2020 Audi Q7 Problems

I am filing a complaint concerning serious safety risks associated with my 2020 Audi Q7 (VIN: [XXX] ) purchased as a Certified Pre-Owned vehicle from Audi Dominion San Antonio. It is currently under service at Audi Central Houston, where multiple concerning events occurred. Timeline and Issues: - Initial diagnosis identified a fire-damaged electrical harness, estimated at $1,400 for replacement. - After repair attempts, the vehicle began smoking, and the diagnosis expanded to include additional compromised electrical lines. The revised quote skyrocketed to $4,700 (later reduced to $3,100). - After nearly two months in service, I was informed that the AC compressor is now deemed "bad" due to debris from the harness, an issue not mentioned in previous inspections. Safety Concerns: 1. Inconsistent Diagnosis: There was no mention of compressor damage during initial assessments. This late-stage discovery indicates negligence or potential additional damage during servicing. 2. Risky AC Activation: A technician attempted to clean the compromised AC compressor and activated the system, a procedure that is dangerous given the debris. This could lead to refrigerant leaks and electrical shorts. 3. Conflicting Statements: Audi Central Houston claims the compressor was previously damaged but also attempted to restore it. Such contradictions raise serious concerns about service integrity. 4. Certified Pre-Owned Credibility: The emergence of these costly issues questions the reliability guarantees of vehicles sold under Audi's Certified Pre-Owned program. Given that the vehicle began smoking shortly after being parked and had not undergone prior electrical work, I underscore the severe safety risks posed by potential electrical fires and undisclosed damage. These issues could endanger lives and property if not properly addressed. I strongly urge Audi USA and the NHTSA to investigate this matter for potential technical service bulletins or recalls, especially fo INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION A

In July 2023, my 2020 Audi Q7 experienced a complete electrical failure at highway speeds due to a Belt Starter Generator (BSG) malfunction. Audi replaced the BSG with the same faulty part. Months later, I noticed increased oil consumption and loud engine noise. Despite multiple service visits and reporting these issues, Audi failed to properly diagnose the problem. In January 2025, despite a clear check engine light indicating a problem, Audi dismissed my concerns. Just weeks later, in February 2025, the engine catastrophically failed due to undiagnosed internal damage. Audi repeatedly ignored diagnostic warnings and failed to address my complaints, putting my safety at risk. Audi consistently dismissed my concerns, attributing engine noise and oil consumption to normal wear. The failures posed safety risks, including sudden loss of power while driving. Despite documented defects, Audi refused to take responsibility or perform proper diagnostics, resulting in continued safety hazards. I am formally requesting NHTSA to investigate the widespread issues affecting the 2020 Audi Q7, including the BSG system and excessive oil consumption leading to engine failure.” Additional Details: •Component/System Failure: The 48V Belt Starter Generator (BSG) and the engine failed. The vehicle is available for inspection upon request. •Safety Risks: The electrical failure at highway speeds caused a sudden loss of power. The engine failure posed a risk of the vehicle shutting down unexpectedly while driving. •Problem Confirmation: The Audi dealership confirmed the engine failure and acknowledged the presence of metal shavings in the oil, indicating severe internal damage. •Inspections: The vehicle has been inspected by the Audi dealership, and Audi representatives acknowledged the issue. •Warning Signs: The check engine light illuminated in January 2025. Additional symptoms included loud engine noise (‘tractor-like’) and increased oil consumption, which Audi dismissed.

the first indication of an issue was oil consumption. It was using more oil than usual around the 70K mile mark. Then it started misfiring, and soon after a knocking noise coming from the engine. There are no check engine light on, after bringing it in for diagnostics, it read that it was a spark plug, once they got into the engine they discovered the cylinder had been stripped from the piston. Yes the diagnostics came from our foreign car mechanic. no, it has not been inspected by the manufacturer or police. Just the symptoms. sometimes the light would come on, and then it would go off. At this point it is off. All of this started in the fall of 2025.

While my vehicle was in for the Audi piston issue, they stated my water pump needed to be replaced and isn’t covered by a recall (yet). My vehicle had less than 42,000 mile on it. I was lead to believe that this problem is coming up more often and they believe a class action lawsuit will come about. I needed to pay over $1,700 out of pocket and was told I was saving so much money because they already had the engine apart because of the piston recall. This is unacceptable.

In July 2023, my 2020 Audi Q7 experienced a complete electrical failure at highway speeds due to a Belt Starter Generator (BSG) malfunction. Audi replaced the BSG with the same faulty part. Months later, I noticed increased oil consumption and loud engine noise. Despite multiple service visits and reporting these issues, Audi failed to properly diagnose the problem. In January 2025, despite a clear check engine light indicating a problem, Audi dismissed my concerns. Just weeks later, in February 2025, the engine catastrophically failed due to undiagnosed internal damage. Audi repeatedly ignored diagnostic warnings and failed to address my complaints, putting my safety at risk. Audi consistently dismissed my concerns, attributing engine noise and oil consumption to normal wear. The failures posed safety risks, including sudden loss of power while driving. Despite documented defects, Audi refused to take responsibility or perform proper diagnostics, resulting in continued safety hazards. I am formally requesting NHTSA to investigate the widespread issues affecting the 2020 Audi Q7, including the BSG system and excessive oil consumption leading to engine failure.” Additional Details: •Component/System Failure: The 48V Belt Starter Generator (BSG) and the engine failed. The vehicle is available for inspection upon request. •Safety Risks: The electrical failure at highway speeds caused a sudden loss of power. The engine failure posed a risk of the vehicle shutting down unexpectedly while driving. •Problem Confirmation: The Audi dealership confirmed the engine failure and acknowledged the presence of metal shavings in the oil, indicating severe internal damage. •Inspections: The vehicle has been inspected by the Audi dealership, and Audi representatives acknowledged the issue. •Warning Signs: The check engine light illuminated in January 2025. Additional symptoms included loud engine noise (‘tractor-like’) and increased oil consumption, which Audi dismissed.

Central control module failure. Item is under recall for various Q5 models. Q7 is essentially the same car with same water intrusion problem. Why isn’t it included in recall. Very dangerous stall.

Often gets warning about Parking Brake malfunction. Dealership already checked once and could not find the problem. Warning comes on speedometer as follows: "Parking brake: malfunction! Please contact Service."

TWO ISSUES: THE SMALL PORTABLE AIR PUMP THAT CAME WITH THE CAR WOULD BLOW THE FUSE TO THE 12V CIGARETTE LIGHTER. AFTER A NEW FUSE IS PUT IN, THIS WOULD HAPPEN ON ABOUT EVERY THIRD OR FOURTH TIME OF USING OF THE PUMP. I HAVE REPLACED ABOUT 5 FUSES ALREADY. THE SECOND ISSUE IS THE SQUEAKING OF THE REAR BRAKES WHEN BACKING UP DURING COLD OR HOT. HOWEVER, IT DOES HAPPEN MORE WHEN COLD/IN THE MORNING. A FACTORY DEALERSHIP HAD LOOK AT THE ISSUE BUT FOUND NOTHING.

While driving, Forward Collision Warning appears without any reason. My understanding is that the car will brake itself if it senses frontal collosion and I am concerned that it might brake suddenly without my knowledge and cause an accident.

WHEN DRIVING WITH THE CRUISE CONTROL ON, THE VEHICLE AUTOMATICALLY ADJUSTS THE SPEED TO THE SPEED LIMIT. ON OCCASION, WHEN DRIVING AT FREEWAY SPEEDS, IT WILL PICK UP THE SPEED LIMIT FROM A CROSS STREET (OVER OR UNDER PASS). THIS HAPPENED ON A RECENT TRIP WITH THE VEHICLE SET AT THE SPEED LIMIT OF 75, THEN SUDDENLY AND AUTOMATICALLY BRAKING BECAUSE IT DETECTED A 45 MPH CROSS STREET. WITH MOST TRAFFIC MOVING AT 75 MPH, THIS WAS EXTREMELY DANGEROUS TO SUDDENLY BRAKE FOR NO APPARENT REASON WITH PEOPLE RIGHT BEHIND US. WE CAN NO LONGER US OUR CRUISE CONTROL BECAUSE OF THIS. THE AUDI DEALERSHIP COULD NOT REPLICATE THIS ISSUE. IT ONLY HAPPENED TO US IN A SMALL NUMBER OF CIRCUMSTANCES, BUT WAS DANGEROUS AND FRIGHTENING WHEN IT DID. THE AUTOMATIC SPEED ADJUST ALSO APPARENTLY CANNOT BE TURNED OFF. THE DEALERSHIP DID MENTIONED THEY WERE AWARE OF ANOTHER AUDI VEHICLE THEY HAD SEEN WITH THE SAME ISSUE.

My 2020 Audi Q7 with 49,500 miles had a complete engine shut down while driving. Towed to Audi. Fuel Pump was recalled and replaced on 1/2023. Audi stated it was the jet suction pump inside the saddle fuel tank. Research discovered that this saddle tank has been problem for this model and year. Audi only covered a portion of the cost. The entire fuel tank had to be replaced. 16 days to complete.

The contact owns a 2020 Audi Q7. The contact received notification of NHTSA Campaign Number: 22V516000 (Fuel System, Gasoline); however, the contact was informed by local dealers that parts were on backorder. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.