2016 Audi A5 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Audi A5, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine337.5%
- Powertrain (other)225.0%
- Body & structure112.5%
- Electrical112.5%
- Steering112.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The drive chain broke, causing permanent damage to the engine which requires a complete engine replacement. The car was 5 + years old with 38,000 miles on it and well maintained.
TL* THE CONTACT OWNS A 2016 AUDI A5. WHILE THE CONTACT WAS MAKING A THREE POINT TURN WITH THE SHIFTER IN THE REVERSE POSITION, THE VEHICLE ABRUPTLY ACCELERATED FORWARD AND MOVED APPROXIMATELY 3 TO 5 FEET WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT ALSO INDICATED THAT THE VEHICLE LOST POWER AND WOULD NOT PROPERLY ACCELERATE ON SEVERAL OCCASIONS. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. AUDI OF EATONTOWN (95 NJ-36, EATONTOWN, NJ) WAS NOTIFIED OF THE FAILURES. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 35,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
The drive chain broke, causing permanent damage to the engine which requires a complete engine replacement. The car was 5 + years old with 38,000 miles on it and well maintained.
TL* THE CONTACT OWNS A 2016 AUDI A5. WHILE THE CONTACT WAS MAKING A THREE POINT TURN WITH THE SHIFTER IN THE REVERSE POSITION, THE VEHICLE ABRUPTLY ACCELERATED FORWARD AND MOVED APPROXIMATELY 3 TO 5 FEET WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT ALSO INDICATED THAT THE VEHICLE LOST POWER AND WOULD NOT PROPERLY ACCELERATE ON SEVERAL OCCASIONS. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. AUDI OF EATONTOWN (95 NJ-36, EATONTOWN, NJ) WAS NOTIFIED OF THE FAILURES. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 35,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
On August 3, 2025, my wife and I came home from dinner and I couldn’t get out of the driver’s side door. I took it to Naples Audi where I bought the car and delt with its Assistant Service Manager and Service Advisor. Audi estimated the repair to be over $1,300. I called Audi USA Regional Customer Service and Mike B opened a Case 06968056 for me. He got back to me today, August 7, and said Audi Corporate and Naples Audi will still make me pay $800 to do the repair. I'm submitting this claim because an inoperable door handle is a huge safety problem and liability to any Audi owner. The parts to repair cost $500, which includes a part to connect the interior handle to the door latch that opens the door, and 4 bolts! I found out the interior part of the door handle is made of plastic – unbelievably not metal. Audit Assistant Service Manager told me over time, especially in the southwest Florida heat, the plastic can become brittle and crack off the latch. One would think Audi Engineers would know to use metal versus plastic for this critical part that enable the door to open. Audi should fully cover the cost to fix my car due to “engineering mistake.” The part wasn’t broken based on anything I, or any other consumer, could do to provide service maintenance to keep this plastic part from cracking. This breakdown of the driver’s side door not being able to let me out, is a huge safety problem for anyone driving this car.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
Car went into limp mode and check engine light came on.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
Electromechanical steering rack has gone out. Had this completely failed while driving myself and others could be put in serious harm of a collision or crash. There are many online complaints and issues with the audi steering racks. No other warnings then it just went out at the same time it tells you stop driving.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .