Owner-reported complaints naming the exterior lighting system, filed with NHTSA
Data refreshed
Reports naming headlights, tail lights, turn signals and other exterior lighting. Every record below is an owner-reported complaint about the 2004 BMW 325XI submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
THREE RECALLS. FRONT DRIVERS AIR BAG, FRONT PASSENGER AIRBAG, BOTH REAR QUARTER PANEL LAMPS CARRIER CONNECTOR WIRES HEATED AND MELTED. CONTACTED BMW OF KINGSPORT SEVERAL TIMES FOR ASSISTANCE. SAID WOULD HELP BUT HAS NOT. NEED SCHEMATIC OF REAR TAILLIGHT ASSEMBLIES AND REPAIR OF AIRBAGS.
THE DRIVER'S SIDE REAR TAIL LIGHT ASSEMBLY FAILED. RECEIVED A WARNING INDICATOR LIGHT ON THE DASH PANEL. REPLACING THE BULBS IN THE ASSEMBLY FAILED TO CORRECT THE PROBLEM. RESEARCHING THIS ISSUE I DISCOVERED THERE HAS BEEN AN EQUIPMENT RECALL FOR FAILED TAIL LIGHT ASSEMBLIES. *TR
RIGHT SIDE SIGNAL LIGHT INTERMITTENT FAILURE. WHEN IT FINALLY FAILED THERE WAS A SCORCHED WIRE. UPON INVESTIGATION FOUND THERE IS A TSB FROM THE MANUFACTURER BUT ONLY IN WARRANTY. NO RECALL. *KB
REAR TAIL LIGHT INTERMITTENTLY SHOW FAILURE. UPON INSPECTION, APPEARS CONNECTION SHOWS SIGNS OF PREMATURE WEAR AND BURNING/OVERHEATING DUE TO INADEQUATE GROUNDING. *TR
THIS IS A VERY COMMON PROBLEM FOR THIS YEAR AND MODEL BMW CAR. AT JUST UNDER 45K MILES, THE EXTERIOR TAIL LIGHTS AT TIMES FAIL TO WORK. THE LIGHTS HAVE BEEN CHANGED ETC. I GET NOTIFIED FROM THE INSIDE DASH BOARD. HOWEVER, AT TIMES IT IS A FALSE POSITIVE (DASH SAYS IT DOESN'T WORK BUT IN FACT IT IS WORKING). THEN AT TIMES THE WARNING LIGHTS SWITCH FROM THE LEFT TO THE RIGHT TAIL LIGHTS. I AM NOT SURE WHEN IT IS ACTUALLY WORKING AND WHEN IT IS NOT WORKING - THIS IS DANGEROUS AND BMW SHOULD FIX THIS DESIGN FLAW. THIS FAILURE IS DUE TO POOR MATERIALS USAGE (CORROSION PROBLEM) AND GROUNDING LIKE THE OTHER POSTS HAVE MENTIONED. APPARENTLY THERE IS A CLASS LAWSUIT AGAINST BMW FOR THIS. WITH ALL THESE COMPLAINTS FOR THE SAME PROBLEM, I DON'T UNDERSTAND HOW IT HAS NOT BEEN RECALLED FOR FIXING B/C FAILURE TO SIGNAL WHEN CHANGING LANES IS A VIOLATION BECAUSE IT IS DANGEROUS. BMW NEEDS TO FIX THIS. *TR
UNRELIABLE TAILLIGHT/BRAKELIGHT/TURN SIGNAL FUNCTIONING IN 2004 BMW 325XI. PROBLEM BEGAN IN EARLY 2008. LIGHTING INDICATORS KEPT COMING ON SUGGESTING TAILLIGHTS WERE OUT. REPLACED ALL APPLICABLE BULBS SEVERAL TIMES OVER THE PAST YEAR THEN FINALLY BROUGHT TO DEALER. THEY SAID THAT THEY HAVE SEEN MANY OF THESE INSTANCES WHERE THEY NEED TO REPLACE CARRIER, HARNESS AND ADD A GROUND WIRE TO FIX THE ISSUE IN ORDER TO GET LIGHTS WORKING AGAIN. DANGEROUS AT NIGHT. UNFORTUNATELY NO RECALLS, HOWEVER, THIS IS NOT A NORMAL WEAR ITEM AND IF A DEALERSHIP NEEDS TO GO BACK IN AND CHANGE WIRING TO MAKE IT WORK, THAN IT'S SIMPLY A DESIGN FLAW AND THE CONSUMER SHOULD NOT BE RESPONSIBLE. NEEDLESS TO SAY, $700 LATER, I HAD TO GET IT FIXED TO ENSURE SAFE DRIVING. *TR
TL* THE CONTACT OWNS A 2004 BMW 325XI. THE WIRE THAT PLUGS INTO THE DRIVER SIDE REAR TAIL LIGHT HARNESS BURNED WHICH MAKES IT IMPOSSIBLE FOR THE DRIVER TO ALERT OTHERS OF HIS INTENTIONS REGARDING DIRECTION OF TRAVEL AND SPEED. TECHNICAL SERVICE BULLETIN # 10020856(EXTERIOR LIGHTING:TAIL LIGHTS) SUMMARIZES THE FAILURE. THE FAILURE HAS NOT BEEN REMEDIED. THE CURRENT AND FAILURE MILEAGES WERE 59,770. UPDATED 12/09/09 *BF THE CONSUMER STATED THE SAME FAILURE HAPPENED ON THE PASSENGER SIDE. THERE WAS INSUFFICIENT GROUNDING WHICH CAUSED THE BURNOUT OF THE TAIL LIGHT WIRING.
THIS IS A FORMAL PETITION FOR A SAFETY DEFECT INVESTIGATION. MY 2004 BMW 325XI HAS A LEFT TAIL LIGHT THAT DOES NOT WORK BECAUSE OF A POOR CONNECTION AT THE REAR LAMP CONNECTOR (THE GROUND WIRE RECEPTACLE AND HOUSING HAVE BURNT OUT BECAUSE THE GROUND IS NOT STRONG ENOUGH FOR THE CURRENT). MY RIGHT TAIL LIGHT STILL FUNCTIONS BUT I AM CONCERNED ABOUT THIS SIDE BURNING OUT AS WELL AND POSING A POSSIBLE FIRE HAZARD. BMW HAS ISSUED A SERVICE BULLETIN (SI B 63 03 06) WHICH ADDRESSES THIS ISSUE AND SAYS THAT THE CAUSE IS "MINOR CORROSION AT THE 8-PIN REAR LAMP CONNECTOR CREATES HIGH RESISTANCE CAUSING DAMAGE TO THE CONNECTOR HOUSING." BMW HAS NOT ISSUED A RECALL AND I AM WORRIED ABOUT GETTING INTO AN ACCIDENT WITHOUT A PROPERLY FUNCTIONING TAIL LIGHT. *TR
CONSUMER COMPLAINT REGARDING BMW 3 SERIES HIGH FAILURE RATE OF THE EMERGENCY FLASHER SWITCH. *TS (11/08/05) THE CONSUMER SUGGESTED THAT THE EUROPEAN DESIGN BE MODIFIED WHERE THERE IS NO CUP HOLDER ADJACENT TO THE EMERGENCY FLASHER AND SWITCH TO THE USA DESIGN WHERE THE EMERGENCY FLASHER IS LESS THAN 1 INCH FROM THE CUP HOLDER. *SC
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .