RoadVitals

2002 Beaver Coach Patriot Thunder

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Mar 5, 2007
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Jun 5, 2008
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

Overview

Our database contains 4 NHTSA owner-reported complaints for the 2002 Beaver Coach Patriot Thunder, most frequently naming the body & structure, brakes and electrical categories. 2 safety recalls have been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Body & structure120.0%
  • Brakes120.0%
  • Electrical120.0%
  • Other / unspecified120.0%
  • Tires & wheels120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
08V257000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Jun 5, 2008
8,587 units potentially affected
The defect: MONACO IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
The risk: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
The remedy: MONACO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR MONACO AT 1-800-685-6545.
MONACO COACH CORPORATIONManufacturer number R08017View on NHTSA.gov
02V004007

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Apr 9, 2002
232 units potentially affected
The defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
The risk: IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION BEGAN SEPTEMBER 9, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-344-6332 OR WILLIAMS CONTROL AT 1-503-684-8600.
MONACO COACH CORP.Manufacturer number R02198View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Brakes
Filed Mar 5, 2007

THE RIGHT FRONT BRAKE LINE WAS CUT BY THE HYDRAULIC JACK FOR THE LEVELING SYSTEM. ALL THE FLUID RAN OUT WHEN THE BRAKES WERE APPLIED. NO BRAKE WARNING LIGHTS CAME ON, SO DRIVER WAS NOT AWARE OF THE PROBLEM AND DROVE FOR SEVERAL DAYS UNTIL IT WAS FOUND BY INSPECTION. APPARENTLY, THE FRONT BRAKES ARE INDEPENDENT OF THE REAR BRAKES, SO THE PEDAL REMAINED NORMAL WHEN APPLIED. *JB

NHTSA ID
10184227
Incident
Feb 11, 2007
Mileage
34,000 mi
Electrical
Filed Sep 15, 2006
Fire reported

I HAVE 2002 BEAVER CONTESSA MOTORHOME WITH A 330 CATAPILLAR ENGINE. RECENTLY I EXPERIENCED A PROBLEM WITH MY ALTERNATOR WHICH TURNED OUT TO BE A BURNED WIRE IN THE WIRE HARNESS. THE WIRE CONNECTED FROM THE ALTERNATOR I TERMINAL TO THE STARTER RELAY. THE FIRE BURNED SEVERAL OTHER WIRES IN THE HARNESS AND SHORTED THE RADIO AND TWO GAUGES. THE WIRE COMPLETELY BURNED THROUGH BEFORE ADDITIONAL DAMAGE WAS DONE. *JB

NHTSA ID
10168362
Incident
Aug 23, 2006
Tires & wheels
Filed Jul 31, 2006

DRIVING FROM BULLHEAD CITY TO PALM DESERT ... LEFT HWY 10 AND WAS ON OLD ROUTE 66 WHEN FRONT DRIVER SIDE TIRE BLEW. THE OUTSIDE TEMPERATURES WERE 100 DEGREE PLUS AND THIS HAPPENED AROUND NOON. LUCKILY NO INJURY OR CRASH. TIRE BLEW OUT SIDE PANEL AND WADDED UP MUD FLAP. COULD HAVE BEEN BAD ACCIDENT. THIS BLOW OUT WAS ON A 2002 BEAVER PATRIOT THUNDER MOTORHOME W/455 CAT ENGINE .. TWO SLIDE OUT MODEL (GALLEY AND BEDROOM ON DRIVER SIDE). TIRE: TOYO HYPARADIAL 275/70R22.5 ...TIRES WERE DISPOSED OFF BECAUSE AT TIME COULDN'T FIND ANY RECALL INFO ON THEM...HAVE SINCE FOUND RECALLS BY COUNTRY COACH AND NATIONAL RV FOR INCIDENTS OF FRONT BLOW OUT WITH THIS TYPE TIRE DUE TO WEIGHT PROBLEM I BELIEVE. *NM

NHTSA ID
10164037
Incident
Jun 19, 2006
Mileage
20,000 mi
Body & structureOther / unspecified
Filed Jul 10, 2006

DT*: THE CONTACT STATED THAT THE REAR JACK ON DRIVER SIDE DETACHED DURING AUTOMATIC LEVELING OF THE VEHICLE AND COLLIDED WITH THE DRIVE SHAFT. INSPECTORS FROM THE DEPARTMENT OF TRANSPORTATION INSPECTED THE VEHICLE, AND DETERMINED THAT THE FAILURE WAS A RESULT OF THE SEPARATION OF THE MOUNTING BRACKET DUE TO SUPERFICIAL AND SPOTTY WELDING. THE MOUNTING BRACKET WAS OBSERVED TO HAVE ROUGH EDGES RESULTING IN POOR CONTACT WITH THE CHASSIS. THE REMAINING JACKS WERE OBSERVED TO BE IN THE SAME CONDITION DUE TO THE IDENTICAL WELDING OF THE DEFECTIVE PART. UPDATED 08/14/06*JB

NHTSA ID
10161960
Incident
Jun 14, 2006
Mileage
38,000 mi

Compare model years

Complaint and recall counts across every year of this model

Beaver Coach Patriot Thunder by model year
YearComplaintsRecallsInvestigationsIssue Index
2006010—
2005010—
2004010—
2003010—
2002Viewing420—
2001430—
2000130—
1999540—
1998020—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.