1998 BMW 528I Problems

TL* THE CONTACT OWNS A 1998 BMW 528I. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED FIVE YEARS AGO. THE CONTACT ATTEMPTED TO USE A CODE READER TO DIAGNOSE THE DEFECT, BUT NO CODE WAS DISCOVERED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

-TAKATA -ABS MODULE MALFUNCTION DUE TO MODULE BEING FRIED BY EXCESSIVELY ENGINE HEAT -DSC SYSTEM FAILURE DUE TO POOR WIRING AND HEAT FROM POOR PLACEMENT IN ENGINE BAY THIS HAS CAUSED MULTIPLE ISSUES WITH DRIVE ABILITY AND SAFETY I'VE BEEN COMPLAINING FOR QUITE AWHILE THAT THE CAR HAS BEEN HAVING SAFETY ISSUES AND BMW IGNORES ME AND MY COMPLAINTS. *TR

THE LEFT SIDE OF THE DRIVER SEAT ONLY TILTS FORWARD AND BACKWARD A LITTLE AND THE OTHER SIDE STAYS STATIONARY. ALL OTHER SEAT FUNCTIONS WORK EXCEPT THAT.

TL*THE CONTACT OWNS A 1998 BMW 528I. THE CONTACT STATED THAT THE DRIVER SIDE DOOR HANDLE INSIDE THE PASSENGER COMPARTMENT WOULD FALL OFF IN HER HAND. THE FAILURE OCCURRED A TOTAL OF EIGHT TIMES AND PREVENTED HER FROM EXITING THE VEHICLE. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE CONTACT REPAIRED THE FAILURE HERSELF ON SEVEN OCCASIONS BECAUSE IT WOULD COST $249 TO REPAIR IT AT A DEALER. THE CURRENT MILEAGE WAS 117,000 AND FAILURE MILEAGE WAS APPROXIMATELY 50,000.

TL*THE CONTACT OWNS A 1998 BMW 528I. WHILE THE ENGINE WAS RUNNING, THE CONTACT SMELLED SOMETHING BURNING. HE DISCOVERED THAT THE BRAKE LIGHT FOR THE WINDOW BURNED THROUGH THE HOUSING AND FELL INTO THE TRUNK. THE BULB LANDED BY THE FUEL TANK. NO REPAIRS HAVE BEEN MADE AND THE CAUSE OF THE FAILURE WAS UNKNOWN. FURTHERMORE, THE PASSENGER AND DRIVER SIDE HANDLES FAILED TO OPEN THE DOORS FROM INSIDE THE PASSENGER COMPARTMENT. THE DOORS WOULD ONLY OPEN FROM THE OUTSIDE. THE FAILURE MILEAGE WAS 138,000 AND CURRENT MILEAGE WAS 166,000.

THE FRONT DRIVER SIDE INSIDE PLASTIC DOOR HANDLE SNAPPED. THIS CAUSED THE CONSUMER TO ROLL THE WINDOW DOWN TO USE THE OUTSIDE DOOR HANDLE TO EXIT THE VEHICLE. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK BMW CONSIDERED THE PROBLEM TO BE AN INTEGRAL PART/TRIM AND DID NOT HONOR THE WARRANTY. THE DRIVER DOOR SQUEAKED UPON OPENING AND CLOSING AND THERE WAS A SQUEAK COMING FROM THE RIGHT SIDE OF THE VEHICLE THAT WOULD GO UP TO 35 MPH IN WHICH THE DEALER COULD NOT DUPLICATE THE PROBLEM. *SC *JB

TWO MAJOR COMPLAINTS: 1. TRANSMISSION OF THE CAR BROKE DOWN COMPLETELY WITHIN 82,000 MILES. I HAD TO SPEND A LARGE AMOUNT OF MONEY TO REPLACE THE TRANSMISSION. 2. POWER STEERING OF THE CAR HAD EXPERIENCED LEAK SINCE I BOUGHT THE CAR. STILL AFTER SO MANY YEARS THE PROBLEM HAS NOT BEEN PROPERLY RECTIFIED DESPITE THE FACT THAT I BROUGHT THIS TO THE ATTENTION OF THE DEALER. 3. AFTER I GAVE MY CAR TO THE ANN ARBOR BMW DEALER, ONCE THEY REPLACED SOME UNRELATED MECHANICAL COMPONENTS THAT COST ME OVER $600. HOWEVER, AFTER PAYING THE MONEY WHEN I SHOWED THAT THE PROBLEM DID NOT SOLVE, THE MECHANICS ADDED SOME BRAKE FLUID AND THE PROBLEM TEMPORARILY DISAPPEARED. THE DEALER DID NOT REIMBURSE THE MONEY FOR INAPPROPRIATELY CHANGING UNNECESSARY COMPONENTS. AGAIN AFTER A FEW MONTHS WHEN I BROUGHT THE CAR BACK WHEN THE PROBLEM RESURFACED DUE TO LOW BRAKE FLUID.R. AFTER I DROVE THE CAR OUT OF DEALERS PREMISE, THE ENGINE STARTED GETTING HEATED UP. I BROUGHT THE CAR BACK AND LEFT IT WITH THE DEALER WHO CALLED ME THE NEXT DAY ASKING ME TO PAY ABOUT $250 TO CHANGE THE THERMOCOUPLE, WHICH I AUTHORIZED. HOWEVER, AFTER SEVERAL HOURS THE DEALER CLAIMED THAT THE ENGINE WAS STILL GETTING HEATED UP AND DEMANDED AN OPEN AUTHORIZATION SO THAT THEY COULD OPEN UP THE ENGINE. WHEN I ASKED HIM HOW MUCH IT COULD COST ME, THE DEALER TOLD ME THAT IT WOULD COST UP TO $5000. THE DEALER HELD MY CAR FOR OVER 14 DAYS WITHOUT GIVING ME A TEMPORARY CAR OR VERIFYING WHETHER THE ENGINE WAS REALLY GETTING HEATED UP AFTER HE CHANGED THE THERMOCOUPLE. THE DEALER CLAIMED THAT IT WOULD BE DANGEROUS TO DRIVE THE CAR IN THAT CONDITION. AFTER 14 DAYS, DESPITE WRITING TO BMW AMERICA AND THE DEALERS HEAD OFFICE, THE DEALER KEPT ON CLAIMING THAT I WOULD HAVE TO AUTHORIZE THEM FOR FURTHER WORK THAT MIGHT COST ME AT LEAST $1500. FINALLY, I DECIDED TO TAKE THE CAR FROM THE DEALER AND GIVE TO ANOTHER MECHANICS WHO FOUND OUT THERE WAS NO PROBLEM WITH THE ENGINE. TILL NOW THE ENGINE DOES NOT HEAT UP. *TR

WHILE DRIVING DOWN THE HIGHWAY (MARICOPA HWY) MY STEERING WHEEL BEGAN TO SPIN AROUND AND IT HAD NO AFFECT ON THE STEERING OF MY BMW, IN OTHER WORDS I COULD NOT OR I HAVE LOST THE STEERING CAPACITY, THE STEERING WHEEL JUST SPINS. *TR

-TAKATA -ABS MODULE MALFUNCTION DUE TO MODULE BEING FRIED BY EXCESSIVELY ENGINE HEAT -DSC SYSTEM FAILURE DUE TO POOR WIRING AND HEAT FROM POOR PLACEMENT IN ENGINE BAY THIS HAS CAUSED MULTIPLE ISSUES WITH DRIVE ABILITY AND SAFETY I'VE BEEN COMPLAINING FOR QUITE AWHILE THAT THE CAR HAS BEEN HAVING SAFETY ISSUES AND BMW IGNORES ME AND MY COMPLAINTS. *TR

WHILE PULLING INTO GARAGE WITH FOOT OFF GAS AND ON BRAKE, VEHICLE ACCELERATED UNEXPECTEDLY INTO GARAGE WALL, PLACED CAR INTO REVERSE, THEN SHOT OUT OF FRONT OF GARAGE ALL WITHOUT PLACING FOOT ON GAS.*AK

THE WIRING HARNESS THAT ENTERS THE TRUNK LID THAT SUPPLIES THE LIGHTS FOR THE REAR LICENSE PLATE AND THE TRUNK LID RELEASE HAS FRAYED AT THE EXACT POINT WHERE THE HARNESS ENTERS THE TRUNK LID. THE WIRING COMES IN DIRECT CONTACT WITH THE SHARP EDGE AT THE OPENING IN THE TRUNK LID, AND SEVERAL OF THE WIRES HAVE BROKEN AT THIS POINT, RESULTING IN FAILURE OF THE LICENSE PLATE LIGHTS. IN ADDITION, THE DASHBOARD INDICATOR SHOWS THAT THE TRUNK LID IS OPEN EVEN THOUGH IT'S LOCKED. I PERFORMED AN INTERNET SEARCH AND THIS SEEMS TO BE A COMMON PROBLEM WITH SEVERAL BMW MODELS.

THE STEERING WHEEL INTERMITTENTLY MOVES UP AND DOWN ON ITS OWN WHILE DRIVING. IN ADDITION, THE BRAKE LIGHTS STAY ON CONSTANTLY AND THE AIR BAG INDICATOR LIGHT ON THE DASH COMES ON INTERMITTENTLY. *JB

DRIVING ON ENTRANCE RAMP TO THE FREEWAY AT ABOUT 10MPH AND SAW WHITE SMOKE COMING FROM THE DRIVER'S SIDE OF THE HOOD. PULLED OVER AND INSPECTED COOLANT SYSTEM AND FOUND THAT THE NECK HAD BROKEN OFF THE RADIATOR(COMMON PROBLEM WITH E39) ALLOWING COOLANT TO SPRAY INTO THE ENGINE COMPARTMENT. I WAS LUCKY THAT I WAS TRAVELLING SLOWLY AND WAS ABLE TO PULL OVER RAPIDLY BEFORE CAR OVERHEATED. COULD HAVE CAUSED A DANGEROUS SITUATION IF IT HAD OCCURED AT HIGHWAY SPEEDS. CAR WAS TOWED TO MECHANIC, WHO REPLACED OLD RADIATOR WITH AN AFTERMARKET BRAND THAT IS MORE ROBUST THAN BMW RAD. I WAS NOT COMFORTABLE USING A BMW RADIATOR DUE TO THEIR CHEAP AND FLAWED DESIGN.

AFTER HAVING THE VEHICLE SERVICED AND A POWERSTEERING HOSE REPLACED, THE VEHICLE WAS LOOSING A LOT OF FUEL IN THE ENGINE COMPARTMENT (7 GALLONS IN 10 MILES). IT TURNED OUT TO BE A FUEL LINE CONNECTION ON THE DRIVERS SIDE IN THE ENGINE COMPARTMENT THAT WAS NOT FULLY CONNECTED AND SPRAYED FUEL OUT. THE CONNECTION IS A FACTORY STANDARD QUICK CONNECT TYPE.. IN MY OPINION, FUEL LINES SHOULD NOT BE OF THIS TYPE OF QUICK CONNECTION, SINCE FAILURE TO PROPERLY CONNECT THE LINES MAY HAVE DETRIMENTAL RESULTS. FUEL LINES SHOULD HAVE THREADED OR SIMILAR TYPE OF CONNECTION. ONCE DISCONNECTED THEY WOULD REQUIRE AN EFFORT IN CONNECTING AND MAY NOT RESULT IN AN INADVERTANT OVERSIGHT. IN MY CASE, IT JUST SPRAYED OUT LOTS OF FUEL IN A SHORT AMOUNT OF TIME WHILE DRIVING.

-TAKATA -ABS MODULE MALFUNCTION DUE TO MODULE BEING FRIED BY EXCESSIVELY ENGINE HEAT -DSC SYSTEM FAILURE DUE TO POOR WIRING AND HEAT FROM POOR PLACEMENT IN ENGINE BAY THIS HAS CAUSED MULTIPLE ISSUES WITH DRIVE ABILITY AND SAFETY I'VE BEEN COMPLAINING FOR QUITE AWHILE THAT THE CAR HAS BEEN HAVING SAFETY ISSUES AND BMW IGNORES ME AND MY COMPLAINTS. *TR

TL*THE CONTACT OWNS A 1998 BMW 528I. WHILE THE ENGINE WAS RUNNING, THE CONTACT SMELLED SOMETHING BURNING. HE DISCOVERED THAT THE BRAKE LIGHT FOR THE WINDOW BURNED THROUGH THE HOUSING AND FELL INTO THE TRUNK. THE BULB LANDED BY THE FUEL TANK. NO REPAIRS HAVE BEEN MADE AND THE CAUSE OF THE FAILURE WAS UNKNOWN. FURTHERMORE, THE PASSENGER AND DRIVER SIDE HANDLES FAILED TO OPEN THE DOORS FROM INSIDE THE PASSENGER COMPARTMENT. THE DOORS WOULD ONLY OPEN FROM THE OUTSIDE. THE FAILURE MILEAGE WAS 138,000 AND CURRENT MILEAGE WAS 166,000.

MY 1998 BMW 5-SERIES 528I STARTED ACCELERATING ON IT'S OWN WHEN I WAS DRIVING, AND I HAD TO KEEP MY FOOT ON THE BRAKE AND ALMOST RAN A FEW RED LIGHTS. WHEN I PARKED MY CAR I HAD TO PUT IT IN NEUTRAL TO TURN IT OFF AND I TRIED STARTING IT AGAIN (WITH MY FOOT ON THE BRAKE) AND IT ACCELERATED W/OUT BEING IN DRIVE. NOW MY CAR JERKS EVERY TIME I'M DRIVING SLOW AND IT FEELS LIKE IT'S NOT SHIFTING PROPERLY ANY MORE. *TR

TWO MAJOR COMPLAINTS: 1. TRANSMISSION OF THE CAR BROKE DOWN COMPLETELY WITHIN 82,000 MILES. I HAD TO SPEND A LARGE AMOUNT OF MONEY TO REPLACE THE TRANSMISSION. 2. POWER STEERING OF THE CAR HAD EXPERIENCED LEAK SINCE I BOUGHT THE CAR. STILL AFTER SO MANY YEARS THE PROBLEM HAS NOT BEEN PROPERLY RECTIFIED DESPITE THE FACT THAT I BROUGHT THIS TO THE ATTENTION OF THE DEALER. 3. AFTER I GAVE MY CAR TO THE ANN ARBOR BMW DEALER, ONCE THEY REPLACED SOME UNRELATED MECHANICAL COMPONENTS THAT COST ME OVER $600. HOWEVER, AFTER PAYING THE MONEY WHEN I SHOWED THAT THE PROBLEM DID NOT SOLVE, THE MECHANICS ADDED SOME BRAKE FLUID AND THE PROBLEM TEMPORARILY DISAPPEARED. THE DEALER DID NOT REIMBURSE THE MONEY FOR INAPPROPRIATELY CHANGING UNNECESSARY COMPONENTS. AGAIN AFTER A FEW MONTHS WHEN I BROUGHT THE CAR BACK WHEN THE PROBLEM RESURFACED DUE TO LOW BRAKE FLUID.R. AFTER I DROVE THE CAR OUT OF DEALERS PREMISE, THE ENGINE STARTED GETTING HEATED UP. I BROUGHT THE CAR BACK AND LEFT IT WITH THE DEALER WHO CALLED ME THE NEXT DAY ASKING ME TO PAY ABOUT $250 TO CHANGE THE THERMOCOUPLE, WHICH I AUTHORIZED. HOWEVER, AFTER SEVERAL HOURS THE DEALER CLAIMED THAT THE ENGINE WAS STILL GETTING HEATED UP AND DEMANDED AN OPEN AUTHORIZATION SO THAT THEY COULD OPEN UP THE ENGINE. WHEN I ASKED HIM HOW MUCH IT COULD COST ME, THE DEALER TOLD ME THAT IT WOULD COST UP TO $5000. THE DEALER HELD MY CAR FOR OVER 14 DAYS WITHOUT GIVING ME A TEMPORARY CAR OR VERIFYING WHETHER THE ENGINE WAS REALLY GETTING HEATED UP AFTER HE CHANGED THE THERMOCOUPLE. THE DEALER CLAIMED THAT IT WOULD BE DANGEROUS TO DRIVE THE CAR IN THAT CONDITION. AFTER 14 DAYS, DESPITE WRITING TO BMW AMERICA AND THE DEALERS HEAD OFFICE, THE DEALER KEPT ON CLAIMING THAT I WOULD HAVE TO AUTHORIZE THEM FOR FURTHER WORK THAT MIGHT COST ME AT LEAST $1500. FINALLY, I DECIDED TO TAKE THE CAR FROM THE DEALER AND GIVE TO ANOTHER MECHANICS WHO FOUND OUT THERE WAS NO PROBLEM WITH THE ENGINE. TILL NOW THE ENGINE DOES NOT HEAT UP. *TR

NO REVERSE GEAR. THE REVERSE GEAR IN THE TRANSMISSION STOPPED WORKING. *TR

SPEEDOMETER IS 3 MPH OFF ON ADJUSTMENT. MJS

1998 BMW 528I REAR WINDOW EXPLODED OR INTERNAL MOTOR WENT OUT**CC *JB

AIR CONDITIONER WAS NOT WORKING PROPERLY. DEALER STATED HE KNEW WHAT WAS THE PROBLEM.*AK

CONSUMER SMELLED GAS WHILE DRIVING,.TOOK VEHICLE TO MECHANIC ,AND THEY STATED THAT CONSUMER HIT SOMETHING AND IT PUNCTURED GAS TANK, CAUSING A LEAK. CONSUMER WAS CONCERNED ABOUT PLASTIC GAS TANK. HOW EASY IT WAS TO PUNCTURE IT. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

CONSUMER STATED TAIL LIGHTS WARPED, CAUSING THEM TO BURN OUT PREMATURELY. *AK

BMW 528I SPORT WHEELS BEND AND WARP EASILY CAUSING VEHICLE TO SHIMMY AT VARIOUS SPEEDS. WHEEL REPAIR SPECIALIST AND BMW DEALERSHIPS HAVE INDICATED THAT THE ALUMINUM IS TOO THIN AND IS PRONE TO WARP. *JB