2008 BMW 5 Series Owner Complaints

My vehicle had a faulty PCV valve that was under "Stop Drive," order. I received no correspondence from the NHTSA nor from BMW of North America in regards to this. My BMW X-5 had significant issues that are directly associated with this issue. After contacting BMW of North America directly because I could not reach anyone at my nearest BMW Service Department, it was escalated twice to attempt to arrange for my vehicle that I unknowingly continued to drive. My vehicle has sat undriven since May of 2024. It was finally picked up, towed to the dealership for repairs related to the PCV recall. The PCV valve was replaced and my vehicle was returned to me in undriveable condition. None of the rough idle, burning smell or engine issues were attended to. They simply replaced the valve without further investigation into the damage done by continued driving of a "Stop Drive," order. BMW of North America is placing blame solely on the NHTSA for not sending me correspondence relative to this recall. My vehicle was identified as having the faulty Takata airbags and I received all of the documents sent by both the NHTSA and BMW USA. I now have a undriveable, unsafe vehicle due to the servicer simply replacing a recalled object but not the damage caused by continuing to drive a vehicle that should have had immediate service. Please advise what steps should be taken. Tara Catalano-Smith

NHTSA ID

11697553

Incident

Oct 14, 2025

I WAS DRIVING AND BUMPED UP AGAINST A SIDEWALK CURVE AND MY AIRBAGS DEPLOYED AS WELL AS MY CAR SHUT OFF. IT WILL NOT START ANOTHER MORE AND THE HOOD UNDERNEATH WAS ON FIRE. (SMOKE WAS PRESENT).

NHTSA ID

11043668

Incident

Oct 28, 2017

Mileage

3 mi

TAKATA RECALL. BMW IS NOT DOING ENOUGH TO RECTIFY THE SITUATION. I RECEIVED A NOTICE IN MARCH & 5 MONTHS LATER BMW DEALERS STILL DO NOT HAVE THE PARTS TO REPAIR THE AIRBAGS. HOW IS IT THAT THIS IS ACCEPTABLE?

NHTSA ID

10892424

Incident

Mar 1, 2016

FRAUD ACTIVITY POSSIBLE CLONE REFINANCED IDENTITY THEFT REMOTE ACCESS WAS PUT ON UNAUTHORIZED THREAT SAFETY FOR OWNER. TWO LOAN START DATES ONE IN REPO

NHTSA ID

10852388

Incident

Feb 24, 2016

JUST BOUGHT A USED 2008 528I (E60) W/94K MILES, IN OTHERWISE PERFECT CONDITION. WENT TO CHANGE THE ANGEL EYES FROM DRAB YELLOW TO LUX LED'S. NOTICED BARE WIRES ON BOTH SIDES OF THE BULB CONNECTORS, ON BOTH SIDES OF THE CAR. TRIED TO USE ELECTRICAL TAPE, JUST MADE MORE BARE WIRE. THE MORE I TOUCHED THE WIRES, THE MORE INSULATION FLAKED OFF, ALMOST LIKE A POWDER. I'VE NEVER SEEN ANYTHING LIKE IT. CAN'T POSSIBLY BE SAFE. DEFINITELY A FIRE HAZARD. NEIGHBOR BROUGHT OVER A BOTTLE OF LIQUID TAPE, AND I RE-COATED ALL THE BARE WIRE I COULD SEE, MAKING SURE EACH WIRE WAS SEPARATED SO A SHORT WOULD NOT OCCUR. THAT IS A GOOD TEMPORARY FIX. WILL HAVE TO STAY ON TOP OF THIS PROBLEM, SINCE MOST, IF NOT ALL, OF THE HEADLIGHT WIRING IS MADE WITH BAD, QUICKLY DEGRADING WIRE INSULATION. A REAL DISAPPOINTMENT IN OTHERWISE GOOD GERMAN QUALITY AND ENGINEERING. I GUESS THE SOURCE PROCURER AT THE FACTORY SAVED BMW SOME BIG BUCKS ON THAT WIRE!! THIS IS DEFINITELY A NHTSA SAFETY RECALL ISSUE. TORT LAWYERS SHOULD HAVE A FIELD DAY ON THIS ONE. PHOTOS OF THIS PROBLEM ARE AVAILABLE AT: HTTP://WWW.BIMMERFORUMS.COM/FORUM/SHOWTHREAD.PHP?2132684-HEADLIGHT-WIRE-JACKETS-JUST-FLAKE-OFF

NHTSA ID

10836474

Incident

Feb 15, 2016

Mileage

94,000 mi

ELECTRICAL WIRING INSULATION/SHEATHING WITHIN THE HEADLIGHT UNIT/HOUSING IS SHOWING SIGNS OF AND OR OUTRIGHT DETERIORATION WHICH IN TURN EXPOSES BARE WIRES WITHIN THE HEADLIGHT HOUSING. AT THIS POINT, THE DAYTIME RUNNING LAMPS HAVE BEEN THE ONLY EFFECTED LIGHTS BUT THE WIRES FOR THE HEADLIGHTS ARE ALSO NOTICEABLY TROUBLED. THE ISSUE IS NOT SPEED, MOVEMENT OR AREA DEPENDENT. FOR FURTHER REFERENCE, I WILL PROVIDE A LINK TO AN OWNER'S FORUM DETAILING OTHER'S DILEMMAS DUE TO THIS EXACT ISSUE: HTTP://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=798640 I LOOK FORWARD TO A RESPONSE.

NHTSA ID

10787407

Incident

Oct 1, 2015

Mileage

139,000 mi

( I AM THE ORIGINAL OWNER THIS VEHICLE) WHILE REPLACING A BURNT OUT HEADLIGHT, I NOTICED THAT THE INSULATION IN THE SEALED HEADLIGHT WAS MISSING. WHEN I CHECKED THE OPPOSITE SIDE, I FOUND THE SAME THING, THE INSULATION WAS BROKEN AND MISSING. BEING THAT THIS IS A SEALED HEADLIGHT HOUSING, I AM UNABLE TO REMOVE AND REPAIR THE PROBLEM. BMW PARTS STATED THAT THE WIRING HARNESS IS NOT SOLD FOR THOSE LIGHTS. ONE HAS TO PURCHASE A COMPLETELY NEW HEADLIGHT ASSEMBLY AT A AVERAGE COST OF $700.00+. *TR

NHTSA ID

10713565

Incident

Jul 30, 2012

Mileage

48,000 mi

OUR 2007 BMW 530XI DEVELOPED A STEERING WHEEL LOCK MALFUNCTION WARNING. A RED STEERING WHEEL WITH A PADLOCK APPEARS ON THE DASH SCREEN WITH A WARNING ON THE COMPUTER. THE STEERING WHEEL LOCKS AND UNLOCKS PERFECTLY EVERY TIME. THE CAR IS DRIVABLE. THE DEALER SAYS THE STEERING LOCK MODULE MUST BE REPLACED FOR $600. I FOUND THAT THIS IS A RAMPANT PROBLEM ON BMWS AND THAT BMW CORPORATION IS AWARE OF THE PROBLEM. THERE SHOULD BE A RECALL FOR THIS PROBLEM. *TR

NHTSA ID

10678436

Incident

Jan 15, 2015

Mileage

79,000 mi

WHILE TRAVELING DOWN THE HIGHWAY, I HEARD A LOUD NOISE - VERY LOUD - ON THE TOP OF MY CAR. IT SOUNDED LIKE SOMETHING FELL OR LANDED ON THE SUNROOF. I SAFELY BROUGHT THE CAR TO A STOP AND THEN SAW THE HUGE HOLE IN MY SUNROOF! *TR

NHTSA ID

10667819

Incident

Dec 22, 2014

Mileage

114,400 mi

GASOLINE IS LEAKING FROM THE FUEL LEVEL SENSOR, WHICH IS ACCESSED BENEATH THE LEFT REAR PASSENGER SEAT, DUE TO A CRACK IN THE PLASTIC HOUSING. MY INDEPENDENT MECHANIC WHO SPECIALIZES IN BMW REPAIR, TELLS ME THIS IS A COMMON PROBLEM WITH BMW AND MERCEDES VEHICLES. *TR

NHTSA ID

10654546

Incident

Jul 16, 2014

Mileage

90,000 mi

ALL 6 FUEL INJECTORS FAILED. CAR LOST POWER WHILE DRIVING ON 3 SEPARATE OCCASIONS. *TR

NHTSA ID

10644962

Incident

Oct 14, 2014

Mileage

76,000 mi

ON OR ABOUT MAY 2013 I WAS TRAVELING AT 60MPH ON THE FREEWAY WHEN SUDDENLY I HEARD A LOUD BANG SOUND AND MY VEHICLE CAME TO AN AUTOMATIC STOP. SCARED AS VEHICLE BEHIND ME SCREECHED AND TURN AWAY AVOIDING ME. I REMAINED IN THE MIDDLE OF THE ROAD FOR APPROXIMATELY 30 MINUTES BEFORE THE VEHICLE RESTARTED AND I TRAVELED FEARFULLY TO COMPLETE MY ASSIGNMENT. SAME DAY ON MY RETURN HOME VEHICLE STOPPED ABOUT 3 TIMES BUT I DROVE STRAIGHT TO DEALERSHIP. WITHOUT INSPECTING MY VEHICLE I WAS TOLD MY ALTERNATOR AND BATTERY WAS GONE. I WAS QUOTED VERY HIGH AMOUNT BUT SOMETHING TOLD ME A BAD ALTERNATOR AND BATTERY WOULD NOT START A VEHICLE SO I OFFERED TO TAKE MY VEHICLE HOME. MY VEHICLE STAYED HOME FOR ABOUT 4 MONTHS WITHOUT USE ONLY WARM UPS REVERSE AND PARK. I DID EXTENSIVE RESEARCH TO AVOID THE FRIVOLOUS AMOUNT THE DEALERS QUOTED AND FOUND THAT THE INTEGRATED MODULE (IVM) WAS BAD. I GOT IT FOR $144 AND REPLACED IT AND PROBLEM WAS FIXED AFTER 4 MONTHS. UNTIL APRIL 2014 I DROVE THE OUT TO WORK AND BARELY TWO MILES AWAY FROM HOME I STOPPED AT A TRAFFIC LIGHT AND WHEN RELEASED THE VEHICLE SOUNDED A HUGE BANGED SOUND THIS WITH TRANSMISSION MALFUNCTION LIGHT ACTIVE BRAKE LIGHTS AND SEVERAL OTHER LIGHTS ON DASH BOARD. ONCE AGAIN I SURVIVED BEING RAN OVER IN THE EARLY MORNING RUSH. TOOK VEHICLE TO BMW DEALERSHIP. TOLD GEAR SHIFTER WAS BAD AND REPLACED FOR $915 AND THEREAFTER I RECEIVED A CALL THE TRANSMISSION WAS OUT. I WAS ADVISED COST WILL BE $15000 THEN LATER THAT IT CANNOT BE FIXED AND ADVICE TO SALE IT AS IS TO SOME GUY. I OWE $17900 ON VEHICLE. CALLED BMW NORTH AMERICA TO COMPLAIN WAS TOLD NEW TRANSMISSION COST $9200 AND I'M ASKED TO PAY $7400 BEST DEAL. THERE'S NO REASON FOR TRANSMISSION ON 2008 TO GO OUT. SINCE DEALERS TOOK MY CAR THEY GAVE ME A RENTAL FOR 4 DAYS AND TOOK IT FROM ME BUT KEPT MY VEHICLE FOR ADDITIONAL 2 WEEKS AND ARE STILL HOLDING IT CALLING TO ACCEPT DEAL. *TR

NHTSA ID

10607925

Incident

May 14, 2013

Mileage

85,000 mi

I TOOK MY CAR TO THE DEALERSHIP FOR REGULAR MAINTENANCE (OIL CHANGE ETC). THEY FOUND RIGHT SIDE ENGINE MOUNT BOLT BROKEN WHICH CAN CAUSE ADDITIONAL DAMAGE TO THE CAR. THIS WAS REPORTED AS A SAFETY CONCERN. I AM THE SOLE DRIVER AND HAVE NEVER HAD ANY ISSUES OR UNUSUAL ROAD CONDITIONS. I SEARCHED ON INTERNET AND I FOUND A LOT OF COMPLAINTS WITH 2008 BMWS (5 SERIES AS WELL AS 3 SERIES). DEFINITELY SHOULD BE A SAFETY RECALL !!! *TR

NHTSA ID

10584080

Incident

Apr 1, 2014

Mileage

77,021 mi

WATER PUMP FAILURE WITH LESS THAN 50K MILES, REPAIR COST $1200, RIDICULOUS! SEE NHTSA ID NUMBER: 10472497, THIS GENTLEMAN HAD THE SAME COMPLAINT AND JUST LIKE HIM, MY CAR WAS OUT OF WARRANTY BY 1.5 MONTHS. *TR

NHTSA ID

10556566

Incident

Dec 15, 2013

Mileage

45,000 mi

MALFUNCTION OF LEFT HEADLIGHT. DEALER INSPECTION REVEALED"HEADLIGHT WIRES LEADING TO BULB SOCKET HAVE CORROSION ON THEM AND CASING AROUND THE WIRES IS COMING OFF". THERE WAS A RECENT VEHICLE SAFETY RECALL FOR THIS MODEL CAR FOR SIMILAR ISSUES WITH REAR LAMP BULB CARRIER: RECALL CAMPAIGN NO. 13V-407 POTENTIALLY SERIOUS SAFETY ISSUE WITH MALFUNCTION OF HEADLIGHTS LEADING TO DANGEROUS DRIVING CONDITIONS OR CRASH CAN OCCUR ESPECIALLY AT NIGHT OR IN BAD/INCLEMENT WEATHER. *TR

NHTSA ID

10553485

Incident

Nov 22, 2013

Mileage

97,700 mi

THE REAR BACK-UP LAMP OUTAGE WARNING LIGHT CAME ON MY DASHBOARD. I ATTEMPTED TO REPLACE THE BULB AND SAW THAT THE WIRING HARNESS HAD BEEN BURNT AROUND THE BROWN WIRE. I SEARCHED ONLINE AND SAW THAT THIS HAS HAPPENED MANY TIMES TO OTHER WITH THE SAME YR MAKE AND MODEL VEHICLE. I REPORTED IT TO THE DEAL WHO IN TURN REFERRED ME TO CONTACT BMW NORTH AMERICA. I RECEIVED AN E-MAIL RESPONSE FROM THEM SAYING THAT THERE IS A RECALL IN PROCESS AND TO WAIT 4-6 WEEKS. THE PROBLEM, IS THAT MY TAIL LIGHT IS NOT WORKING. IT IS UNFORTUNATE THIS CANNOT BE FIXED IMMEDIATELY. I WANT TO ENSURE THAT I AM INCLUDED IN THIS RECALL. *TR

NHTSA ID

10552147

Incident

Nov 1, 2013

Mileage

66,050 mi

THE GROUNDING WIRE IN THE CONNECTOR TO THE TAIL LIGHT BULB HOLDER MELTED AND MELTED PARTS OF THE CONNECTOR. THIS RESULTED IN NO SIGNAL, BRAKE AND RUNNING REAR LIGHTS. A RECALL HAS BEEN CALLED FOR BMW E46 3 SERIES FOR THIS EXACT PROBLEM. THE RECALL SHOULD BE EXPANDED TO COVER THE 5 SERIES AS WELL. *TR

NHTSA ID

10460828

Incident

Jun 1, 2012

Mileage

48,600 mi

LEFT SIDE OF THE CENTER DASH TRIM CONTINUES TO POP OFF. OCCURS EVERY 4 MONTHS AT $40 A REPAIR. REPAIRED 3 TIMES; ONCE UNDER WARRANTY AND TWICE OUT OF WARRANTY. THE TRIM POPS OUT ON ITS OWN, HOWEVER THE BMW DEALERSHIP CONTINUES TO STATE THAT EXCESSIVE FORCE IS CAUSING THE PROBLEM. THAT IS NOT THE CASE. THIS IS NOT A CHARACTERISTIC TO EXPECT ON THIS CLASS OF VEHICLE. AN OWNER SHOULD NOT EXPECT TO MAINTAIN THE DASH TRIM. *TR

NHTSA ID

10459542

Incident

May 23, 2012

Mileage

64,500 mi

WE BOUGHT A CERTIFIED PRE-OWNED 2008 535XI IN NOVEMBER 2010. IT HAD 36,000 MILES. AT 59,000 MILES WHILE DRIVING APPROXIMATELY 75 MPH ON A MAJORY HIGHWAY IN LONG ISLAND AFTER SITTING IN TRAFFIC FOR AN HOUR AND A HALF ON A 70 DEGREE DAY, THE CAR JUST SHUT DOWN. IT WOULD BARELY STEER AND WOULD NOT ACCELERATE. WE WERE LUCKY THAT THE BRAKES WORKED AND WERE ABLE TO GLIDE OVER TO THE SHOULDER. COMPUTER SAID ENGINE OVERHEATED AND IT WAS THE RED INDICATOR WHICH IS THE WORST. WE GOT TOWED TO A DEALERSHIP AND ARE TOLD ITS THE WATER PUMP. WE DID HAVE THE CAR SERVICED AT A DIFFERENT DEALERSHIP 4 DAYS BEFORE THIS HAPPENED AND TOLD THEM ABOUT A CLICKING NOISE FROM THE ENGINE BUT THEY DIDN'T HEAR IT SO NOTHING WAS DONE. THE INCIDENT WAS VERY SCARY AND MAKES ME NOT WANT TO DRIVE THE CAR ANYMORE. *JS

NHTSA ID

10458574

Incident

May 12, 2012

Mileage

59,000 mi

TL- THE CONTACT OWNS A 2008 BMW 535. THE CONTACT WAS DRIVING 60 MPH WHEN THE VEHICLE OVERHEATED AND STALLED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE DEALER ADVISED THE CONTACT THAT THE ELECTRICAL WATER PUMP AND THERMOSTAT MALFUNCTIONED AND NEEDED TO BE REPLACED. THERE WERE NO RECALLS FOR THE FAILURE OF THE VEHICLE. THE FAILURE MILEAGE WAS 59,500. KMJ

NHTSA ID

10441547

Incident

Dec 25, 2011

Mileage

59,500 mi

GROUND WIRE FOR PASSENGER SIDE TAIL LIGHT BURNED UP. GROUND WIRE, BOTH SIDES OF ELECTRICAL CONNECTOR, AND TAIL LIGHT BULB HOLDER ALL BURNED UP. PASSENGER SIDE BRAKE LIGHT, TAIL LIGHT, TURN SIGNAL AND BACK UP LIGHT DO NOT FUNCTION AT ALL. IMPROPERLY RATED FUSE DID NOT BLOW BEFORE CIRCUIT BURNED UP AND MELTED. THIS CIRCUIT IS NOT DESIGNED CORRECTLY. THIS IS A SAFETY HAZARD TO MYSELF AND ANYONE DRIVING BEHIND ME. CAR MODEL IS A 2008 528XI. *TR

NHTSA ID

10430057

Incident

Apr 11, 2011

Mileage

72,500 mi

WHILE DRIVING DOWN THE ROAD, THE RIM SEPARATED CAUSING THE TIRE TO GO FLAT. HAD WE BEEN TRAVELING AT A HIGH RATE OF SPEED THE RESULTS COULD HAVE BEEN MUCH WORSE. BMW, AS I HAVE COME TO FIND OUT, DECLINES ANY RESPONSIBILITY. DO YOUR JOB!

NHTSA ID

10417413

Incident

Jul 29, 2011

Mileage

55,000 mi

TL* THE CONTACT OWNS A 2008 BMW 535I WITH MICHELIN PILOT SPORT PS2 RUN FLAT TIRES, SIZE 275/35/R18. THE CONTACT STATED THAT THE CENTER OF BOTH REAR TIRES WAS WORN TO THE POINT WHERE THE CHORD WAS VISIBLE. THERE WERE NO FAILURES WITH THE FRONT TIRES. THE ALIGNMENT WAS TESTED BUT NO FAILURES WERE FOUND. THERE WERE NO REPAIRS TO THE VEHICLE. THE DOT NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 45,000.

NHTSA ID

10416646

Incident

Jul 29, 2011

Mileage

45,000 mi

TL* THE CONTACT OWNS A 2008 BMW 535I. THE CONTACT STATED THAT THE DRIVER SIDE REAR WHEEL WAS CRACKING. AFTER PURCHASING A NEW TIRE HE THEN NOTICED THE CRACKED WHEEL IN TWO DIFFERENT PLACES. THE DEALER WAS CONTACTED WHO DECLINED TO WARRANT THE WHEELS. THE MANUFACTURER WAS CONTACTED WHO ALSO STATED THAT THEY WOULD NOT WARRANT THE FAILURE. THE WHEELS WERE REPAIRED AT A COST OF $484 BY THE CONTACT. THEY OFFERED NO OTHER ASSISTANCE. THE FAILURE MILEAGE WAS 27,000.

NHTSA ID

10406830

Incident

Jun 13, 2011

Mileage

27,000 mi

THREE WKS AGO MY 08 528I WAS MAKING A RATTLING SOUND IN THE ENGINE, TIN-CAN SOUNDING. TOOK THE CAR FOR SERVICE & THEY REPLACED MY LIFTERS AND RELATED PARTS. THEY SAID THAT THE LIFTERS ARE "KNOWN" FOR GOING BAD ON THE 5 SERIES AND IT'S TYPICALLY DUE TO SEASONAL CHANGES. WHEN MY HUSBAND BROUGHT THE CAR HOME TO ME I WAS VERY UPSET BECAUSE THE NOISE WAS STILL THERE, NOT AS LOUD AS BEFORE. I CALLED BMW AND MADE ANOTHER APPOINTMENT, CITING THAT THIS PROBLEM HAD NOT BEEN RESOLVED AND IT NEEDED TO BE LOOKED AT AGAIN. THE APPOINTMENT WITH A LOANER COULD NOT BE SCHEDULED FOR ANOTHER 10 DAYS, SO WE WAITED. DURING THOSE 10 DAYS THE VEHICLE STARTED TO TAKE LONGER TO TURNOVER AT START UP. I WOULD ALSO FEEL THE ENGINE LIGHTLY SHUTTERING AS I DROVE AT SPEEDS AVERAGING 35-50 MILES PER HOUR. MONDAY 05/23/11 WAS MY REQUESTED APPOINTMENT; HOWEVER BECAUSE MY 15 MO. OLD BABY WAS ILL WE HAD TO CANCEL. THANK GOODNESS WE DID BECAUSE MY CAR WOULD NOT HAVE MADE IT THE 20 MILES OF FREEWAY TO THE DEALERSHIP. TODAY, 05/25/11, I MADE A LEFT OUT OF MY NEIGHBORHOOD AND AS I ACCELERATED APPROX. 50 YARDS, MY ENGINE BUCKED (FELT LIKE THE BOTTOM FELL OUT), I LOST SPEED DRAMATICALLY. SUDDENLY, STEERING BECAME NEARLY IMPOSSIBLE AND I WAS FORCED TO "TURN" INTO A SMALL SHOPPING CENTER. HOWEVER, I LOST ABILITY TO STEER UPON ENTERING THE PARKING LOT. MY CAR WOULD RESPOND TO NOTHING BUT THE BRAKES (THANK GOD THOSE ATLEAST WORKED). I LOOKED DOWN AT MY GEAR SHIFT TO ATTEMPT TO REVERSE AWAY FROM THE CURB AND MANEUVER INTO A PARKING SPACE, THOUGH MY CAR WAS THROWN INTO NEUTRAL & WOULD NOT RESPOND TO ANYTHING BUT "PARK". I ATTEMPTED TO STARTUP AGAIN BUT ENGINE WOULDN'T TURN OVER. IT WAS DEAD. WITHIN MOMENTS MY ABS, CHECK ENG, AND BATTERY LIGHTS ILLUMINATED & CORRESPONDING MSGS CAME ONTO MY COMMUNICATION SCREEN. CAR WAS TOWED. AWAITING DEALERSHIP RESPONSE IN THE AM. AFTER SEEING PRIOR COMPLAINTS, I SEE SOMEONE NEEDS TO BE FIRED. THE US GOVERNMENT NEEDS TO STEP IN BEFORE PEOPLE DIE! THANK GOD MY BABY WASN'T WITH ME! *TR

NHTSA ID

10402778

Incident

May 25, 2011

Mileage

28,700 mi