2016 BMW 528I Problems

The contact owns a 2016 BMW 528i. The contact stated that the vehicle was repaired under an unknown recall, and after the recall repair, while driving at an undisclosed speed, there was an abnormal oil-burning odor entering the cabin of the vehicle. The vehicle was taken to a local Midas, where it was discovered that oil was leaking onto the engine. The vehicle was not repaired due to the cost. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 32,400.

On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.

On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.

My coolant line overheated. From the leaking water pump and pcv that exploded all over my engine causing it to overheat and now how has not turned back on. Ive been without a car for months and when I seen the recall and reached out to the dealer expressing my situation they said they would get back to me and have not called or emailed or even responded in months.

The contact owns a 2016 BMW 528I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact received a message displaying a hazard symbol for the driver restraint system. The vehicle was taken to the dealer who diagnosed the fault for the driver’s side air bag Intel Stage 2. The dealer confirmed that there was an internal disconnect with the air bag that needed to be replaced. The vehicle was not repaired. The dealer confirmed that the part for the recall repair was not yet available. The manufacturer was made aware of the failure and confirmed that the repair was not included in the recall or covered under warranty. The failure mileage was 17,700. VIN tool confirms parts not available.

Some wires within the steering wheel deteriorated causing my driver air bag to no longer be connected and my horn no longer works to alert other drivers.

Vehicle: 2016 BMW 528i xDrive (VIN: [XXX]) Safety Issue / Defect Description: Strong, hazardous raw gasoline fumes began entering the passenger cabin and trunk area. On XXX, the vehicle was brought to an authorized dealership (BMW of Sterling) for diagnostic evaluation. The dealership's technician conducted a multi-point inspection and produced video evidence documenting fluid leaking from the top of the plastic fuel tank. The dealership issued Repair Order Quote #$4,824.92 to "REPLACE FUEL TANK DUE TO FUEL LEAK" and declared the vehicle unsafe. Despite diagnosing a structural fuel tank leak that allows raw gasoline and fumes to migrate into the cabin—presenting an immediate fire, explosion, and toxic vapor risk—BMW of North America and the dealership have refused warranty coverage or goodwill assistance, claiming the tank is "not leaking actively enough" under Service Bulletin SI B01 03 22 (NHTSA ID: MC-10212779-9999). An uncontained raw fuel leak on a plastic fuel tank is a critical safety defect that requires immediate investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle developed a strong, toxic odor of raw gasoline inside the passenger cabin and trunk area. The vehicle was brought to an authorized franchise, BMW of Sterling, where technicians performed a multi-point inspection. The technician confirmed that the factory plastic fuel tank assembly is structurally defective and leaking raw fuel from the top weld seams. The dealer provided an official invoice quoting $4,824.92 to replace the tank due to the fuel leak, noting it is an active hazard, but refused to cover the failure under BMW’s active 15-year/150,000-mile extended warranty for N20 plastic fuel tanks (SI B01 03 22). Driving a vehicle with raw fuel pooling on the exterior of the tank and migrating into the cabin creates an immediate fire hazard and health risk to occupants."

I've gotten my car fixed multiple times and nothing has worked. My car is leaking coolant severely it overheats constantly I get the red and the yellow message. My heater is self stopped working and my car on the freeway has stopped from going 75 to 80 miles dropping all the way to 20 miles.

The contact owns a 2016 BMW 528I. The contact stated that there was an abnormal burning odor coming from the vehicle while at a stop. The contact detected fumes underneath the hood and there was oil on the alternator. The contact stated that the tires were replaced, but the vehicle was not aligned. The contact stated that the driveshaft had dropped and was making an abnormal rubbing sound. The oil light was illuminated. The vehicle was taken to an independent mechanic who determined that the rear differential needed to be replaced. The vehicle was repaired, but the failure recurred. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electricals System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was taken to the local dealer for a routine oil change and the contact was made aware of an oil leak. The vehicle was diagnosed again, and the contact was informed that the rear differential needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 151,198. VIN tool confirms parts not available.

A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or fire." The problem began with dashboard warnings about overheating, despite the coolant reservoir being full. Following these warnings, the vehicle entered "limp mode," posing a significant safety risk in normal traffic. The potential for fire is also a major concern. An independent service center has confirmed the water pump and its electrical connector as the point of failure. The failed component is available for inspection by a NHTSA investigator. I contacted BMW's customer relations line and was informed that no remedy is currently available. I must wait for an official letter before any action can be taken, including reimbursement. The representative did not provide a case number, making it impossible to track my complaint. The vehicle has not been inspected by the manufacturer, law enforcement, or an insurance representative. I am unable to transfer the title because the car cannot pass a safety inspection in its current state. I am in a severe catch-22: I must receive a recall letter for a vehicle that I am unable to finalize ownership of. This failure to assist an owner with a known safety recall has left me stranded with a dangerous, undrivable vehicle.

Very often, when I change the gear to 'Drive' or 'Reverse' I get a message on the dashboard screen - "secure Vehicle against rolling" and the car DOES NOT move unless I shift the auto gear lever several times or sometimes shut off the engine to get back to normal driving. Once when I was in such a situation, no matter what I do, the error message would not go away and I had to call the tow truck to get home. And when tow truck person brought the car home, the problem fixed itself!! I only have 81000 miles on this car. It is a very serious safety issue as far as I am concerned. PLEASE HELP.

I have 2016 BMW 5 series car, for past two to three years headlights are getting condensation inside on colder months. Dealer is not able to fix the condensation, they are advising to replace the headlights. Some of my friends replaced OEM headlights, but after few years they are started condensation, it’s looked like defect from manufacturer, I had few Honda vehicles older than my BMW car, they never had any condensation complaints. It’s look like manufacturer used cheap materials causing condensation, it is causing low light at night times may lead to accidents. Please look at this issue and consider it as a safety issue and please recall these headlights. Dealer is asking $2500 + $500 labor to fix each headlight. All of my friends are having same problem, I bet other BMW car owners too. Please issue a recall on this safety issue.

My driver headlight is constantly getting moisture trapped in it. It’s been replaced twice and the seals were checked, but it keeps happening and shorting out my headlight. It’s $4000 to fix. Just had it replaced 1.5 weeks ago and it’s broken already. I took it to bmw the moment I noticed the moisture was back and they told me it was fine. This is a widespread problem and they are not fixing their product

A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or fire." The problem began with dashboard warnings about overheating, despite the coolant reservoir being full. Following these warnings, the vehicle entered "limp mode," posing a significant safety risk in normal traffic. The potential for fire is also a major concern. An independent service center has confirmed the water pump and its electrical connector as the point of failure. The failed component is available for inspection by a NHTSA investigator. I contacted BMW's customer relations line and was informed that no remedy is currently available. I must wait for an official letter before any action can be taken, including reimbursement. The representative did not provide a case number, making it impossible to track my complaint. The vehicle has not been inspected by the manufacturer, law enforcement, or an insurance representative. I am unable to transfer the title because the car cannot pass a safety inspection in its current state. I am in a severe catch-22: I must receive a recall letter for a vehicle that I am unable to finalize ownership of. This failure to assist an owner with a known safety recall has left me stranded with a dangerous, undrivable vehicle.

Coolant pump failure engine failure also caused fire in engine bay. Insurance inspector. Pre shop inspection. No light were on prior to explosion.

THE CAR HAS A PROBLEM WITH THE CV JOINTS, THIS HAS BEEN A PROBLEM SINCE PURCHASING THE CAR IN 10/19 - IF I TRY TO TURN THE STEERING WHEEL AT TIMES WHILE DRIVING IT WON'T TURN. THE BMW CERTIFIED DEALER STATES IT IS BOTH CV JOINTS AND BMW HAS BEEN RECALLING THEIR VEHICLES SINCE 2013 FOR CV JOINTS

On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.

TAKATA RECALL,, 12-20-2017 I WAS IN A COLLISION. MY VEHICLE REAR ENDED A VEHICLE WHILE TRYING TO STOP. I WAS ALONE IN MY VEHICLE. THE DRIVER SIDE STEERING WHEEL AND KNEE AIRBAGS DEPLOYED. THE PASSENGER FRONT AND REAR SIDE CURTAIN AIRBAGS DEPLOYED. THE DRIVER SIDE FRONT AND REAR SIDE CURTAIN AIRBAGS FAILED TO DEPLOY. BMW UPON MY REQUEST AND COMPLAINTS HAD THE VEHICLE CHECKED MY ONE OF THEIR ENGINEERS. WHO I WAS TOLD SAID THAT THE DRIVER SIDE CURTAIN AIRBAGS SHOULD NOT HAVE DEPLOYED. WHEN I ASKED THEM WHY WOULD THE PASSENGERS IF I WAS ALONE AND WAS TOLD OH THAT'S A SAFETY PRECAUTION DON'T WORRY ABOUT IT.

THE CAR HAS A PROBLEM WITH THE CV JOINTS, THIS HAS BEEN A PROBLEM SINCE PURCHASING THE CAR IN 10/19 - IF I TRY TO TURN THE STEERING WHEEL AT TIMES WHILE DRIVING IT WON'T TURN. THE BMW CERTIFIED DEALER STATES IT IS BOTH CV JOINTS AND BMW HAS BEEN RECALLING THEIR VEHICLES SINCE 2013 FOR CV JOINTS