1994 BMW 525I Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1994 BMW 525I, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine330.0%
- Interior & seats220.0%
- Driver assistance110.0%
- Heating & air conditioning110.0%
- Steering110.0%
- Transmission110.0%
- Visibility110.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
CONSUMER HAS SAME PROBLEM WITH COOLANT SYSTEM AS STATED IN RECALL 98V178000. BUT, THIS VEHICLE WAS NOT INCLUDED IN RECALL DUE TO VIN. *AK
RADIATOR BLEW OUT WHILE DRIVING AT 55 MPH, CAUSING VEHICLE TO OVERHEAT. ALSO, HEATER CORE CRACKED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
CONSUMER'S VEHICLE WAS HAVING THE SAME DOOR LOCK/LATCH PROBLEM AS STATED IN RECALL 94V219000. BUT THIS VEHICLE WAS NOT INCLUDED IN RECALL DUE TO VIN. *AK
SECURITY SYSTEM ENGAGED WHILE OCCUPANTS INSIDE, OCCUPANTS TRAPPED INSIDE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
AFTER HAVING RECALL REPAIR WORK DONE LAST WEEK VEHICLE IS STILL EXPERIENCING SAME PROBLEM, THE THROTTLE WILL REMAIN OPEN, WHILE DRIVING VEHICLE. RECALL # 97V131000. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Heating & air conditioning
Reports naming the heating, ventilation and air-conditioning system.
From owner reports, verbatim
HEAD GASKET WAS REPLACED UNDER WARRANTY 3/31/98 DUE TO OIL LEAK. FAILED AGAIN ON 4/28/99 AT 55900 MILES. WHITE EXHAUST SMOKE AND COOLANT DROP OG 35 MM IN 2438 MILES. AIR CONDITIONER COMPRESSOR NOISY AND VIBRATES STEERING WHEEL AND DOES NOT COOL AT IDLE. COMPLAINT UNDER WARRANTY ON 3/31/98 NOT FIXED. REPLACED IDLER PULLEY ONLY. GETTING WORSE ON 4/30/99 AT 56400 MILES.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
SECURITY SYSTEM ENGAGED WHILE OCCUPANTS INSIDE, OCCUPANTS TRAPPED INSIDE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
MY TRANSMISSION WENT OUT IN MY 1994 BMW 525I. THIS HAS BEEN REPORTEDLY HAPPENING TO MANY OF US. THE FAILURE WAS IN THE REVERSE GEAR FIRST, THEN THE FIRST TWO FORWARD GEARS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
RADIATOR BLEW OUT WHILE DRIVING AT 55 MPH, CAUSING VEHICLE TO OVERHEAT. ALSO, HEATER CORE CRACKED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .