2001 BMW 5 Series Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2001 BMW 5 Series, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure125.0%
- Electrical125.0%
- Exterior lighting125.0%
- Visibility125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
BMW X5 WITH 15,000 MILES HAD SUCH EXTENSIVE RUST IN THE FRONT END PARTS THAT THE REPAIR COST OVER $2,000. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
FAILURE OF THE INFORMATION CLUSTER, MISSING PIXELS)....MILEAGE AND OTHER INFORMATION CAN NOT BE READ.*TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
THE HEADLIGHT'S HAVE MANUAL ADJUSTERS ON EACH SIDE, BOTH OF MY HEADLIGHTS POINT TOWARDS THE GROUND BECAUSE THEY ARE BROKEN, I TRIED TO ADJUST THE BEAM AND BOTH SIDES JUST CLICK. THIS IS A MAJOR SAFETY HAZARD BECAUSE AT NIGHT IT LIMITS YOUR VISION AHEAD TO ABOUT 10 TO 20 FEET. I OWN OTHER VEHICLE'S THAT ARE OLDER THAN THIS VEHICLE AND THE HEADLIGHTS HAVE NEVER BEEN A PROBLEM. I AM A MEMBER OF A FORUM FOR THIS PARTICULAR MODEL CAR AND MORE THAN HALF, IF NOT EVERY MEMBER HAS ENCOUNTERED THIS PROBLEM. THE SOLUTION FROM MY DEALER WAS TO REPLACE BOTH HEADLIGHTS FOR A TOTAL OF $1000.00 PLUS. I DON'T THINK A HEADLIGHT SHOULD HAVE TO BE REPLACED ON A VEHICLE AND THIS IS A WELL KNOWN AND DOCUMENTED PROBLEM. THE SAFETY OF MY FAMILY IS AT RISK BECAUSE OF THE POOR DESIGN OF THESE HEADLIGHTS. THE ADJUSTER'S JUST CLICK AND THE HEADLIGHTS ALWAYS POINT TOWARDS THE GROUND, IM PRETTY SURE IT WAS MADE THIS WAS TO INCREASE VISIBILITY OF THE ROAD AND HAZARDS AHEAD BUT IF THE MECHANISM IS BROKEN THEN THE SAFETY HAS BEEN COMPROMISED. WHILE DRIVING AT NIGHT MY VISION AHEAD IS VERY LIMITED, IT PRESENTS A VERY SERIOUS SAFETY HAZARD BECAUSE YOU SHOULD HAVE A BETTER VIEW OF THE ROAD AHEAD OF YOU AS OTHER CAR'S HAVE. THIS SHOULD BE ADDRESSED AND IT SHOULD HAVE BEEN A RECALL BY BMWNA FOR ALL USA OWNERS OF THIS TYPE OF HEADLIGHT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
THE HEADLIGHT'S HAVE MANUAL ADJUSTERS ON EACH SIDE, BOTH OF MY HEADLIGHTS POINT TOWARDS THE GROUND BECAUSE THEY ARE BROKEN, I TRIED TO ADJUST THE BEAM AND BOTH SIDES JUST CLICK. THIS IS A MAJOR SAFETY HAZARD BECAUSE AT NIGHT IT LIMITS YOUR VISION AHEAD TO ABOUT 10 TO 20 FEET. I OWN OTHER VEHICLE'S THAT ARE OLDER THAN THIS VEHICLE AND THE HEADLIGHTS HAVE NEVER BEEN A PROBLEM. I AM A MEMBER OF A FORUM FOR THIS PARTICULAR MODEL CAR AND MORE THAN HALF, IF NOT EVERY MEMBER HAS ENCOUNTERED THIS PROBLEM. THE SOLUTION FROM MY DEALER WAS TO REPLACE BOTH HEADLIGHTS FOR A TOTAL OF $1000.00 PLUS. I DON'T THINK A HEADLIGHT SHOULD HAVE TO BE REPLACED ON A VEHICLE AND THIS IS A WELL KNOWN AND DOCUMENTED PROBLEM. THE SAFETY OF MY FAMILY IS AT RISK BECAUSE OF THE POOR DESIGN OF THESE HEADLIGHTS. THE ADJUSTER'S JUST CLICK AND THE HEADLIGHTS ALWAYS POINT TOWARDS THE GROUND, IM PRETTY SURE IT WAS MADE THIS WAS TO INCREASE VISIBILITY OF THE ROAD AND HAZARDS AHEAD BUT IF THE MECHANISM IS BROKEN THEN THE SAFETY HAS BEEN COMPROMISED. WHILE DRIVING AT NIGHT MY VISION AHEAD IS VERY LIMITED, IT PRESENTS A VERY SERIOUS SAFETY HAZARD BECAUSE YOU SHOULD HAVE A BETTER VIEW OF THE ROAD AHEAD OF YOU AS OTHER CAR'S HAVE. THIS SHOULD BE ADDRESSED AND IT SHOULD HAVE BEEN A RECALL BY BMWNA FOR ALL USA OWNERS OF THIS TYPE OF HEADLIGHT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .