2019 BMW 430I Owner Complaints

The contact owns a 2019 BMW 430I. The contact stated that while driving approximately 55 MPH and switching lanes, there was a loud explosion. The contact was unable to determine the cause of the sound. The contact pulled over to the side of the road to inspect the tires and discovered that the sunroof had shattered upward. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 131,992.

NHTSA ID

11753237

Incident

Jul 28, 2026

Mileage

131,992 mi

The car has a plastic part in the oil housing component that cracks under heat usually between 50000 and 70000 miles causing a major loss of coolant onto highway and disables the engine

NHTSA ID

11744815

Incident

Jun 12, 2026

The contact owns a 2019 BMW 430I. The contact stated that there was a coolant leak. The contact stated that the engine overheated and the vehicle stalled while driving. The message "Engine Overheating - Stop Vehicle Immediately" was displayed. The vehicle was towed to the local dealer, where it was diagnosed, and it was determined that the coolant housing needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, where it was determined that the coolant water pump needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken to the same local dealer, where it was diagnosed, and it was determined that there was coolant leaking from the oil housing. The vehicle was not repaired. The manufacturer was contacted, a complaint was filed, and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 116,758.

NHTSA ID

11716146

Incident

Feb 4, 2026

Mileage

116,758 mi

I am reporting a potential safety defect involving the seatbelt, airbag, and occupant detection system in my 2019 BMW 430i. At the time of purchase, the vehicle’s software had not been updated since 2018. Because the software was so outdated, multiple safety-related fault codes did not appear during the dealer’s pre-sale inspection or during initial diagnostic checks. During a later service appointment, the dealership informed me that they were unable to perform accurate diagnostics because the software was old and could interfere with sensor readings. After I paid for the software update, several safety-related codes appeared, including faults connected to the seatbelt/occupant classification system. None of these safety defects were disclosed to me prior to the sale. This raises concern that the vehicle had an existing safety defect at the time of sale, but the outdated software prevented the detection and reporting of these faults. If other vehicles are being sold without current software, this may result in safety-critical issues being hidden from consumers and inspectors. A malfunctioning seatbelt or occupant detection system significantly increases injury risk in a crash. If outdated vehicle software suppresses or fails to display safety-critical faults, consumers may unknowingly be operating unsafe vehicles.

NHTSA ID

11702674

Incident

May 22, 2025

Rear window does not work. This car collects water from the windows which pools inside the window panel. Eventually, the pooled water damages the window motor and window regulator. Once the window stops working, the convertible top no longer works. This issue is reported all over youtube and google searches. The worse part is that to fix this, mechanics have to manually bring down the convertible top. Examples: [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11695883

Incident

Feb 3, 2025

The airbags did not deploy upon impact from head on collision into another vehicle. The vehicle was towed and the other vehicle’s airbags did deploy that was involved in the collision. There was a police report filed & the insurance company has picked up the vehicle for them to complete an inspection & evaluation.

NHTSA ID

11693906

Incident

Oct 14, 2025

On my way home driving, my car dashboard and LCD screen give me a warning of overheating and engine oil pressure too low. Car stalled on stalled soon after, and started smoking. So I had the car towed and was told from bmw dealership, I had to get a new engine. I have kept up on my oil change and maintenance and never got these warning signs until now. I did mr research and found out from Kelly blue book and other websites such Dealer Rater that bmw same year make and model have a few recalls including engine cooling and crankshaft sensor malfunction. The bmw mechanic advise the coolant and oil holder made of plastic melted down into the engine and engine needs to be replaced. However, there have been reports states that other have experience the same thing with bmw cars. This should not have happened when much warnings was not given and how ironic same year make and model had the same issue and recall was issued. I have screen shots to prove it.

NHTSA ID

11677834

Incident

Jul 26, 2025

The contact owns a 2019 BMW 430I. The contact stated that while driving at an undisclosed speed, the "Coolant Low" message was displayed, prompting the contact to add coolant to the coolant reservoir. The vehicle returned to normal functionality, but the failure became a regular occurrence. The low coolant warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 99,000.

NHTSA ID

11641817

Incident

Feb 8, 2025

Mileage

99,000 mi

The contact owns a 2019 BMW 430I. The contact stated that after starting the vehicle and driving at an undisclosed speed, the “Air Bag Off” and “Service Air Bag” messages were displayed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to Special Coverage Adjustment: 23520 Passenger Presence Sensor (PPS) Module; however, the VIN was not included in the Special Coverage Adjustment. The manufacturer was made aware of the failure. The failure mileage was approximately 86,000.

NHTSA ID

11614401

Incident

May 10, 2024

Mileage

86,000 mi

I purchased my vehicle October2023. May 23,2024, at 1:34 pm, my vehicle broke down due to a message on my dashboard stating “Drivetrain malfunction”. I was on the highway with no use of my gas pedal, which resulted in me rolling back all while being 5 months pregnant. June 18,2024, at 3:04pm ,my vehicle broke down again due to the same message that previously popped up “Drivetrain malfunction”. I was also on the highway with no use of my gas pedal all while pregnant. July 18,2024, at 12:25 midnight, my vehicle broke down again due to the previous problem “Drivetrain malfunction” by the airport with no use of my gas pedal all while 6 months pregnant. Each time I my vehicle malfunction I almost got hit by other vehicles because I had no use of my gas pedals to get out of the way. There were no warning signs at all. When the message pops up on my dashboard the gas pedal completely becomes inoperable. This vehicle has put me and my soon to be baby in harms way multiple times. The dealership has had 3 times to fix the problem and still fail to do so. Having their opportunity to fix it three times just to tell me it’s because it doesn’t have gas in it when it did has put my in a situation where I’m constantly worried about it braking down again putting me and my unborn child in danger AGAIN, to where I am financing a car I can not use. Not including the 2 times I had to pay to get it towed from the airport because the police told me I couldn’t leave it there.

NHTSA ID

11605588

Incident

May 23, 2024

My fiancé was driving my vehicle and hit a tree. The air bag deployed and she has shrapnel cuts on her face. The surgeon stated that she should not have had that injury on the face like she did.

NHTSA ID

11576307

Incident

Jan 8, 2024

Coolant leaking due to overheating, seems to be common problem

NHTSA ID

11560042

Incident

Dec 8, 2023

The contact owns 2019 BMW 430I. The contact stated while the vehicle was parked, he noticed coolant was leaking underneath the vehicle onto the ground. Additionally, the contact stated while driving at various speeds, the message that the coolant level was low was displayed and the vehicle was overheating. The vehicle was taken to the dealer several times. The dealer diagnosed that the vehicle with a fractured coolant hose, and that the oil filter housing, and an unknown part connecting the engine block from the coolant reservoir needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 40,000.

NHTSA ID

11559507

Incident

May 15, 2020

Mileage

40,000 mi

On Aednesday April 12th, I was driving on a busy road and the car died. There was no safe place for me to pull off which had cars swerving to miss me. There was no indication of coolant level low. The car just died. After extensive research, I found out this car was part of a service action that was never performed because I wasn’t notified of it. This is very dangerous to anyone who owns a 2019 BMW 430i and will cause bodily harm or death if not recalled.

NHTSA ID

11518866

Incident

Apr 12, 2023

Car stalled because of coolant vent line in cylinder head Faulty coolant line like other models. I was lucky enough to get out of traffic without an accident. This car had to be flatbeded to dealership to repair their “service advisory” which I was never notified of. My papers from dealership says BMW recall and they are now refusing payment for tow!! This faulty part could cause someone to be killed!!! They need to be held accountable for tow because of a faulty part that could be deadly

NHTSA ID

11503531

Incident

Dec 24, 2022

"Passenger restraint system: Malfunction" alert came up on the display screen and then quickly disappeared several times. BMW dealer said the seat belt/airbags would not operate correctly in the event of a crash. BMW dealer said it was not related to the 2 recalls issued in 2021 and 2022 on this car for coolant or telematics (which BMW had not notified us about yet or fixed during service appts in 2021 or 2022). From a quick search online, this specific passenger restraint warning alert is unfortunately a very common problem with this year/make/model and should be reviewed to see if it qualifies as a recall. BMW dealer charged $1840 to replace the seat, mat and clear the warning alert.

NHTSA ID

11502192

Incident

Jan 2, 2023

COOLANT HOSE AND FITTINGS FAILED. OVERHEATED THE ENGINE. CAR SPEED WAS LIMITED AND HAD TO STOP THE CAR ON THE SIDE OF THE ROAD. BMW USES PLASTIC PARTS FOR THE COOLING SYSTEM. THESE PLASTIC PARTS FAILED AFTER 35,000 MILES. THE COST TO REPAIR WAS ~ $1200.00

NHTSA ID

11491962

Incident

Nov 1, 2022

MY SUNROOF EXPLODED WHILE DRIVING. THERE WERE NO OTHER VEHICLES ON THE ROADWAY. THE EXPLOSION WAS VIOLENT AND LOUD. LUCKILY THE VIOLENT EXPLOSION DIDN'T CAUSE ME TO CRASH. BITS OF GLASS ARE STILL STUCK IN MY SKIN. I CAN FEEL THE GLASS BUT I CAN'T SEE IT.

NHTSA ID

11339294

Incident

Jul 14, 2020

Mileage

15,000 mi

MY SUNROOF EXPLODED ON ME WHILE DRIVING. LUCKILY THERE WAS NO OTHER TRAFFIC ON THE ROADWAY. THE EXPLOSION WAS VIOLENT AND SOUNDED LIKE A GUNSHOT.

NHTSA ID

11339275

Incident

Jul 14, 2020

Mileage

15,370 mi

SEAT OCCUPANCY SENSOR IS SENSING A FAULT. IT SAYS IT IS NOT WORKING AND THE AIRBAG IS NOT ON. THE DEALER IS RELUCTANT TO REPAIR IT, BECAUSE IT'S EXPENSIVE. IT'S UCLEAT IF THE AIRBAG WILL WORK.

NHTSA ID

11196971

Incident

Apr 15, 2019

Mileage

11,000 mi

TAKATA RECALL

NHTSA ID

11183709

Incident

Nov 3, 2000