2016 Audi A6 Electrical Problems

Engine area of car caught fire with ignition off

NHTSA ID

11625896

Incident

Nov 2, 2024

The contact owns a 2016 Audi A6. The contact stated that while driving approximately 40 MPH, the vehicle suddenly experienced a loss of motive power and stalled. During the failure, the message Electric Power Control "EPC" was displayed. The vehicle was later towed to the local dealer who diagnosed that the electric wiring harness located in the engine compartment had failed due to moisture intrusion and the harness along with an internal computer needed to be replaced. No further information was available. The vehicle was not yet repaired. The failure mileage was 49,000.

NHTSA ID

11586615

Incident

Apr 22, 2024

Mileage

49,000 mi

I took the vehicle into a repair shop because the check engine light is on. I was advised that the water pump is leaking and it needs to be replaced along with the thermostat. The turbo charger assembly also needs to be replaced. Both of these items appear to be deficient and were listed under recent recalls on similar Audi vehicles and this VIN was not included in either recall. However, it appears to be a similar concern and should be resolved by the Manufacturer.

NHTSA ID

11583388

Incident

Apr 16, 2024

The contact owns a 2016 Audi A6. The contact stated that the vehicle had shuddered and failed to accelerate on several occasions. There was no warning light illuminated. Additionally, the contact stated while driving at an undisclosed speed, the vehicle emitted an abnormal sound. The vehicle was taken to an independent mechanic where it was diagnosed that the spark plugs and the fuel rails needed to be replaced. The spark plugs were replaced. However, the fuel rails were not replaced. An unknown dealer was notified of the failure and an appointment was scheduled. The dealer also informed the contact of prior recall repairs that had been completed on the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that they could not assist as the VIN was not included in any recalls. The failure mileage was 70,240.

NHTSA ID

11479044

Incident

Aug 8, 2022

Mileage

70,240 mi

The contact owns a 2016 Audi A6. The contact stated the emergency lights were illuminated. The vehicle loss coolant and overheated. The stop immediately message was displayed. The vehicle was taken to an independent mechanic who stated that the engine coolant housing assembly needed to be replaced. The vehicle was repaired. The local dealer was not contacted. The manufacturer was notified and referred the contact to NHTSA. The failure mileage was approximately 51,000.

NHTSA ID

11435089

Incident

Sep 10, 2021

Mileage

51,000 mi

OK PURCHASED THE CAR OCTOBER 2019, IMMEDIATELY NOTICED A BURNING SMELL, IN THE CAR. TOOK OUT TO AUDI MULTIPLE TIMES ASK IF THERE WAS A LEAK, BEFORE THE WARRANTY RAN OUT. THEY SAID NO, NOW A YEAR LATER MY CHECK ENGINE LIGHT HAS COME ON. ONE DIAGNOSTIC DONE AT JIFFY LUBE READ A CODE THAT SAYS IT IS THE COMPUTER AUXILIARY OUTPUT. TOOK THE CAR TO AUDI TO DO A SECOND DIAGNOSTIC, THEY SAID ITS THE THERMOSTAT, AND COOLANT PUMP. MY CAR IS NOT EVER HEATING AND THE HEAT AND AIR WORK FINE. HOW IS IT NOW THAT THE CAR IS NOT UNDER WARRANTY THEY NOTICE THE LEAK IN THE COOLANT PUMP, WHEN I COMPLAINED ABOUT THE SMELL OF BURNING WATER WHEN I FIRST PURCHASED THE CAR. THERE ARE NO INDICATIONS OF A LEAK ON MY DRIVEWAY. THE DEALERSHIP HAS QUOTED ME 1683.00 THOUGH THERE IS A RECALL ON THE SAME PARTS. A YEAR AGO WHEN I PURCHASED THE CAR THERE WERE FAULTY ISSUES WITH THE COMPUTER. AUDI DID REPLACE THIS UNDER WARRANTY, BUT A MONTH AGO THE COMPUTER WOULD NOT COME ON SEVERAL DIFFERENT TIMES. CALLED THE DEALERSHIP TOLD THEM IT WAS ON AND OFF THEY SAID TO BRING IN IF IT CONTINUES. SOON AFTER THE CHECK ENGINE LIGHT COMES ON, AND NOW ALL OF A SUDDEN ITS A LEAK IN THE COOLANT PUMP ALLEGEDLY. I REPEATEDLY ASKED THEM IF THE CA HAD A LEAK WHEN I FIRST BOUGHT IT ONLY BECAUSE THE ENGINE WAS GIVING OFF THE BURNT SMELL. THEY WAITED UNTIL THE CAR WAS OUT OF WARRANTY TO AGREE WITH ME. THERE IS A RECALL TO FIX THE COOLANT PUMPS ON THE AUDI BUT THEY ARE WANTING TO CHARGE ME TO REPAIR MINE. RIGHT NOW THE VEHICLE SHUT OFF ON ME TONIGHT AND THE EPC LIGHT IS ON. CAR WILL NOT START, NOR WOULD THE ENGINE RECEIVE THE GAS WHEN TRYING TO ACCELERATE. ONLY BEEN DRIVING THE VEHICLE FOR A YEAR, I SHOULD NOT HAVE MAJOR ISSUES WITH IT AS OF NOW.

NHTSA ID

11395680

Incident

Oct 3, 2019

Mileage

38,000 mi

GOT A WARNING LIGHT THAT ADAPTIVE CRUISE AND BRAKING WERE NOT AVAILABLE. ACCORDING TO THE SERVICE DEPT. THERE WAS A SEAM IN THE BODY THAT WAS NOT WELDED PROPERLY IN THE MANUFACTURING PROCESS. I HAVE 6500 MILES ON MY CAR. THEY SAID THAT WATER WAS LEAKING IN ON ELECTRICAL MODULES. THIS PROBLEM HAPPENS WHILE DRIVING.

NHTSA ID

10860975

Incident

Apr 11, 2016

Mileage

6,500 mi

VEHICLE STUMBLES AND CUTS OFF AT A FEW MOMENTS OF IDLING. IT HAS ALSO LOST POWER AND THE GAINED IT BACK MOMENTS LATER AT RAPID PACE.

NHTSA ID

10845864

Incident

Mar 9, 2016

Mileage

1,560 mi