1990 BMW 525I Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1990 BMW 525I, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine616.2%
- Brakes410.8%
- Electrical38.1%
- Heating & air conditioning38.1%
- Powertrain (other)38.1%
- Visibility25.4%
- Body & structure25.4%
- Fuel system25.4%
- Interior & seats25.4%
- Exterior lighting25.4%
- Transmission25.4%
- Airbags25.4%
- Steering25.4%
- Driver assistance12.7%
- Suspension12.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
(1) MY 1990 BMW 525I STARTED TO OVER HEAT ON AUGUST 01,2006. THE TEMP GAUGE GOES UP 50% MARK. THE COOLANT LEVEL WENT DOWN EVERY DAY AND I FILLED IT UP WITH DISTILLED WATER TO CONTROL THE TEMPERATURE, HOPING THAT IT WOULD CORRECT ITSELF SOME TIME. (2) I COULD NOT DRIVE THE CAR ON REGULAR BASIS ANYMORE. WITHIN FEW DAYS, I SAW COOLANT OVERFLOWING AND SPRAY-OUT. FOLLOWING THIS, I NOTICED SLIGHT ROUGH IDLE AND VIBRATION. (3) REALIZING THAT DRIVING THE CAR WAS NO MORE SAFE, I CALLED WESTCHESTER BMW, WHITE PLAINS, NY. ON EMERGENCY BASIS, THE DEALER ACCEPTED THE CAR THE FOLLOWING WEEK FOR DIAGNOSIS. ON AUGUST 14 2006, THE DEALER CONCLUDED IT IS COOLANT LEAKING IN THE ENGINE AND OUTSIDE THE ENGINE. NO PARTS WERE REPAIRED AND REPLACED BECAUSE THE ENGINE WORK SPECIFIED BY THE DEALER WAS EXPENSIVE. I TOOK THE CAR BACK HOME. CAN NOT DRIVE IT ANYMORE. *JB
WHILE DRIVING, COOLANT LEVEL WARNING LIGHT ILLUMINATED AND CONSUMER NOTICED WHITE SMOKE COMING FROM THE REAR OF THE VEHICLE, CONSUMER FOUND THAT WATER WAS IN THE OIL DUE TO A CRACKED HEAD, CONSUMER LATER RECEIVED RECALL 98V178. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
BRAKE LIGHT FAILED NO DAMAGE, DEALER WON'T HONOR RECALL #96V111000. *AK
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
REAR DOOR WILL NOT OPEN FROM INSIDE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Heating & air conditioning
Reports naming the heating, ventilation and air-conditioning system.
From owner reports, verbatim
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
REAR DOOR WILL NOT OPEN FROM INSIDE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
REAR DOOR WILL NOT OPEN FROM INSIDE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
REAR DOOR WILL NOT OPEN FROM INSIDE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
REAR DOOR WILL NOT OPEN FROM INSIDE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
REAR DOOR WILL NOT OPEN FROM INSIDE.
BRAKE LIGHTS INOPERATIVE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
REAR DOOR WILL NOT OPEN FROM INSIDE.
BRAKE LIGHTS INOPERATIVE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
CONSUMER COMPLAINED ABOUT THE LOW BEAM HEADLIGHTS. LIGHTS WENT OUT WITHOUT WARNING. THIS HAPPENED INTERMITTENTLY. *AK
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
REAR DOOR WILL NOT OPEN FROM INSIDE.
BRAKE LIGHTS INOPERATIVE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
WHILE DRIVING 30 MPH THE VEHICLES AIR BAGS DEPLOYED WITHOUT WARNING. *NLM
CONSUMER WAS DRIVING 30 MPH WITHOUT VEHICLE COLLISION OCCURRING THE DRIVER'S AIR BAG DEPLOYED, CAUSING THE OCCUPANT TO BECOME INJURED. PLEASE GIVE ANY FURTHER DETAILS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
I REALIZED MY CAR WAS WRECKED SEVERAL TIMES, IT'S A SALVAGED CAR, BUT SOLD AS NORMAL; THEREFORE OVERPRICED. *AK
REAR DOOR WILL NOT OPEN FROM INSIDE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .