2010 BMW 335I Owner Complaints

The contact owns a 2010 BMW 335I. The vehicle was a custom-modified vehicle and a company mascot. The contact received notification of NHTSA Campaign Number: 17V676000 (Electrical System); however, the vehicle was not repaired. The contact self-identified as an independent mechanic who wanted to be present when recall repair was performed; however, the contact preferred to have the recall disassociated with the VIN and to perform the recall repair himself. The local dealer was contacted and declined the contact to be present during the recall remedy process. The manufacturer was contacted, but the contact was advised that the request was denied. In addition, the contact was not advised on the recall reimbursement process. The contact wished to perform the recall repair himself and be granted reimbursement. The contact had not experienced a failure.

NHTSA ID

11702256

Incident

Dec 1, 2025

Good Morning Folks, I own a 2010 BMW 335i sedan with approximately 110k miles and I will have to be replacing AGAIN, the valve cover gaskets in the car. The first time I had to replace the VCGs was back in 2016 and the vehicle barely had 50k miles on it. Had to replace the VCGs again in 2020. Milage was approximately 92k miles. Fast forward to today and once again, the VCG are leaking. This is an obvious manufacturer defect and I would request that the NHTSA look into to this reoccurring problem with BMW North America. The replacement cost of the VCGs on these vehicles is costly and because it is happening so frequently, BMW should not only be required to cover the cost of replacement but should also be required to remedy the problem permanently. The leakage could lead to possible ignition and a fire within the engine compartment. Thank you for your attention to this matter. [XXX] Grovetown, Ga 2010 BMW 335i owner [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11694468

Incident

Oct 20, 2025

The contact owns a 2010 BMW 335I. The contact stated while driving 45 MPH, the vehicle went into LIMP Mode, and the check engine warning light illuminated. The vehicle was not taken to a dealer or an independent mechanic. The vehicle was self-diagnosed, and the contact stated that the camshaft timing bolts needed to be replaced. The vehicle was repaired by the contact. The contact related the failure to NHTSA Campaign Number: 23V707000 (ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was 150,000.

NHTSA ID

11659108

Incident

Apr 30, 2025

Mileage

150,000 mi

RECALL 17V-676: BLOWER MOTOR WIRING was preformed several years ago. Today the wiring connection added during the recall work failed and the blower motor stopped working.

NHTSA ID

11582603

Incident

Apr 9, 2024

The engine stalled multiple times driving on the highway. When I turn off the car and turn on the car, it would go back to normal. I researched this is a problem for 335d, I think im experiencing the same problem, not sure why 335i is not included in the recall list. This happened multiple times for me and I ignored it at that time, other person has also experienced the same issue when he was driving my car. Now the electrical battery power is completely shut off and there is no recall, this really bothers me.

NHTSA ID

11508094

Incident

May 28, 2018

The high pressure fuel pump failed. I still have the vehicle but it does work. It cannot be driven with a bad high pressure fuel pump. To repair it is over $2000.00.

NHTSA ID

11499513

Incident

Dec 30, 2022

MY HEAD LIGHTS WITH ADAPTIVE DRIVE CAUGHT ON FIRE AND BURNED THE WIRES.

NHTSA ID

11397981

Incident

Feb 10, 2021

Mileage

53,000 mi

THE VEHICLES FTM (FOOTWELL MODULE) ISN'T WORKING. DURING A DRIVE MY TURNING SIGNALS DIDN'T WANT TO WORK. MY HEADLIGHTS WON'T TURN OFF. WINDOWS STAY PUT. DOORS DON'T LOCK. VEHICLE IS STATIONARY BUT CAN STILL BE OPERATED. SHOPS AROUND THE AREA NOTIFIED ME THAT THEY HAD A FEW VEHICLES HAVE THE SAME PROBLEM THIS YEAR. THERE WAS A RECALL FOR THE SAME PROBABLY THE DATES FOR THE RECALLS DIDN'T INCLUDE MY CARS MANUFACTURERED STATE

NHTSA ID

11339382

Incident

May 31, 2020

Mileage

123,500 mi

MY REAR LEFT BRAKE CALIPER STARTED SHOOTING OUT BRAKE FLUID FROM WITHIN THE MIDDLE. I HAVE AN ATE CALIPER. THIS COVERS MODELS FROM ABOUT 2006-2014. ON BIMMERFEST.COM, E90POST.COM, ETC . . . MANY PEOPLE HAVE HAD THIS PROBLEM. ON ROCKAUTO, AUTOZONE, ETC . . . THE PREMIUM RECOMMENDED REPLACEMENT IS TO GET A CALIPER FOR THE REAR THAT HAS NO PHENOLIC PISTON, YET, INSTEAD HAS A SOLID METAL PISTON. UNTO THE WORST, AT TIMES, THE PHENOLIC PISTON HAS EJECTED FROM THE CALIPER AND JAMMED THE BRAKE PADS TO THE VERY ROTORS. ATE CALIPERS ARE OFTEN USED AS SINGLE OR DUAL PIN BOOTED CALIPERS ON BENZ. THEY ALWAYS HAVE METAL PISTONS. I HAVE PREMIUM BRAKES. MY ROTORS ARE UNHARMED, MY BRAKE PADS ARE UNHARMED. THERE IS NOT A SCRATCH IN MY ROTOR. MY WHEEL BEARING IS GONE. MY SUSPENSION IS GONE.MY SUB FRAME IS GONE. IT FLATTENED MY TIRE. IT MADE ME SLIDE COMING OUT OF A TURN AT 15-18MPH. MY SPEEDOMETER BEGAN WAVERING UP AND DOWN, I GOT A TRACTION CONTROL LIGHT FOR THE DISC. IT SLID INTO THE SIDE OF A CURB. THE CURB HAS NOT A MARK ON IT. MY CAR HAS ONLY PAINT DAMAGE TO LOWER DRIVER SIDE SKIRT. AND SMALL SCRATCH ON THE FRONT LEFT QUARTER PANEL. WHILE WE ARE AT IT, WHY IS THERE NO REGULATION THAT A HUGE H8 OR T8 SIZED BATTERY NOT BE PLACED UNDER THE REAR PASSENGER SEAT WHERE THE CHILD SEAT GOES? YOUR CHILD IS SITTING ON A HUGE PILE OF SULFURIC ACID. THEY ARE SEALED, BUT THEY COOK AND SMELL LIKE ROTTEN EGGS OFTEN. ANOTHER BAD DESIGN. THEY DID THAT FOR YEARS. IT NEEDS TO GO IN THE TRUNK OR SOMEWHERE ELSE. THAT'S TERRIBLE! IT HAS HIGH PRESSURE EXTERNAL DFI, AND A CENTERED FUEL TANK. THE YEARS OF THE DODGE AND LAMBO LP TRIAL AND ERROS ALL COMBINED. IT'S REALLY BAD. I HAVE ME CALLING THE POLICE TO FILE A REPORT. THEY DENIED SHOWING TO THE SCENE. I HAVE THE CALLS RECORDED. I FILED AN ACCIDENT REPORT WITH THE TN DEPT OF HOMELAND SECURITY; AND I HAVE A CERTIFIED MAIL RECEIPT. NO ONE ELSE INVOLVED. 12:31*DT*JB

NHTSA ID

11325908

Incident

May 19, 2020

Mileage

111,000 mi

TL* THE CONTACT OWNS A 2010 BMW 335I. THE CONTACT STATED THAT THE BLOWER MOTOR FAILED TO OPERATE. WHILE DRIVING 65 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED, BUT FAILED TO DRIVE. THE VEHICLE WAS TOWED TO BMW OF SILVER SPRING (LOCATED AT 3211 AUTOMOBILE BLVD, SILVER SPRING, MD 20904, (888) 295-2096) WHERE IT WAS DIAGNOSED THAT THE ENGINE OVERHEATED. THE CONTACT WAS ALSO INFORMED THAT THE WATER PUMP WAS LEAKING, AND THE RADIATOR WAS LEAKING ANTIFREEZE AND WAS MIXING WITH THE OIL, WHICH NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THE VEHICLE WAS OUT OF WARRANTY. NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

NHTSA ID

11165882

Incident

Dec 18, 2018

Mileage

75,000 mi

THE WIRING HARNESS FOR THE HEADLIGHTS TENDS TO ROT OVERTIME IN THESE CARS WHICH THEN LEADS TO BARE COPPER WIRES MAKING CONTACT WITH EACH OTHER AND ENDS UP CAUSING A SHORT AND BLOWING THE BULB. THIS IS A SAFETY HAZARD, NOT ONLY FOR VISIBILITY BUT FOR FIRE PREVENTION AS WELL. THIS IS A COMMON ISSUE IN A LOT OF BMW'S AND IT SHOULD BE ADDRESSED. THIS ISN'T SOMETHING THAT SHOULD HAVE TO BE REPLACED AND IT IS VERY CHALLENGING TO DO SO. I TOOK A LOOK AT THIS AS MY HEADLIGHT BULB BLEW LAST WEEK WHILE ON THE ROAD. LIKE I HAD MENTIONED EARLIER, THIS IS PRETTY COMMON AND IS EVEN OCCURRING IN THEIR NEWER MODELS. THE INSULATION OVER THE WIRING JUST FLAKES OFF AND THE DEALERSHIPS SHOW NO CARE WHEN THE ISSUE IS BROUGHT UP.

NHTSA ID

11156054

Incident

Dec 1, 2018

Mileage

84,975 mi

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW 335I. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V071000 (AIR BAGS) AND 17V676000 (ELECTRICAL SYSTEM). THE CONTACT STATED THAT THE DEALER (ZT MOTORS OF FORT WALTON BEACH, 1000 N BEAL PKWY NW, FORT WALTON BEACH, FL 32547, (850) 863-2167) SCHEDULED AN APPOINTMENT FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 90,000.

NHTSA ID

11110166

Incident

Jul 7, 2018

Mileage

90,000 mi

CAR IN GARAGE INSERTED KEY CAR DEAD. NOTHING WORKED. ALL ELECTRICAL SYSTEMS DOWN. UNABLE TO OPEN TRUNK TO CHECK BATTERY.CALLED WRECKER SERVICE JUMP STARTED CAR INSTANTLY FROM UNDER HOOD.MECHANIC CHECKED CAR NO PROBLEMS FOUND. FOUND: PROBLEM BMW RECALL SAFETY UK . EXACT SAME PROBLEM SAYS CAR CAN SHUT DOWN IN MOTION.

NHTSA ID

11109984

Incident

Jul 6, 2018

Mileage

90,000 mi

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW 335I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V071000 (AIR BAGS) AND 17V676000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT ALSO STATED THAT COMPENSATION SHOULD BE PROVIDED FOR THE INCONVENIENCE CAUSED BY THE RECALLS. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11054458

Incident

Feb 5, 2016

TL* THE CONTACT OWNS A 2010 BMW 335I . THE CONTACT STATED THAT THE DEALER DID NOT NOTIFY HIM DURING THE TIME OF PURCHASE THAT THE VEHICLE WAS PENDING NHTSA CAMPAIGN NUMBER: 17V676000 (ELECTRICAL SYSTEM). THE DEALER INFORMATION WAS UNKNOWN. IT WAS UNKNOWN IF THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE HOWEVER WAS CONCERNED FOR THEIR SAFETY. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11051800

Incident

Sep 2, 2017

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW 335I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V071000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACTED (HENDRICK BMW, CHARLOTTE, NC, 888-660-4841) AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11033039

Incident

Feb 5, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW 335I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V071000 (AIR BAGS) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER (GLOBAL IMPORTS BMW, 500 INTERSTATE N PKWY, ATLANTA, GA 30339, 800-294-1853) DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT WAS NOT EXPERIENCING A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 10/17/17*LJ *TR

NHTSA ID

11015314

Incident

Feb 5, 2016

TAKATA RECALL: RECEIVED NOTICE OF RECALL BACK IN MARCH 2016 FOR MY 2010 BMW 335I FOR THE DRIVERS AIR BAG. I LIVE IN TEXAS WHICH IS WHERE I BOUGHT THIS CAR (HAH ZONE). HOW LONG IS A REASONABLE AMOUNT OF TIME TO WAIT FOR THIS RECALL TO BE REMEDIED? BMW LETTER STATED THAT WHEN PARTS ARE AVAILABLE I WILL RECEIVE A LETTER. STILL WAITING.....

NHTSA ID

11004057

Incident

Mar 1, 2016

I NEED MY AIRBAG TO BE REPLACED SINCE LAST YEAR AND BMW DEALERS ALL THE TIME IS JUST SAYING THAT THE PART IS NOT AVAILABLE. IT HAD BEEN HAPPENING FROM LAST YEAR. THEY DO NOT CARE ABOUT REPLACE THE AIR BAGS.

NHTSA ID

10994240

Incident

Jan 2, 2017

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW 335I CONVERTIBLE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V071000 (AIR BAGS). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE LOCAL DEALER (LOCATED AT BMW OF HOUSTON NORTH IN THE WOODLANDS; 17830 N FWY SERVICE RD, THE WOODLANDS, TX 77384; (936) 776-4610) CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE CONTACT WAS CONNECTED TO THE BMW MANUFACTURER BY THE DEALER, BUT THERE WAS NO RESPONSE AND THE CALL GOT DISCONNECTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10994126

Incident

Feb 5, 2016

TAKATA RECALL I RECEIVED A RECALL NOTICE ABOUT THE AIRBAGS IN MY BMW. I HAVE REPEATEDLY CONTACTED MY BMW FREMONT DEALER AS WELL AS BMW AMERICA ABOUT REPLACING THEM. THEY KEEP TELLING ME THEY DO NOT HAVE REPLACEMENTS. IN 2016 THEY SAID THEY SHOULD BE IN LAST SEPTEMBER. I ASKED AGAIN TODAY & STILL NO AIRBAGS.

NHTSA ID

10991868

Incident

May 26, 2017

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW 335I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V071000 (AIR BAGS). THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE CONTACT'S VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 01/06/17*LJ UPDATED 01/23/17.*JB

NHTSA ID

10917485

Incident

Aug 10, 2015

TL* THE CONTACT OWNS A 2010 BMW 335I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V071000 (AIR BAGS); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

10892885

Incident

Aug 3, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW 335I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V071000 (AIR BAGS); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

10889188

Incident

Jul 28, 2016

TAKATA RECALL. I WAS INVOLVED IN A MINOR, SLOW SPEED ACCIDENT WHERE MY VEHICLE REAR-ENDED THE VEHICLE IN FRONT. THE AIRBAGS DEPLOYED WITH SUCH FORCE THAT BOTH FRONT PASSENGER WINDOWS WERE BLOWN OUT AND THE WINDSHIELD CRACKED. I SUFFERED PARTIAL HEARING LOSS AS A RESULT. VEHICLE WAS MOVING AT APPROXIMATELY 15-20 MPH ON A HIGHWAY AT THE TIME.

NHTSA ID

10881828

Incident

May 30, 2016

Mileage

77,000 mi