RoadVitals

1977 BMW 320I Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
4
Newest Jun 19, 1980
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

4 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

80V076000

VEHICLE SPEED CONTROL:SPRINGS

Jun 19, 1980
66,600 units potentially affected
The defect: WHEN SUBJECTED TO THE EXTREMELY HIGH TEMPERATURES THAT CAN OCCUR IN THE ENGINE COMPARTMENT, THE DAMPER SLEEVES WHICH COVER THE RETURN SPRINGS OF THE ACCELERATOR CONTROL SYSTEM CAN DEFORM AND PREVENT THEIR RETURNING THE THROTTLE TO IDLE POSITION AFTER RELEASE OF THE ACCELERATOR PEDAL.
The remedy: DEALER WILL REPLACE THE THROTTLE RETURN DAMPER SLEEVES WITH NEW SLEEVES OF HIGH TEMPERATURE-RESISTANT PLASTIC MATERIAL.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov
78V074000

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

Apr 4, 1978
28,819 units potentially affected
The defect: THE HEX HEAD BOLT THAT CONNECTS THE MAIN WIRING HARNESS TO TERMINAL #30 MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE.
The remedy: THE DEALER WILL REMOVE THE FUSE PANEL AND RETIGHTEN THE 5-MM HEX HEAD BOLT IN THE MAIN POWER TERMINAL UNDERNEATH THE FUSE PANEL, WITHOUT CHARGE TO OWNER.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov
78V061000

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

Mar 24, 1978
32,500 units potentially affected
The defect: DUE TO THE HIGH FUEL FLOW RATE IN THE FUEL SYSTEM, CONDITIONS OF EXTREME ALTITUDE, TEMPERATURES, OR FUEL CONTAMINATION, MAY LEAD TO THE FORMATION OF FUEL VAPOR BUBBLES.
The remedy: THE DEALER WILL INSTALL AN ADDITIONAL FUEL PUMP IN THE RIGHT SIDE OF THE FUEL TANK AT NO CHARGE TO OWNER.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov
77V092000

VEHICLE SPEED CONTROL:SPRINGS

Jun 16, 1977
22,850 units potentially affected
The defect: THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS". THE TWO ACCELERATOR RETURN SPRINGS LOCATED ON TOP OF ENGINE MAY OSCILLATE AT HIGH ENGINE SPEEDS, WHICH MAY CAUSE VIBRATION NOISE AND LEAD TO PREMATURE SPRING FATIGUE AND POSSIBLE BREAKAGE. THIS MAY MAKE IT IMPOSSIBLE FOR THE ACCELERATOR SYSTEM TO RETURN TO IDLE SPEED.
The remedy: DEALER WILL INSPECT AND, IF NECESSARY, INSTALL RUBBER SLEEVES OVER THE RETURN SPRINGS TO PRECLUDE OSCILLATION, WITHOUT CHARGE TO OWNER.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

DP78034ClosedDefect Petition

SPARK PLUG FOULING

Opened May 2, 1978
Closed Jul 24, 1978

SPARK PLUG FOULING

ELECTRICAL SYSTEM

Elsewhere on this vehicle

Data sources