2005 BMW 530I Owner Complaints

TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED WHILE DRIVING, WHICH WAS A SAFETY CONCERN. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FAILURE AFFECTED THE AIR BAGS, AND THAT THE FLOOR MAT SENSOR WAS FAULTY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND INDICATED THAT AN UNKNOWN RECALL CAMPAIGN WAS AVAILABLE FROM 2009; HOWEVER, THE STATUTE EXPIRED. THE MANUFACTURER PROVIDED NO SOLUTION. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11088681

Incident

Feb 28, 2018

I BOUGHT THIS CAR LAST YEAR WITH 140,000 MILES ON IT. THE PASSENGER SIDE AIRBAG LIGHT AND SEATBELT LIGHT BOTH CAME ON AFTER MAYBE A MONTH OF DRIVING. I TOOK IT TO THE BMW SHOP AND THEY SAID THAT IT CAME ON BECAUSE I HAD SOMETHING HEAVY SITTING IN THE SEAT---NOTHING HEAVIER THAN MY PURSE. THEY WANTED TO CHARGE ME A DIAGNOSIS FEE TO TURN THE LIGHT OFF BUT I REFUSED. THAT IS NOT A CAUTION IN THE HANDBOOK SO HOW WAS I SUPPOSE TO KNOW THAT WAS PROBLEM. I'M WORRIED THAT MY SEATBELT AND AIRBAG MAY MALFUNCTION IN THE CASE OF AN ACCIDENT. I HAD THE SAME PROBLEM WITH MY 2005 BMW 525.

NHTSA ID

10924793

Incident

Jun 26, 2015

Mileage

141,500 mi

TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFUSED ANY REPAIR OR ASSISTANCE.. THE APPROXIMATE FAILURE MILEAGE WAS 134,000. UPDATED 10/19/16*LJ UPDATED 10/24/16/16.*JB

NHTSA ID

10874178

Incident

Jun 10, 2016

Mileage

134,000 mi

MY IDRIVE SHOWED A MESSAGE INDICATING THAT THE AIRBAG IN THE PASSENGER SIDE WAS DEACTIVATED BECAUSE OF A SENSOR OR SIMILAR ISSUE. I TOOK THIS TO THE DEALER, ASKED FOR IT TO BE COVERED UNDER THE PREVIOUS SERVICE BULLETIN WHICH INDICATED THE SEAT MAT SENSOR WAS DEFECTIVE. THE DEALERSHIP INDICATED THEY WOULD NOT FIX IT. I CONTACTED BMW NORTH AMERICA AND THEY SAID THEY MIGHT FIX IT IF I PAID FOR THE ASSESSMENT. THE ASSESSMENT SUGGESTED THERE WAS A DEFECT IN DIFFERENT SENSOR. AND SUGGESTED THAT A BATTERY CABLE SHOULD BE REPLACED. ALL OTHER SYSTEMS IN THE CAR WORKS FINE. BOTH BMW AND THE DEALER REFUSED TO FIX THIS ISSUE. THERE HAVE BEEN NO OTHER REPORTED CASES OF THE BATTERY CABLE ACTUALLY CAUSING THE AIRBAGS TO BE DEACTIVATED. TODAY, THE AIRBAG IS STILL NOT WORKING, AND BMW HAS REFUSED TO FIX THE PROBLEM.

NHTSA ID

10863267

Incident

Jan 18, 2016

Mileage

112,000 mi

TL* THE CONTACT OWNS A 2005 BMW 530I. THE SRS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS DIAGNOSED, BUT NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 192,000.

NHTSA ID

10851626

Incident

Mar 25, 2016

Mileage

192,000 mi

TL* THE CONTACT OWNS A 2005 BMW 530I. THE VEHICLE WAS REPAIRED UNDER AN EXTENDED WARRANTY THROUGH THE MANUFACTURER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THE PASSENGER SIDE AIR BAG WARNING INDICATOR WAS CONSISTENTLY ILLUMINATED. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT WAS FAULTY AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V564000 (AIR BAGS) BECAUSE THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE MANUFACTURER'S EXTENDED WARRANTY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

NHTSA ID

10817010

Incident

Sep 1, 2015

Mileage

170,000 mi

I PURCHASED THE VEHICLE FROM SOMEONE. THE PASSENGER RESTRAINT SYSTEM MALFUNCTION SIGNAL ON COMPUTER HAS COME ON, THE BRAKE PAD MALFUNCTION WARNING HAS ALSO COME ON, ALONG WITH THE LEFT BRAKE LIGHT MALFUNCTION! I HAVE TRIED TO HAVE BMW HONOR THE WARRANTY ON THE PROBLEM WITH THE PASSENGER RESTRAINT, TO NO AVAIL! I HAVE ASKED THE SERVICE ADVISOR SEVERAL TIMES, THEY ARE SAYING I NEEDED TO PAY TO HAVE THIS DONE, ALTHOUGH IT WAS STILL UNDER THE TERMS OF 10 YEAR RULE! THE LIGHT AND BRAKES ARE FINE, HOWEVER I CAN'T FIGURE OUT WHY THE COMPUTER SAYS OTHERWISE, UNLESS THERE ARE SOME UNDETERMINED PROBLEMS. THE BRAKES AND SENSOR HAVE BEEN REPLACED! THE LIGHT IS WORKING PROPERLY, YET THE COMPUTERS READING DIFFERENTLY. I HAVE ASKED ON SEVERAL DIFFERENT OCCASIONS ABOUT THE PASSENGER RESTRAINT, THE FEMALE SALES ADVISOR STATES I HAVE TO PAY FOR THIS!

NHTSA ID

10809672

Incident

Jun 1, 2015

PSS. RESTRAINT SYSTEM SHOWS IN MAIN SCREEN. SEAT BELT SHOWS IN THE FRONT SCREEN. IM CONCER OF ITS ACTUALLY FUNCTIONALITY.

NHTSA ID

10790069

Incident

Nov 8, 2015

Mileage

139,900 mi

I HAVE XENON ADAPTIVE HEADLIGHTS OEM MADE BY HELLA. THE INSULATION ON ALL OF THE WIRING INSIDE THE HEADLIGHT ASSEMBLY IS FALLING OFF. YOU CANNOT TOUCH A WIRE WITHOUT THE INSULATION CRUMBLING OFF THE WIRING. NOW HAVING NUMEROUS FAULTS AND HID LIGHT ON DRIVERS SIDE IS NON FUNCTIONAL DUE TO WIRING SHORTS.

NHTSA ID

10781864

Incident

Jan 1, 2012

Mileage

150,000 mi

THE IDRIVE, KNOWN AS "CCC", UNIT USED TO WORK JUST FINE. IT CONTROL NAVIGATION, RADIO AND VEHICLE'S INFORMATIONS FOR OWNER. ONCE AWHILE THE SCREEN BLINK AND GO BLANK, AND THEN SOMETIME IT WORK JUST FINE. NOW IT JUST DON'T WORK ANYMORE. THE SCREEN NOW BLINK CONTINUOUSLY WHILE DRIVING. THIS IS CAUSING A MAJOR DISTRACTION FOR ME BEHIND THE WHEEL ESPECIALLY AT NIGHT. I STARTED RESEARCHING ONLINE AND NOTICE A LOT OF OWNERS WITH THIS MODEL ALSO HAVE THE SAME PROBLEMS. THEY REPLACED THE CCC UNIT AND UPDATE SOFTWARE INFORMATION AT THE DEALER AND IT FIXED THE ISSUES. I CALLED BMW MOMENTUM OF HOUSTON ABOUT THE CCC. THE COST IS $1,500.00 NOT INCLUDING LABOR. I BELIEVE THIS GRAND DEFECTS IS A MANUFACTURING DEFECTS. CAN YOU PLEASE INVESTIGATE INTO THIS MATTER SO THAT A RECALL CAN BE ISSUE.

NHTSA ID

10778281

Incident

May 1, 2011

Mileage

60,000 mi

DRIVING IN A NEIGHBORHOOD DEVELOPMENT HOME, OUTSIDE TEMPERATURE ABOUT 86 DEGREES, DRY DRIVING CONDITIONS. DRIVER BUMPED INTO A CONCRETE CURB UPON TURNING INTO DRIVEWAY AND TIRE BLEW OUT, TIRE SIDEWALL COMPLETELY SEPARATING FROM TIRE TREAD. TIRES WERE INSTALLED IN APPROXIMATELY JULY 2014 AND INCIDENT OCCURRED IN SEPTEMBER 2015. APPROXIMATELY 12,000 MILES ON THE TIRES. CONTINENTAL EXTREME CONTACT DWS 225/50/R17. DOT NUMBER LM403VR 1313

NHTSA ID

10761402

Incident

Sep 3, 2015

PASSENGER SIDE AIR BAG LIGHT AND SEAT BELT LIGHT ARE ON AGAIN! TOOK TO DEALER COUPLE YEARS AGO DURING RECALL AND IT HAPPEN AGAIN (MAT SENSOR)

NHTSA ID

10725123

Incident

Jun 13, 2015

Mileage

77,070 mi

I HAVE A 05 BMW 530I WITH SPORT PACKAGE AND I GOT AN ERROR WITH THE PASSENGER RESTRAIN SYSTEM MALFUNCTION. IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE. BMW DID NOT WANT TO TAKE CARE OF THIS COMMENT AND RECALL PROBLEM!! *TR

NHTSA ID

10712061

Incident

Apr 15, 2015

Mileage

177,000 mi

WAS TRAVELING ON THE FREEWAY WHEN THE CAR GAS PEDAL BEGAN TO REV UP ON ITS ON AND THEN THE WARNING LIGHT ALERT "TRANS. MALFUNCTION" THE VEHICLE WILL HAVE REDUCED ACCELERATION. HAVE THE SYSTEM CHECKED BY THE NEAREST BMW CENTER. TRANS. FAULT DRIVE MODERATELY, WE PULLED OFF THE FREEWAY AFTER TURNING OFF THE CAR FOR A WHILE I WAS ABLE TO DRIVE BUT THIS CONTINUES TO HAPPENS, I HAVE CHECKED ON WWW.MOTORTREND.COM FOR RECALLS AND EVERYONE THAT IS LISTED ARE PROBLEMS IM HAVING,RECALL # 76534 AIR BAGS FRONTAL LIGHT, RECALL 51587 POWER TRAIN; AUTOMATIC TRANSMISSION, RECALL #93389 ENGINE & ENGINE COOLING: COOLING SYSTEM: FAN, RECALL 71260 SERVICE BRAKES, HYDRAULIC: POWER ASSIST: VACUUM, I'M HAVING TROUBLE WITH MY CAR IN ALL THESE RECALLS, PLEASE HELP. *TR

NHTSA ID

10705674

Incident

Aug 30, 2014

Mileage

190,358 mi

WHILE BMW HAS RECALLED MANY 2005 BMW 530I SEDANS FOR THE AIRBAG CONCERNS, MY VIN IS APPARENTLY NOT INCLUDED IN THIS LIST. I HAVE CONTACTED BMW DIRECTLY, AS WELL AS MANY LOCAL SERVICE DEPARTMENTS, WITH NO AVAIL. BOTH LIGHTS INDICATING SEAT BELT AND AIRBAG MALFUNCTIONS HAVE BEEN ILLUMINATED FOR OVER A YEAR AND I AM VERY CONCERNED THAT IF A CRASH WERE TO OCCUR, THE PASSENGERS IN THE VEHICLE WOULD NOT BE ADEQUATELY PROTECTED. IF THERE ARE AIR BAG ISSUES IN SOME BMW 530I SEDANS, ISN'T IT POSSIBLE THAT OTHERS MAY HAVE THE SAME ISSUE? *TR

NHTSA ID

10703156

Incident

Feb 10, 2014

Mileage

75,000 mi

THE MICRO POWER MODULE IN THE TRUNK WAS BURNT ON MY 2005 530I, NOW MY IDRIVE / AUDIO / NAV AND PDC HAS SHUT DOWN. CAR STARTS AND DRIVES NORMAL, EXCEPT THE PREVIOUSLY MENTIONED ACCESSORIES THAT NO LONGER WORK, WHO KNOW WHAT OTHER DAMAGES (IF ANY) RESULTED FROM A MPM MELTDOWN. I'VE READ SOME HORROR POSTS OF SIMILIAR EVENTS THAT CAUSED EVERYTHING ON THE VEHICLE TO SHORT OUT, WHICH MEANT THAT BASICALLY EVERYTHING CCC / M-ASK / TV MODULE / CD ETC. WHEN THIS HAPPENED ON MY VEHICLE, THE CAR WAS ACTUALLY SWITCHED OFF. IT WAS ONLY WHEN I GOT BACK TO THE CAR THE NEXT MORNING WHEN I GOT THIS STRONG ELECTRICAL BURN SMELL FROM THE TRUNK AREA. THE MPM PROBABLY SHORTED OUT DURING THE COURSE OF THE NIGHT. LUCKILY THE CAR DID NOT CAUGHT ON FIRE, CAUSE IT COULD HAVE THEN BURNED DOWN MY APARTMENTS AS WELL, AS THE CAR WAS PARKED NEXT TO MY APARTMENT. FROM WHAT I COULD VISUALLY ACCESS, ONLY THE MPM UNIT BURNED OUT COMPLETELY AND MELTED. I JUST HOPE THAT I KNOCKED THE MPM OUT BEFORE IT COULD CAUSE ANY MORE DAMAGE TO THE CAR'S OTHER ELECTRONICS. MY CAR IS UNFORTUNATELY NO LONGER UNDER WARRANTY. THE CAR HAS ALREADY BEEN TAKEN INTO MY LOCAL DEALERSHIP TO ACCESS THE DAMAGE AND TO GIVE ME A QUOTE TO REPAIR, BUT THEY DID INFORM ME THAT IT IS GOING TO BE A COSTLY AFFAIR. I FIND IT VERY INTERESTING THAT BMW DECIDED TO MOVE THESE MODULES NEWER MODELS FROM THE TRUNK AREA TO THE BODY GATEWAY MODULE WHICH IS A MUCH SAFER ENVIRONMENT. MAKES YOU THINK THAT THEY REALIZED THAT THERE WAS A DEFECT WITH THE VEHICLE IN PLACING THEM THERE IN THE FIRST PLACE. DON'T KNOW IF IT'S SAFE TO DRIVE ON THE ROAD DO TO THE DANGER OF ELECTRICAL FIRE. I ALSO HAVE PICTURES AVAILABLE. *TR

NHTSA ID

10694999

Incident

Mar 12, 2015

Mileage

160,000 mi

I PURCHASED MY VEHICLE FROM A DEALER ON APRIL 2014. APPROXIMATELY A MONTH LATER, THE PASSENGER FRONTAL AIRBAG AUTOMATICALLY DISABLED AND THE LIGHT ILLUMINATED ON THE DASHBOARD. THE FRONTAL PASSENGER SEATBELT ALSO DISABLED AND THE LIGHT ILLUMINATED ON THE DASHBOARD. THE BRAKE LIGHT IS ALSO ILLUMINATED. IN JUNE 2014, MY CAR WAS HIT BY A F150 TRUCK. THE IMPACT WAS SO FORCEFUL, MY CAR WAS KNOCKED ON THE OTHER SIDE OF THE STREET. NON OF THE AIRBAGS DEPLOYED AND THERE WERE INJURIES TO THE DRIVER. MY VEHICLE WAS REPAIRED AND I WAS INFORMED BY THE MECHANIC THAT THE LIGHTS ILLUMINATED ON MY DASHBOARD WERE RECALLS AND A KNOWN SAFETY ISSUE WITH MY VEHICLE'S MAKE AND MODEL. I RESEARCHED THE INFORMATION AND DID FIND RECALLS FOR THE FRONTAL AIRBAG AND FRONTAL SEATBELT. I CONTACTED A BMW DEALERSHIP A COUPLE OF TIMES AND I AM TOLD MY VIN DOES NOT SHOW ANY OPEN RECALLS AND THE REPAIRS WILL BE OUT OF POCKET. THESE PROBLEMS APPEARS TO BE DEFECTS WITH THE VEHICLE AND A DEFINITE SAFETY ISSUE. *JS

NHTSA ID

10690322

Incident

May 14, 2014

Mileage

102,000 mi

THE INSULATION INSIDE THE HEADLIGHT HAS COMPLETELY CRACKED AND FLAKED OFF, LEAVING BARE WIRES EXPOSED THAT CAN SHORT OUT AND PRESENT A FIRE RISK. *TR

NHTSA ID

10664118

Incident

Aug 1, 2014

Mileage

102,000 mi

PASSENGER SIDE AIR BAG FAILURE MESSAGE. *TR

NHTSA ID

10644100

Incident

Oct 1, 2014

THIS HAS BEEN HAPPENING TO OTHER 2005 BMW 530I OWNERS. WHILE BRAKING VEHICLE IDRIVE GAVE WARNING THAT REAR DRIVER SIDE BRAKE LIGHT FAILED AND THEN THAT THE REAR LIGHT HAD A MALFUNCTION. UPON LOOKING AT THE WIRING HARNESS ATTACHED TO THE TAILLIGHT BULB CARRIER, THE BROWN WIRE IS BURNT OUTSIDE OF THE HARNESS. THE RUBBER COATING OF THE WIRE IS BURNT THROUGH AND THE WIRE IS EXPOSED. THE PLASTIC WIRE HARNESS IS BURNT AND MELTED. THE TAILLIGHT BULB CARRIER IS ALSO BURNT AND MELTED. EXACTLY WHAT HAS HAPPENED TO MY CAR. THE GROUND WIRE HAS WAY TOO MUCH CURRENT ON IT RESULTING IN MELTING AND POSSIBLE FIRE. *TR

NHTSA ID

10643202

Incident

Aug 1, 2014

Mileage

107,000 mi

TL* THE CONTACT OWNS A 2005 BMW 530I. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE PASSENGER SEAT AIR BAG SENSOR MAT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 08V384000 (FRONT PASSENGER SEAT OCCUPANT DETECTION MAT). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 71,000. UPDATED 8/27/14*CN UPDATED 09/8/2014 *JS

NHTSA ID

10597875

Incident

Jul 1, 2012

Mileage

50,000 mi

FRONT PASSENGER SEAT OCCUPANT MAT IS MALFUNCTIONING IN MY 2005 BMW 530I. THERE WAS A RECALL IN ACTION NUMBER EA08001 IN WHICH BMW AGREED TO EXTEND THE WARRANTY OR COMPLETE THE REPAIR OF THE PROBLEM. WHEN I WENT TO THE BMW SERVICE FACILITY, THEY WOULD ONLY FIX THE ISSUE IF I PAID. I CALLED BMW USA AND THEY TOLD ME THAT MY SPECIFIC VIN NUMBER IS NOT INCLUDED IN THE REPAIR/EXTENDED WARRANTY. EVEN THOUGH MY VEHICLE IS EXPERIENCING THE PROBLEM, THEY TELL ME MY VIN IS NOT INCLUDED. THEREFORE, MY PASSENGER SEAT AIRBAGS DO NOT WORK. I REPORTED THIS PROBLEM ORIGINALLY IN 2012 TO BMW. *TR

NHTSA ID

10597872

Incident

Aug 14, 2012

Mileage

51,051 mi

TL* THE CONTACT OWNS A 2005 BMW 530I. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A LOUD NOISE NEAR THE FRONT DRIVER'S SIDE WHEEL. THE DEALER COULD NOT DUPLICATE THE FAILURE AND DID NOT STATE IF THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 10V446000 (SERVICE BRAKES, HYDRAULIC). THE CONTACT WAS UNABLE TO STOP THE VEHICLE IN TIME WHEN ANOTHER VEHICLE SUDDENLY MANEUVERED IN HER LANE, WHICH LED TO THE CONTACT CRASHING INTO THE REAR OF THE SECOND VEHICLE. AS A RESULT, THE CONTACT SUSTAINED BURNS TO THE SKIN DUE TO THE CONTENTS THAT WERE RELEASED UPON AIR BAG DEPLOYMENT. TWO PASSENGERS WERE ALSO INJURED. A POLICE REPORT WAS FILED AND MEDICAL ATTENTION WAS RECEIVED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

NHTSA ID

10597054

Incident

Apr 30, 2014

Mileage

145,000 mi

I'VE GOT AN ALERT ON THE DASHBOARD (PASSENGER RESTRAIN SYSTEM MALFUNCTION). I'VE HEARD THAT IS A RECALL FOR THIS MALFUNCTIONS. I WANT TO CHECK WITH YOU IF MY CAR IS ABLE FOR THAT. THANKS *TR

NHTSA ID

10567962

Incident

Mar 8, 2014

Mileage

106,240 mi

I HAVE LEFT MY CAR AT THE AIRPORT FOR A 2 DAY BUSINESS TRIP. WHEN I DROVE BACK FROM THE AIRPORT, WHILE ON THE HIGHWAY, I SAW A BIG PLUME OF SMOKE COMING FROM THE BACK OF MY CAR. THE ENGINE KIND OF HESITATED BUT DIDN'T' STALL. I WAS ABLE TO DRIVE TO A SAFE PLACE AND CHECK THE OIL DIPSTICK. THERE WAS NO OIL LEFT IN THE OIL COMPARTMENT. WHEN THE ENGINE COOLED DOWN I SAW BLACK LIQUID DRIPPING OFF THE EXHAUST PIPE. THE CAR SMELLED LIKE BURNT OIL. I SPOKE TO THE DEALERSHIP THAT SERVICES MY CAR AND THEY TOLD ME TO TOW IT TO AVOID ANY FURTHER DAMAGE. THE DEALERSHIP IDENTIFIED THE PROBLEM AS A FROZEN OIL SEPARATOR THAT CREATED A VACUUM LOCK AND PUSHED THE OIL TO BURN THRU THE ENGINE AND THE EXHAUST SYSTEM. FROM FURTHER DISCUSSION WITH THE DEALERSHIP SERVICE ADVISOR AND LOOKING INTO BMW POSTING FORUMS I REALIZED THAT THIS IS AN ISSUE THAT HAS BEEN HAPPENING FOR A WHILE NOW WITH BMWS IN COLD WEATHER CONDITIONS. I ALSO FOUND OUT THAT BMW HAS RELEASED IN FEB 2009 A SERVICE INFORMATION BULLETIN SIB 11 08 03 THAT RECOGNIZED, THAT THE DEFECTIVE PART MAY FAIL IN COLD WEATHER CONDITIONS, AND RECOMMENDED TO BMW SERVICE DEPTS REPLACEMENT WITH A NEW BETTER DESIGNED PART. HOWEVER, BMW DID NOT TAKE THE STEP TO NOTIFY CUSTOMERS WHO HAVE BEEN OR COULD BE AFFECTED BY THIS DEFECT. IF I KNEW ABOUT THIS ISSUE IN FEB 2009, WHEN MY CAR WAS UNDER THE NEW VEHICLE WARRANTY, I WOULD HAVE REPLACED IT AT NO COST AND THE ENGINE AND EXHAUST WOULD NOT HAVE GONE THRU THIS NEARLY DESTRUCTIVE INCIDENT. I NOW HAD TO INCUR THIS $1300 REPAIR COST AND I DON'T KNOW WHAT ELSE COULD MECHANICALLY INCUR WITH THIS CAR IN THE FUTURE DUE TO THIS MALFUNCTION.THE RESALE VALUE OF THE CAR HAS ALSO GONE DOWN AS WELL. I FEEL BMW HAS ACTED IRRESPONSIBLY, IF NOT CRIMINALLY, TO NOT NOTIFY AFFECTED CUSTOMERS ABOUT THIS DEFECT. IT COULD HAVE BEEN MUCH WORSE DRIVING IN THE INTERSTATE AND HAVING A STALLED ENGINE AT 60 MILES AN HOUR. *TR

NHTSA ID

10565394

Incident

Feb 12, 2014

Mileage

78,850 mi