2013 Audi S5 Powertrain (other) Problems

NHTSA Safety Complaint DraftVehicle Information:Year/Make/Model: 2013 Audi S5 Premium Plus CoupeVIN: [XXX]: Power Train / Transmission (7-Speed Dual-Clutch S-Tronic / DSG)Description of Safety Defect:I am writing to report a severe, recurring safety defect regarding the 7-speed dual-clutch transmission in my 2013 Audi S5. The vehicle is experiencing catastrophic transmission issues, including sudden power loss, violent juddering, erratic shifting, and abruptly entering "limp mode" without warning.This issue presents an immediate and severe safety hazard. When the transmission abruptly loses power or forces the vehicle into limp mode while driving at highway speeds, it leaves the driver completely unable to accelerate or safely keep pace with surrounding traffic. This sudden, unpredictable loss of propulsion significantly increases the risk of a high-speed rear-end collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11744360

Incident

Jun 15, 2026

I had a very pricey service performed on my vehicle and during that service they said there was a service bulletin or recall that required a software upgrade for the transmission (Audi of El Paso, TX). Once that occurred, my transmission would shift very hard especially going from 1st to 2nd gear or downshifting from 2nd to 1st gear. My service advisor told me that my vehicle had to learn again and that it would smooth out in time. It never has. My vehicle with only 79,000 miles on it should certainly not be having any transmission issues, especially since they were non-existent until the software upgrade was applied. I have researched the issue and have found that it is a common and widely known issue in Audis with similar electronic transmissions. I was able to find well over a hundred Audi owners who documented the same issues. Due to this update my vehicle showed simultaneous warning for a TPMS failure and gearbox failure.

NHTSA ID

11646068

Incident

Jul 15, 2020

mechatronic unit failed incident : random jerking when driving had to pull the car over car lost power "gear box malfunction" code on my dashboard. after replacing the mechatornic unit had to pay 5127 dollars out of pocket to get fixed

NHTSA ID

11505091

Incident

Sep 30, 2018

while driving, got a notification on the dash board "transmission malfunction, limited functionality" and a "tpms malfunction" notification. Car seemed like it was skipping 1st and 2nd gear after i continued driving.

NHTSA ID

11419483

Incident

Jun 3, 2021

AFTER THE CAR SITS OVER NIGHT, AND IS DRIVEN W/O BRING WARMED UP IT SLIPS GOING INTO 1ST AND 2ND GEAR, ROUGH DOWNSHIFT OR SLIGHT BUMP WHEN COMING TO A STOP, AND A ROUGH IDLE AND NOISE COMING FROM THE TRANSMISSION WHEN IN PARK. CAR HAS 87K.

NHTSA ID

11373431

Incident

May 8, 2020

Mileage

79,000 mi

MY CAR WENT INTO LIMP MODE WHERE THE TRANSMISSION DOESN'T ENGAGE AND COME TO FIND OUT IT WAS THE MECHATRONIC UNIT IN THE TRANSMISSION AND A VERY WELL KNOWN PROBLEM. THE CAR WOULDN'T MOVE WHEN I WAS ON A BUSY ROAD. IT SAID CONTINUE TO DRIVE BUT I COULDN'T. IT HAPPENED AT 65K MILES. I HAD IT REBUILT FOR OVER $2000 AND THE CAR IS VERY WELL MAINTAINED.

NHTSA ID

11350133

Incident

Aug 3, 2020

Mileage

65,000 mi

MY VEHICLE AS WELL AS MANY AUDIS WITH THE MECHATRONIC SYSTEM ARE HAVING AN ISSUE THAT PRESENT A ERROR, " MECHATRONIC FAILURE TPMS GEARBOX MALFUNCTION). IT OFTEN EITHER NOT DRIVABLE, EVEN WHEN IN TRAFFIC OR DRIVES AT A SNAIL'S PACE WHEN ATTEMPTING TO EXIT TRAFFIC. AUDI CORPORATE SAID A RECALL IS ONLY DONE WHEN THE NHTSA FEEL THAT'S IT A ISSUE THAT CAN CALLS SAFETY &/OR DEATH. THIS SEEM TO EFFECT, FROM MY RESEARCH, 2010 - 2014 AUDI S4, S5 AND A5 MODEL [N THE USA AND THERE ARE SOME EUROPE COMPLAINTS, WHICH I HAVE FOUND AS WELL] MANUFACTORED AT A PARTICULAR PLANT OR PROVIDER. THIS TYPE OF MALFUNCTION CAN CERTAINLY CAUSE 'LOSS OF LIFE' AS IT OCCURS IN TRAFFIC. I HAPPEN TO LIVE IN METRO ATLANTA GA, WITH OUR FAST PACE TRAFFIC, ITS A SERIOUS ISSUE. THERE ABSOLUTELY SHOULD BE A RECALL. THE COST TO REPAIR CAN BE UP TO $15K. THERE IS NO WAY THIS SHOULD HAPPED TO A $60-$75 HIGH-END VEHICLE. HAVE VIDEO'S OF THE DASHBOARD WITH THE ERROR AND CAN UPLOAD TO YOU. I WAS OFFERED 15% ON THE REPAIR, WHICH IS REALLY AN INSULT. PLEASE LOOK INTO THIS ISSUE AND ITS NOT HARD TO FIND OTHERS WITH THIS ISSUE. I PRAY FOR SOME RELIEF IN THE FORM OF A RECALL. IT HAS BEEN HAPPENING SINE 2010, FROM WHAT I HAVE LEARNED.

NHTSA ID

11235288

Incident

Nov 1, 2018

Mileage

88,000 mi

TRANSMISSION FAULT CODE POPPED UP. TRANS BOGS WHEN TRYING TO START, ALMOST IN A LIMP MODE FOR THE TRANSMISSION. THE CODE COMES ON AND OFF SOMETIMES, AND DOESN'T ALLOW ME TO GO INTO MANUAL MODE. THE TRANS IS A DSG, AND IS ACTING VERY WEIRD. MECHATRONIC WAS TOLD TO BE REPLACED BY A EUROPEAN AUTO SHOP.

NHTSA ID

11203350

Incident

Apr 14, 2019

Mileage

89,000 mi

VEHICLE IS THROWING TRANSMISSION FAULT CODES, SHIFTING AS IF THE TRANS IS IN LIMP MODE, WHEN STOPPED AND THEN GOING, THE TRANS BOGS, AS WELL AS BETWEEN SHIFTS. DOESN'T GO INTO MANUAL MODE EITHER FOR THE DSG TRANS MY CAR HAS. A SHOP SAID THE METATRONIC UNIT NEEDS REPLACEMENT.

NHTSA ID

11203344

Incident

Apr 21, 2019

Mileage

89,000 mi

I WAS DRIVING ON THE FREEWAY ALL OF THE SUDDEN I LOST POWER AND FELT JERKY MOVEMENTS I HAD TO PULL OVER. OBVIOUSLY I HAD CHECK ENGINE LIGHT COME AND GEARBOX MALFUNCTION MESSAGE. THE PROBLEM TURNS OUT TO BE A MECHATRONIC ISSUE WITH MY VEHICLE THERE'S A TECHNICAL SERVICE BULLETIN ON IT TSB NUMBER IS 10054213-2278. ALTHOUGH I TRIED TO OPEN A CASE WITH AUDI USA. MY CASE GOT DENIED BECAUSE THEY STATED THE CAR IS OUT OF WARRANTY AND BECAUSE IT'S NOT A KNOWN ISSUE ON THE VEHICLE MODEL. I CAN UNDERSTAND THE WARRANTY PART BUT TO SAY THAT IS NOT A KNOWN ISSUE THAT QUALIFIES AS A NON ACCURATE STATEMENT SINCE THERE'S IS AN OFFICIAL TSB ON THE MATTER AND I TAKE THAT AS AN INSULT HONESTLY. I WOULD LIKE FOR SOMEONE TO ADDRESS THAT ISSUE AND MAYBE HAVE AUDI ACKNOWLEDGE THE PROBLEM MORE OPENLY SINCE IT'S SOMETHING THAT'S AFFECTS ALOT OF CUSTOMERS AND AUDI IS GETTING AWAY WITH POOR QUALITY CONTROL ON THEIR VEHICLES. THANK YOU AND HAVE A GOOD DAY

NHTSA ID

11112801

Incident

Jun 19, 2018

Mileage

76,000 mi