Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 16 NHTSA owner-reported complaints for the 1993 Audi S4. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–16 of 16
THIS WAS A CONSUMER CALL RECEIVED BY REGIONAL OFFICE STAFF, AND IS BEING RELAYED. VEHICLE HAS AN ACTIVE FUEL SYSTEM RECALL, AND DEALER IN SALT LAKE CITY, UT SCHEDULED REPAIR, BUT CANCELLED THE REPAIR APPOINTMENT DUE TO NOT HAVING PROPER BILLING CODE TO BE REIMBURSED FOR THE REPAIR BY THE MANUFACTURER. PLEASE CONTACT CONSUMER DIRECTLY FOR FURTHER DETAILS AND TO ASSIST HIM IN RESOLVING THIS ISSUE.
I OWN TWO OF THE ORIGINAL AUDI S4'S, BOTH 1993 MODELS. MY DAUGHTER WAS DRIVING ONE OF THESE CARS IN 2007 AND THE THROTTLE STUCK OPEN SO THAT THE ENGINE RACED UNCONTROLLABLY. SHE WAS ABLE TO PUT THE CLUTCH IN AND STOP THE CAR AND TURN THE ENGINE OFF. THEN SHE HAD THE CAR TOWED TO THE NEAREST REPAIR SHOP. IT WAS DISCOVERED THAT A PLASTIC PART ON THE TIP OF THE THROTTLE CAM HAD BROKEN OFF AND AS A RESULT THE THROTTLE CABLING MECHANISM STUCK IN THE PARTIALLY "OPEN" POSITION. I HAD THE THROTTLE CAM REPLACED WITH AN ALL STAINLESS STEEL CAM WHICH CANNOT BREAK DOWN AS A RESULT OF HEAT, AS PLASTIC OR A SIMILAR PRODUCT CAN DO. I HAD OEM CAMS REPLACED IN BOTH S4'S. AUDI DEALER WAS NOTIFIED OF THE PROBLEM IN OCTOBER 2007. I HAVE RECOMMENDED TO AUDI THAT ALL 1992-1997 S4 AND S6 MODELS BE RECALLED AND THAT ALL THROTTLE CAMS BE REPLACED WITH AN ALL STAINLESS STEEL CAM (FOR EXAMPLE, ONE FABRICATED BY 034 MOTORSPORT IN FREMONT, CA.) AT LEAST ONE OTHER INSTANCE OF UNINTENDED ACCELERATION, DUE TO FAILURE OF THE OEM THROTTLE CAM, HAS BEEN REPORTED ON THE "WEB" -- IN FACT THAT REPORT LED ME TO 034 MOTORSPORT'S SOLUTION. I KNOW I NEVER RECEIVED, FROM AUDI, A NOTICE OF THIS POTENTIAL PROBLEM. DATE SHOWN BELOW IS APPROXIMATE. I WOULD HAVE TO FIND THE TOWING BILL TO BE PRECISE. *TR
I RUN A SMALL REPAIR SHOP AND HAVE SEEN A NUMBER OF AUDI VEHICLES FROM 1986 TO 1998 WHICH HAVE STEEL GASOLINE LINES THAT COLLECT ROAD SALT AND RUST IN THE RUBBER SUPPORT GROMMETS ATTACHED TO THE CHASSIS. THE RUST CAUSES A PINHOLE LEAK WHICH THEN BEGINS TO SPRAY GASOLINE ON THE EXHAUST SYSTEM. I HAVE SEEN 5 OR 6 VEHICLES LIKE THIS IN THE PAST 5 YEARS AND SAW ANOTHER ONE LAST WEEK. *TR
PLASTIC THROTTLE CABLE PIECE BROKE RESULTING IN STUCK THROTTLE CONDITION. FOR AN ACCOUNT OF THE INCIDENT ALONG WITH PHOTOS SEE THE URL BELOW. *NM HTTP://WWW.S-CARS.ORG/POSTNUKE/MODULES.PHP?OP=MODLOAD&NAME=NEWS&FILE=ARTICLE&SID=183
I HAD PREVIOUSLY CONTACTED NHSTA REGARDING FUEL LINE LEAKS IN THE ENGINE COMPARTMENT OF THE EALRY S4 AND S6 MODELS. THIS RESULTED IN THE "KY" RECALL CAMPAIGN. MORE RECENTLY, SOME OWNERS HAVE BEEN DISCOVERING LEAKS IN THE FUEL LINES GOING FROM THE REAR OF THE CAR TO THE FRONT. THESE LEAKS OCCUR AT THE POINT WHERE THE FUEL LINE GOES THROUGH RUBBER ISOLATION/MOUNTING BLOCKS. MOISTURE ACCUMULATES AT THESE POINTS AND CORRODES THE FUEL LINE RESULTING IN LEAKS. I DISCOVERED THIS ON MY OWN CAR IN EARLY 2002 AND I KEEP HEARING FROM MORE AND MORE PEOPLE FINDING THE SAME THING. THESE CARS HAVE BEEN EXTREMELY GOOD IN OTHER AREAS BUT THE FUEL SYSTEM PLUMING LEAVES MUCH TO BE DESIRED. DT
WHILE DRIVING DURING A RAINSTORM THE REAR END BROKE HARD TO THE RIGHT SENDING THE VEHICLE INTO A COUNTERCLOCKWISE SPIN, AS A RESULT THE VEHICLE HIT A LAMPOST.NLM
FUEL LINE FAILED WHERE BRAIDED LINE MEETS SOLID BRASS LINE. HAS HAPPENED IN MANY OTHER CARS OF THIS MODEL RELATIVE TO THE TOTAL NUMBER SOLD.
FAILURE IS WHERE HOSE FROM FILTER IS PRESS FIT TO METAL FUEL LINE
THE FAILED FUEL LINE WAS CUT OFF AND REPLACED WITH FUEL INJECTION HOSE AND CLAMPS.BY MY AUDI TRAINED MECHANIC. THIS REPAIR WAS NOT SUCCESSFUL AND THE FUEL BEGAN LEAKING AGAIN ON APRIL 1, 1999. I CONTACTED AUDI OF AMERICAN AT THE ADVISE OF THE AUDI S CAR INTERNET WEBSITE. MANY OTHER OWNERS HAD POSTED THE SAME PROBLEM. AOA INTERVENED AND THE REPAIR WAS MADE AT NO COST BY SCHAUMBURG AUDI IN ILLINOIS.
THE FUEL LINE FAILURE OCCURS INCHES FROM THE TURBO, CREATING A DANGEROUS FIRE HAZARD!
PLEASE SEE WEB SITE S-CARS.ORG F.A.Q RE LEAKING FUEL LINES.
FUEL LINE LEAK...NOTICED FAINT FUEL SMELL ON MORNING OF 6/5/99 (COLD WEATHER THAT MORNING).. THIS PROBLEM HAS BEEN FOUND BY SEVERAL OTHER OWNERS. I HAVE NOT BEEN TO A DEALER ABOUT IT, BUT I KNOW THAT IT IS A PROBLEM WITH MY CAR.
NO SUMMARY.
METAL FUEL LINE LEAKING ONTO ENGINE COMPARTMENT CAUSING FUMES TO ENTER PASSENGER COMPARTMENT OF VEHICLE. NLM
WHILE DRIVING THERE WAS A LOT OF VIBRATION IN FRONT END. ABS BRAKES WERE NOT FUNCTIONING/LOCKED UP, CAUSING VEHICLE TO VIBRATE. ALSO, FRONT LEFT WHEEL HAD SMOKE COMING FROM IT. DEALER HAD TO REPLACE ALL BRAKE ROTORS AND REAR CALIPERS. *AK
BOUGHT THE CAR FROM MY MOTHER WHO BOUGHT IT NEW JANUARY 1993 FROM HIGHLAND PARK AUDI, HIGHLAND PARK IL. NO SPECIFIC DEFECT CITED IN THE SUMMARY.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .