSTEAD OF DOING A RECALL, THEY ALLOWED THE CAR TO BE DRIVEN AND NOW MY ENGINE IS AFFECTED. I TRIED TO ARRANGE A TRADE-IN AT A LOCAL SUBARU DEALERSHIP AND THEY OFFERED ME LOW BLUE BOOK MINUS $10,000. MY CAR IS NOT ONLY UNDESIRABLE, BUT WORTHLESS.

COOLANT PUMP- AUDI ACTION CODE-19L2-"THE COOLANT PUMP MAY DEVELOP A SMALL LEAK OVER TIME." MY AUDI SUFFERED A COOLANT LEAK AND HAD TO FIX FOR $1100 IN DIAGNOSIS/REPAIRS. I REPAIRED IT ON MY OWN AND LATER I LEARNED THAT THERE WAS A RECALL FROM AUDI. I NEED TO GET MY REIMBURSEMENT FOR THE MONEY I PUT UP TO FIX COOLANT LEAK.

I WAS AT THE TAIL END OF A 400 MILE TRIP-ALL FREEWAY DRIVING. AFTER EXITING THE FREEWAY, THE CAR WAS SLOWLY LOSING POWER. THE GLOW PLUG LIGHT CAME ON. CAR STALLED AFTER 1/2 MILE. I TRIED TO RESTART IT. IT WOULD NOT START. THE GLOW PLUG AND CHECK ENGINE LIGHT WERE ON. TOWED TO DEALERSHIP TO FIND THE HIGH PRESSURE FUEL PUMP SEND METAL INTO MY FUEL SYSTEM AND ENGINE. I HAVE JUST OVER 50,000 MILES ON THE CAR. THE REPAIR IS COVERED DUE TO THE FAULTY PART. AUDI SHOULD HAVE TO TAKE THE CAR BACK BECAUSE THEY KNEW ABOUT THIS PROBLEM. INSTEAD OF DOING A RECALL, THEY ALLOWED THE CAR TO BE DRIVEN AND NOW MY ENGINE IS AFFECTED. I TRIED TO ARRANGE A TRADE-IN AT A LOCAL SUBARU DEALERSHIP AND THEY OFFERED ME LOW BLUE BOOK MINUS $10,000. MY CAR IS NOT ONLY UNDESIRABLE, BUT WORTHLESS.

answering questions above: -body control module fuse, possibly engine comopartment fuse box itself -intermittent exterior lighting outages -no dealer / independent service center has inspected -not been inspected by anyone -no warnings, just bulb-out warnings once the issue started longform description: Last week, I was experiencing intermittent light outages on the right side of my car (2011 audi a3 TDI) . It started wednesday 3/22, during my morning commute to work, when I was exiting highway and turned on my right turn signal all the exterior lights on the right side of my car started flickering, and stopped. Same thing happened the next morning, except worse, applying my brakes would disable my right headlight. I stopped driving until the weekend when I drove over to get my car scanned for errors by a buddy of mine who has a diagnostic tool. It pointed to the body control module. With the car on, he gave the body control module fuse a light wiggle, and smoke started pouring out. He turned the car off and took out the fuse, one of the contacts melted into two pieces, and the plastic housing the fuse is full of bubbles. It seems that the engine fuse box for this car is poorly designed, and audi knows this as they've updated the part, but no recall was started. A recall was initiated for a similar issue on Tiguans manufactured around the same time (Recall no. 13V569000). Crazy to think that while I was driving around, there could have been smoke pouring out of my engine compartment fuse box, seems pretty dangerous. And I'm not the only one as people online call this the "infamous audi/vw melted fuse box issue".

TL* THE CONTACT OWNS A 2011 AUDI A3. WHILE DRIVING 40 MPH AT NIGHT, THE EXTERIOR LIGHTING POWERED OFF INTERMITTENTLY. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE NORMALLY. THE FAILURE RECURRED THREE TIMES. IN ADDITION, MULTIPLE ELECTRICAL WARNING INDICATORS ILLUMINATED AND BOTH TURN SIGNALS, BRAKE LIGHTS, AND THE PASSENGER SIDE HEADLIGHT STOPPED WORKING. THE VEHICLE WAS TAKEN TO AUDI OF MISSION VIEJO (LOCATED AT 28451 MARGUERITE PKWY, MISSION VIEJO, CA 92692, (949) 359-4053), WHERE IT WAS DIAGNOSED THAT THE PLASTIC BODY OF FUSE F16 MELTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

INTERMITTENT FAILURE OF EXTERIOR LIGHTS TO INCLUDE HEADLIGHTS, TURN SIGNAL LIGHTS, AND BRAKE LIGHTS DURING DRIVING. THE FIRST OCCURRENCE WAS AT NIGHT. FAULT SEEMS TO BE (ENGINE) TEMPERATURE DEPENDENT (I.E. - DOES NOT SEEM TO OCCUR WHEN ENGINE BAY IS COLD). ISSUE CONTINUED TO OCCUR INTERMITTENTLY FOR SEVERAL DAYS (UNTIL THE PARTS IN THE FOLLOWING DESCRIPTION WERE REPLACED). THE PLASTIC HOUSING FOR A 30 AMPERE FUSE (POSITION F16) IN THE ENGINE COMPARTMENT WAS PARTIALLY MELTING. THE MELTED FUSE RESIDUE WORKED ITSELF INTO THE FUSE BOX TERMINALS (CAUSING DAMAGE OF THE FUSE BOX) AND CAUSING A FAULTY CONNECTION WHICH IN TURN CAUSED THE INTERMITTENT FAILURES OF THE EXTERIOR LIGHTS. I HAVE ATTACHED PICTURES OF THE F16 (POSITION) 30 AMPERE FUSE SHOWING ITS PARTIALLY MELTED PLASTIC BODY AND THE FUSE HOLDER BLOCK (ALSO WITH PARTIALLY MELTED CONTACT POSITION / TERMINAL AREA). UPON FURTHER INVESTIGATION, THE FAULT IS EXACTLY THE SAME AS A CURRENT NHTSA CAMPAIGN ID 13V569000 FOR A VW (A SISTER COMPANY OF AUDI) IN BOTH THE FUSE LOCATION AND ITS AFFECTS. IT'S NOT UNCOMMON FOR VW AND AUDI TO USE SAME PARTS. FAILURE OF EXTERIOR LIGHTS (ESPECIALLY AT NIGHT) IS EXTREMELY HAZARDOUS. INTERNET SEARCH SHOW MULTIPLE OCCURRENCES OF THE SAME ISSUE FOR AUDI A3 (SIMILAR MODEL YEARS). OWNER HAS THE FAULTY PARTS (FOR YOUR INSPECTION IF NEED BE). THANK YOU.

TL* THE CONTACT OWNS A 2011 AUDI A3. WHILE DRIVING 40 MPH AT NIGHT, THE EXTERIOR LIGHTING POWERED OFF INTERMITTENTLY. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE NORMALLY. THE FAILURE RECURRED THREE TIMES. IN ADDITION, MULTIPLE ELECTRICAL WARNING INDICATORS ILLUMINATED AND BOTH TURN SIGNALS, BRAKE LIGHTS, AND THE PASSENGER SIDE HEADLIGHT STOPPED WORKING. THE VEHICLE WAS TAKEN TO AUDI OF MISSION VIEJO (LOCATED AT 28451 MARGUERITE PKWY, MISSION VIEJO, CA 92692, (949) 359-4053), WHERE IT WAS DIAGNOSED THAT THE PLASTIC BODY OF FUSE F16 MELTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

VEHICLE DOES NOT SWITCH GEARS PROPERLY. ONCE DRIVE GEAR IS SELECTED THEN THE GEAR INDICATOR FLASHES (EX. THE D FLASHES OR P FLASHES). VEHICLE DOES NOT SWITCH GEARS UNTIL 5500 RPM IS REACHED. AND VEHICLE DOES NOT ENGAGE R GEAR ONCE CAR HAS BEEN IN DRIVE. HAVE TO TURN VEHICLE OFF AND BACK ON TO GET TO R. VEHICLE IS PRETTY MUCH NOT DRIVABLE IN CURRENT CONDITION AS IT NEEDS TO BE SHUT OFF AND TURNED ONE MULTIPLE TIMES JUST TO PARK THE CAR. SOMETIMES BEHAVES NORMALLY FOR SHORT BURSTS.

THE CAR IS JERKING IN BETWEEN 1ST AND SECOND GEAR. SEEMS THE TRANSMISSION CANT DECIDE TO STAY IN 1ST OR SECOND. ALSO- THE CAR SHIFTS DOWN TO 1ST INAPPROPRIATELY QUICKLY. *TR

I WAS DRIVING ALONG THE NY STATE THRUWAY IN ALBANY AT 65-70 MILES AN HOUR. I REALIZED I WAS UNABLE TO ACCELERATE AND SAW THAT THE GLOW PLUG LIGHT WAS FLASHING. I SLOWED DOWN AND TRIED TO MOVE OVER TO THE RIGHT, BUT AS I SLOWED, THE CAR STALLED AND I WAS IN THE MIDDLE LANE. I WAS IN THE MIDDLE LANE WITH CARS PASSING ME ON EITHER SIDE AND I WAS UNABLE TO RESTART MY CAR. IT WAS SO SCARY. I COULDN'T GET OUT, I WAS ALONE. I DIDN'T KNOW WHAT TO DO, I FELT MY LIFE WAS IN DANGER, UNABLE TO GET OUT OF MY CAR. I GOT MYSELF TOGETHER ENOUGH TO CALL AAA. THEY CALLED THE POLICE TO HELP ME WITH TRAFFIC. I WAS PUSHED TO THE SIDE OF THE ROAD DODGING CARS AND TRYING NOT TO GET HIT. AAA CAME 1 HOUR LATER; IT WAS 12:00PM, HOT AND HUMID ON THE LABOR DAY HOLIDAY! THEY TOWED ME TO THE NEAREST AUDI DEALER WHICH WAS 20 MILES AWAY. I HAD TO PAY FOR THE EXTRA MILES. I AM 3 HOURS FROM HOME WITH NO IDEA WHAT I AM GOING TO DO. MY DAUGHTER HAD TO COME PICK ME UP AND DRIVE ME BACK HOME. NOW MY CAR IS IN ALBANY AND I AM IN MASSACHUSETTS. I DON'T KNOW WHAT IS WRONG WITH MY CAR OR HOW I AM GOING TO GET MY CAR BACK. THIS WAS A VERY SCARY, UNACCEPTABLE INCIDENT! *TR

PURCHASED A NEW 2011 AUDI A3 TDI LAST SATURDAY. THE FOLLOWING FRIDAY WHILE PULLING OUT INTO AN INTERSECTION THE DSG TRANSMISSION BRIEFLY WENT INTO NEUTRAL AND I SAW THE TACHOMETER NEEDLE SHOOT UP AND HEARD THE ENGINE WHINE. I WAS IN MANUAL MODE AT THE TIME. I DOWN SHIFTED AND LET OFF THE GAS AND IT RE-ENGAGED. THE FOLLOWING DAY (TODAY) THE SAME THING HAPPENED AGAIN. THIS TIME I WAS ALSO IN MANUAL MODE AND WAS AGAIN PULLING OUT INTO TRAFFIC FROM AN ALMOST COMPLETE STOP. I WILL BE CALLING THE DEALER MONDAY, BUT IN THE MEANTIME I HAVE SINCE LEARNED THAT THIS IS AN ONGOING AND KNOWN ISSUE WITH VW / AUDI DSG TRANSMISSIONS. *TR

I RECENTLY STARTED TO USE THE BACK PART OF THE CAR, NEVER HAD USED IT BEFORE HAD ANOTHER CAR FOR DOGS AND BIKES. THE AREA WHERE THE SPARE TIRE IS MADE OUT OF CARDBOARD, WILL NOT HOLD 125 LAB DOG OR A BIKE. WENT TO DEALER SAID THEY WOULD REPLACE THE PIECE AND SPLIT THE COST. PIECE IS NOT BROKEN, 1/2 THE CAR IS NOT USABLE, IF I PUT MY 125 LAB BACK THERE SHE WOULD FALL INTO THE SPARE TIRE. AUDI DOES NOT THINK THIS IS A PROBLEM. IT IS DANGEROUS TO HAVE KIDS, BIKE OR DOGS BACK THERE. UNSAFE. I HAVE BEEN EMAILING AUDI CORPORATE AND DEALER- LOTS OF TALK AND NO SOLUTIONS. THE CAR IS WONDERFUL, THEY JUST FELL ASLEEP WHEN THEY MADE THE TRUNK AREA. DANGEROUS!! *TR

YOU MOBILE PHONE CONNECTS TO THE AUTOS RADIO SYSTEM. THE AUTOS DEFAULT RING VOLUME IS AT AN UNSAFE VOLUME AND CANNOT BE MODIFIED. TWO AUDIOLOGISTS HAVE BOTH ATTESTED TO THE FACT THAT THE VOLUME IS AT AN UNSAFE LEVEL. AUDI SAYS THE REALIZE THE PROBLEM, BUT WILL OFFER NO FIX. I AM CONCERNED FOR MY HEARING AND FOR MY WIFE AND CHILD. *TR

ESP malfunctioned while driving on highway: tires braked several times rapidly on one side without warning, making car difficult to control. Immediately took foot off gas and had to steer out of a small fishtail. At the time I was driving at normal speed, not cornering aggressively or anything, on a smooth dry road. In heavy traffic or on a wet road this could have resulted in a crash. On just a couple occasions shortly before this occurred, while going around corners at highway or near-highway speeds there was a sensation that the steering direction suddenly "slipped" a notch, with a sort of thunk from the tires. At the time I attributed it to unseen road bumps, but after experiencing the more serious failure I realized it was the same asymmetrical braking just on a smaller scale. No warning lights gave any indicator of this dangerous sensor fault. During the most serious incident, the ESP light flickered briefly but that is the only time any lights appeared at all. I would expect this system to "fail safe" by deactivating, rather staying active and risking loss of control. Dealer garage said the problem "might" be the ESP sensor yaw rate sensor (G202) but can't guarantee that will fix it. I found several reports online of others experiencing loss of control due to Audi A3 ESP malfunction: 1) https://www.audi-sport.net/xf/threads/esp-driving-me-nuts.225172/ 2) https://www.audi-sport.net/xf/threads/yaw-sensor-g202-replacement-location.350445/ 3) http://www.vask.org.nz/index.php?topic=41577.0