2009 BMW 528I Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2009 BMW 528I, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine1241.4%
- Electrical413.8%
- Fuel system413.8%
- Brakes26.9%
- Other / unspecified13.4%
- Seat belts13.4%
- Airbags13.4%
- Visibility13.4%
- Body & structure13.4%
- Driver assistance13.4%
- Exterior lighting13.4%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The contact owns a 2009 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that he started to smell a burning odor inside the cabin of the vehicle. The contact stated that the check engine warning light was illuminated. VIN tool confirms parts not available. The failure mileage was unknown.
I was driving and something was burning under my hood
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
I was driving and something was burning under my hood
CAR BATTERY DRAINING, INSACIABLES BRAKE FLUID TIMING FOR CHANGE OF GEAR TAKES A WHILE
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FUEL SMELL IN THE DRIVER SIDE REAR. THE FUEL PUMP LEAKS FUEL.
THE CAR SMELLS AS FUEL IS LEAKING AND THE HEADLIGHTS BLINK IN AND OUT... MY TRUNK STOP OPENING WITH KEY FOB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
Vehicle fail breaks malfunction. No response to the brakes. Push many times no break response vehicle hit vehicle in front of it could not be avoided That rotors are less than one year old there about six or 7000 miles on them. They are basically new new tires car will maintain no lights on dash no warning no airbag deployment. Vehicle going in slow speed due to heavy traffic
TL* THE CONTACT OWNS A 2009 BMW 528I. THE CONTACT STATED THAT WHILE ATTEMPTING TO DECELERATE, THE BRAKES FAILED TO RESPOND AND THE BRAKE PEDAL WAS NOT ABLE TO BE FULLY DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 59,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
I took the 2009 BMW 528i to Bridgeport BMW to have a prior safety recall (17V-673/19V-273) repaired but, it wasn't fixed and my car caught on fire last year before I got another recall letter stating that there's no remedy for the Recall Campaign No. 22V-119: PCV Valve Heater.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2009 BMW 528I. THE CONTACT STATED THAT THE PASSENGER RESTRAINT FAULT SYSTEM INDICATOR WAS CONSTANTLY ILLUMINATED ON THE INSTRUMENT PANEL. A LOCAL MECHANIC STATED THAT THE SEAT BELT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED TWICE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 56,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2009 BMW 528I. THE CONTACT STATED THAT THE AIR BAG MALFUNCTION WARNING LIGHT ILLUMINATED AS THE ENGINE WAS STARTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2009 BMW 528I. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE REAR DRIVER SIDE VIEW MIRROR WOULD INADVERTENTLY MOVE TOWARDS THE FRONT OF THE VEHICLE CAUSING THE DRIVER NOT TO HAVE THE ABILITY TO VIEW VEHICLES OUT OF THE MIRROR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. THE VIN WAS UNAVAILABLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
I took the 2009 BMW 528i to Bridgeport BMW to have a prior safety recall (17V-673/19V-273) repaired but, it wasn't fixed and my car caught on fire last year before I got another recall letter stating that there's no remedy for the Recall Campaign No. 22V-119: PCV Valve Heater.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
I WAS DRIVING THE VEHICLE ON THE HIGHWAY ABOUT 70 MILES PER HOUR - WHEN WITHOUT ANY WARNING THE VEHICLE "CHECK ENGINE LIGHT" AND "HAZARD LIGHTS CAME ON - THE FUEL GAUGE SHOWED OVER 100 MORE GALLOONS IN THE TANK THAN IT HAD PREVIOUSLY - TRIED TO ACCELERATE BUT THE CAR DID NOT RESPOND. THE ENGINE REDUCED POWER AND WAS STALLING AS I IMMEDIATELY STARTED TO CROSS THE HIGHWAY FROM THE FURTHEST LEFT LANE IN ORDER TO GET TO SAFETY ON THE RIGHT SIDE OF THE ROAD - I WAS WITH MY PARENTS AND MY HANDICAPPED NEPHEW AND SCARED FOR ALL OF OUR LIVES. THE ENGINE "SPUTTERED AND VIBRATED" BEFORE STOPPING. I DIDN'T NOTICE ANYTHING WRONG OR ANY CHANGE IN THE WAY THE CAR DROVE. THIS WAS A VERY DANGEROUS AND UNSAFE INCIDENT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
I KEEP GETTING WARNINGS THAT THE HEAD LAMP, RUNNING LAMPS ARE MALFUNCTIONING. I TOOK IT IN FOR SERVICE AND FOUND EXPOSED WIRES AND WAS TOLD THIS IS A FIRE HAZARD RESULTING IN THE HEADLIGHT WIRING INSULATION FLAKING OFF AND LEAVING COPPER WIRE EXPOSED AND WIRES ARE TOUCHING, UNINSULATED WIRES. WIRES ARE SHORTING OUT THE LIGHTS, BURNING BULBS AND CAUSE MALFUNCTIONS IN THE HEADLIGHTS, TURN SIGNALS, PARKING LIGHTS, AND DAYTIME RUNNING LIGHTS AND IS A FIRE HAZARD.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .