2006 BMW 525I Owner Complaints

The contact owns a 2006 BMW 525I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated while driving approximately 30 MPH, she noticed the odor of burning plastic. The contact stated that the check radiator light was illuminated. The contact stated that she drove the vehicle to a dealer. The dealer diagnosed that the failure was with the PCV valve and replaced the PCV valve. The vehicle was repaired; however, the contact was billed by the dealer for the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was 235,641. The manufacturer was made aware of the issue. VIN tool confirms parts not available.

NHTSA ID

11491227

Incident

Apr 16, 2022

Mileage

235,641 mi

I received a notice in the mail stating that my vehicle with the matching Vin had a recall for the pc value heater. And that it causes the vehicle to over heat and catch fire I contacted the dealership and manufacturer and I was told that there was no remedy available as I started experiencing issue's with my vehicle. It worries me because I constantly have my grandchildren with me and don't want them in a unsafe vehicle.

NHTSA ID

11464424

Incident

Apr 4, 2022

The contact owns a 2006 BMW 525i. The contact stated while driving 60-65 MPH, the vehicle started to overheat. The coolant temperature warning light was illuminated. The contact veered to the side of the road and added coolant in the vehicle. The contact then continued to drive. The contact stated that the failure reoccurred while driving. The contact stated that he replaced the thermostat himself. However, the failure persisted and the vehicle failed to start. The vehicle was towed to the residence. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 135,000. VIN tool confirms parts not available.

NHTSA ID

11463215

Incident

Jan 3, 2021

Mileage

135,000 mi

The contact owns a 2006 BMW 525I. The contact stated that there was a strong fuel odor coming from the vehicle. The vehicle was taken to an independent mechanic and the dealer where it was both diagnosed that the vehicle was leaking fuel. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 188,318.

NHTSA ID

11442068

Incident

Nov 4, 2021

Mileage

188,318 mi

TL* THE CONTACT OWNS A 2006 BMW 525I. THE CONTACT STATED THAT THE AIR BAGS WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER PASSPORT BMW (4730 AUTH PL, SUITLAND-SILVER HILL, MD 20746, (301) 423-2700) WHERE IT WAS DIAGNOSED WITH NEEDING A BOLT TIGHTENED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 17V428000 (AIR BAGS). THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 112,000.

NHTSA ID

11394638

Incident

Feb 1, 2021

Mileage

112,000 mi

RED AIRBAG LIGHT AND RED SEAT BELT LIGHT CAME ON AND THERE WAS A CHIME GOING OFF. PASSENGER SEAT OCCUPANCY MAT IS GIVING A FAULT CODE AND DISABLING THE PASSENGER SIDE AIRBAG

NHTSA ID

11290732

Incident

Dec 15, 2019

Mileage

188,000 mi

BRAKE BOOSTER IS LOOSING VACUUM WHEN SITTING OVER NIGHT CAUSING THE BRAKE PEDAL TO BE ROCK HARD AT STARTUP. THE BRAKES ARE FINE AGAIN AS SOON AS THE CAR STARTS. I KNOW THAT THE E65 FROM THE SAME YEARS HAS A RECALL ON THE BRAKE BOOSTER VACUUM LINE AND CHECK VALVE.

NHTSA ID

11271265

Incident

Oct 19, 2019

Mileage

187,000 mi

WAS ROTATING MY TIRES. THE TIRES HAVE OVER HALF THE USABLE THREAD LEFT ON THEM. FOUND CRACKING AND BLISTERS ON THE TIRE WALL ON THE INSIDE NEAR THE RIM EDGE WHICH WAS NOT VISIBLE UNTIL I GOT THE WHEELS OFF.

NHTSA ID

11256763

Incident

Sep 19, 2019

Mileage

160,000 mi

WAS ROTATING MY TIRES. THE TIRES HAVE OVER HALF THE USABLE THREAD LEFT ON THEM. FOUND CRACKING AND BLISTERS ON THE TIRE WALL ON THE INSIDE NEAR THE RIM EDGE WHICH WAS NOT VISIBLE UNTIL I GOT THE WHEELS OFF.

NHTSA ID

11256761

Incident

Sep 19, 2019

Mileage

160,000 mi

I WAS ON MY WAY TO WORK AND HAD DRIVEN ONLY 4 1/2 MILES AT 6:55AM ON THURSDAY, AUGUST 15, 2019. I WAS ABOUT 1/2 FROM WORK ON A CITY STREET WHEN SMOKE BEGAN COMING OUT THE AIR VENTS AND STEERING COLUMN. A SMELL OF PLASTIC, ELECTRICAL FILLED THE CAR AND I PULLED INTO THE NEAREST PLACE WHEN THE SMOKE WAS QUICKLY INCREASING. MY SON AND I JUMPED OUT OF THE CAR AND CALLED 911. THE FIRE DEPARTMENT ARRIVED ALMOST IMMEDIATELY, AND UPON PULLING UP, BEFORE THEY COULD GET OUT OF THE TRUCK, THE DRIVER'S SIDE CURTAIN AIRBAG EXPLODED, THE FIREMEN HEARD THE EXPLOSION. BY THE TIME THEY PULLED THEIR HOSES AND LIFTED THE HOOD, SMOKE WAS HEAVILY COMING FROM THE CAR. WHEN THE AIRBAG EXPLODED, A LARGE PIECE OF PLASTIC SHRAPNEL WAS BLOWN TO THE PASSENGER SIDE OF THE CAR AND STUCK BETWEEN THE WINDSHIELD AND THE WINDOW AND STUCK INTO THE EDGE WINDSHIELD FRAME. THE FIREFIGHTERS TRIED FOR SEVERAL MINUTES TO GET THE SOURCE UNDER CONTROL AND FINALLY WAS ABLE TO WHEN THEY DISCONNECTED THE BATTERY. I HAD MY CAR TOWED TO BMW COLUMBUS, THEY "REPAIRED THE RECALL" AND SAID THAT THE FIRE WAS NOT A RESULT OF THE RECALL. I BELIEVE THAT IF THE FIREFIGHTERS DID NOT RESPOND AS QUICKLY AS THEY DID BECAUSE THEY WERE NEARBY, THEN MY CAR WOULD HAVE GONE UP IN FLAMES.

NHTSA ID

11246298

Incident

Aug 15, 2019

Mileage

180,000 mi

TL* THE CONTACT OWNS A 2006 BMW 525-I. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WITH THE ENGINE TURNED OFF, SMOKE STARTED EMERGING FROM THE ENGINE COMPARTMENT. THE HOOD WAS OPENED AND A FIRE WAS DISCOVERED COMING FROM THE PASSENGER SIDE. THE FIRE DEPARTMENT WAS CALLED AND THEY EXTINGUISHED THE FIRE. THE POLICE WAS PRESENT AND A REPORT WAS ISSUED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 307,726.

NHTSA ID

11240285

Incident

Jul 15, 2019

Mileage

307,726 mi

BECAUSE OF POOR QUALITY OF FIBER OPTICS WIRING USED ON THE HEADLIGHT THEY TEND DRY ROT RESULTING IN A BURNT OUT HEADLIGHT. WHICH CAN BECOME A SAFETY HAZARD.

NHTSA ID

11220400

Incident

Feb 7, 2018

Mileage

100,000 mi

WE RECEANTLY PURCHASED A USED BMW 525 I. AND IT SUDDENLY CAUGHT ON FIRE WHILE MY SON CAME TO A STOP. HE BARLEY EXCAPED WITH HIS LIFE. THE WHOLE CAR WAS UP IN FLAMES. WE DONT KNOW WHERE IT CAME FROM BUT IT WAS THE WORST THING THAT I SEEN. THANK GOD HE WAS ABLE TO GET OUT OF THE VEHICLE WHEN HE DID. WE NEVER THOUGHT WE WOULD HAVE TO WORRY ABOUT HIS SAFETY IN THIS VEHICLE, BEING ONE OF THE TOP OF THE LINE VEHICLES!

NHTSA ID

11184997

Incident

Mar 2, 2018

MY PASSENGER SEAT BELT RESTRAINTS AND AIRBAG WARNINGS LIGHT COMES ON. I SAW THAT THIS YEAR WAS INCLUDED IN MY MODEL 525I, BUT BMW OF HONOLULU SAID MY BIN SHOWS NO RECALL? I'M CONFUSED AND UPSET ON HOW BMW CAN RISK SUCH A SAFETY ISSUE BY NOT INCLUDING ALL AFFECTED BY THIS ESPECIALLY MY YEAR AND MODEL CLASS BECAUSE IT'S OBVIOUSLY AN ISSUE WE ALL ARE HAVING AROUND THE SAME EXACT TIME. IS THERE A SOLUTION OR SHOULD I GIVE UP ON BMW FOR SUCH NEGLECT FOR MY SAFETY AND YOURS?

NHTSA ID

11156403

Incident

Jun 8, 2018

PASSENGER AIR BAG RESTRAINT LIGHT IS ACTIVATED.

NHTSA ID

11143963

Incident

Oct 1, 2018

I RECENTLY STARTED GETTING PASSENGER RESTRAINT SYSTEM WARNING MESSAGE APPEARING. AFTER SEARCHING ONLINE, I DISCOVERED 2006 525I VEHICLES HAVE A RECALL ON THE SAME ISSUE. HOWEVER WHEN I CONTACTED BMW, I WAS TOLD BASED ON VIN NUMBER MY VEHICLE IS NOT UNDER ANY RECALL EVEN THOUGH I HAVE SAME ISSUE WITH THE VEHICLES UNDER RECALL AND REFERENCED NHTSA CAMPAIGN NUMBER: 17V428000 (AIR BAGS). CURRENTLY, THE PASSENGER AIRBAG WILL NOT DEPLOY AND CAN CAUSE SERIOUS HARM TO THE PASSENGER IF INVOLVED IN ANY TYPE OF ACCIDENT, THEREFORE, MY VEHICLE SHOULD BE PART OF THE RECALL.

NHTSA ID

11128103

Incident

Aug 30, 2018

Mileage

126,525 mi

WARNING LIGHT PASS. RESTRAINT SYSTEM FAULT IN PASSENGER RESTRAINT SYSTEM AFFECTING AIRBAG BELT TENSIONER ETC

NHTSA ID

11090232

Incident

Apr 23, 2018

Mileage

140,000 mi

I RECENTLY STARTED GETTING PASSENGER RESTRAINT SYSTEM WARNING MESSAGE APPEARING. AFTER SEARCHING ONLINE, I DISCOVERED 2006 525I VEHICLES HAVE RECALL ON THE SAME ISSUE. HOWEVER WHEN I CONTACTED BMW, I WAS TOLD BASED ON VIN NUMBER MY VEHICLE IS NOT UNDER ANY RECALL EVEN THOUGH I HAVE SAME ISSUE WITH THE VEHICLES UNDER RECALL. AS IS, THE PASSENGER AIRBAG WILL NOT DEPLOY AND CAN CAUSE SERIOUS HARM TO THE PASSENGER, THEREFORE MY VEHICLE SHOULD BE PART OF THE RECALL.

NHTSA ID

11088461

Incident

Apr 2, 2018

MY BMW APPEARS TO THE HAVE AN ISSUE WITH THE PASSENGER AIR BAG SENSOR, BUT THE VIN ISN'T INCLUDE IN THE RECALL LIST. KINDLY REQUEST RECALL, AS THE VEHICLE HASN'T BEEN IN AN ACCIDENT, BUT PASSENGER AIR BAG LIGHT REMAINS ON.

NHTSA ID

11078903

Incident

Jun 14, 2017

Mileage

105,000 mi

WAS DROPPING OFF A PASSENGER AND WHEN I PARKED ON A CITY STREET .HE TOOK HIS SEATBELT OFF AND OPENED THE PASSENGER DOOR . WHEN HE GOT OFF THE SEAT I NOTICED TWO LIGHTS COME ON IN THE DASHBOARD . THEN THE NOTIFICATION CAME UP ON MY MENU SCREEN DISPLAYING RESTRAINT AUSTEN MALFUNCTION . I'VE LOOKED UP MY 2006 BMW 525I TO NOTICE IT HAPPENING TO ALLOT OF THE SAME YEAR MAKE AND MODEL AS MINE.

NHTSA ID

11066112

Incident

Dec 21, 2017

Mileage

143,000 mi

TL* THE CONTACT OWNS A 2006 BMW 525I. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO BMW OF HOUSTON NORTH IN HOUSTON, TX WHERE IT WAS DIAGNOSED THAT THE PASSENGER DETECTION MAT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 17V428000 (AIR BAGS). THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 158,000.

NHTSA ID

11046039

Incident

Jul 6, 2017

Mileage

158,000 mi

BRAKES ARE NOT WORKING (STALLING) AFTER FULLY STOPPING AND REAPLYING BRAKE AT A LOWER SPEED. BRAKE PADEL IS BECOMING VERY HARD AND EVEN WITH ALL FOOT FORCE BRAKE PADEL IS NOT BEING DEPRESSED. I HAD MY KIDS IN THE CAR WHEN THIS HAPPENED. I READ IT ONLINE SIMILAR PROBLEM ACCURED IN OTHER BMW MODEL AND RECALL BULLETIN WAS ISSUED. THIS ISSUE IS VERY SERIOUS AND I'M WILLING TO LET INVESTIGATORS CHECK MY VEHICLE IF THEY WISH TO CHECK OUT THE PROBLEM. THANK YOU [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11014976

Incident

Aug 9, 2017

Mileage

146,000 mi

WATER PUMP WAS REPLACED TWICE THE THIRD TIME I WAS DRIVING CITY STREET CAR STOPPED HAD TO TOW IT HOME.

NHTSA ID

10971514

Incident

Apr 8, 2015

SEATBELT NOT RETRACTING AND WARNING LIGHT STATING SEATBELT AND AIRBAG MAY NOT FUNCTION IN CRASH. INITIALLY INTERMITTENT BUT NOW STEADY WARNING LIGHTS. * EXTREME FADING OF PAINT ON HOOD, ROOF, DECK LID.

NHTSA ID

10934341

Incident

May 11, 2016

Mileage

40,000 mi

I HAVE A 2006 BMW 525I AND RECEIVING PASS. RESTAINT SYSTEM MALFUNCTION AFFECTING THE AIRBAG. THIS IS A PROBLEM BMW SHOULD SERVICE AS THEY ARE FAMOUS FOR THESE MALFUNCTIONS. IT IS DANGEROUS AND ITS RUINS THE INTEGRITY OF THE VEHICLE.

NHTSA ID

10925357

Incident

Nov 9, 2016

Mileage

165,000 mi