2002 BMW 530IA Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 BMW 530IA, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags240.0%
- Powertrain (other)240.0%
- Driver assistance120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
TL* TAKATA RECALL. THE CONTACT OWNS A 2002 BMW 530IA. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2002 BMW 530IA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
ON MAY 28TH 2012 ON THE HIGHWAY, THE BMW THREW A SERVICE ENGINE SOON LIGHT. USING A SCANNER, A CODE P0741 WAS THROWN. WHEN I SEARCHED ON GOOGLE, I FOUND IT WAS VERY COMMON FOR THE E39 BMW 530IA CARS HOUSING ZF MANUFACTURED TRANSMISSIONS TO HAVE THE TORQUE CONVERTER TURBINE SHAFT SEAL DETERIORATED CAUSING THE FAULT. IT IS UNREASONABLE TO HAVE BMW TO REPLACE THE TRANSMISSION AT A COST OF OVER $4000 FOR A SEAL THAT IS NO MORE THAN $25.00. THEREFORE IT SHOULD BE A GOODWILL REPLACEMENT DUE TO THE MANUFACTURE OF A FAULTY TRANSMISSION WITH A KNOWN PART FAILURE IN THE FIRST PLACE. *TR
AT 104,700 MILES THE SERVICE ENGINE SOON LIGHT ILLUMINATED. DIAGNOSIS WAS P0741 (BMW CODE 48) WHICH IS A FAULT WITH THE TORQUE CONVERTER CLUTCH (TCC). THIS FAILURE, UNTIL CORRECTED, RESULTS IN LOWER FUEL MILEAGE AND A GUARANTEED FAILURE TO PASS AN EMISSIONS TEST DURING STATE MANDATED VEHICLE INSPECTIONS. CONTINUED USE OF THE VEHICLE WILL LIKELY RESULT IN TRANSMISSION DAMAGE SINCE THE TCC LOCKUP CLUTCH IS SLIPPING, RESULTING IN DEBRIS BUILDING UP IN THE FLUID. THIS FAULT IS DUE TO A DEFECTIVE TORQUE CONVERTER CLUTCH SEAL THAT BMW HAS A HIDDEN SERVICE BULLETIN ON. SEE SI 24 03 06 DATED FEBRUARY 2008. NUMEROUS POSTINGS ON BMW FORUMS INDICATE THAT THIS ISSUE IS WIDESPREAD WITH A LARGE NUMBER OF FAILURES TAKING PLACE. THERE IS NO DOCUMENTED EVIDENCE THAT THE SEAL IN QUESTION HAS BEEN UPDATED, MEANING FAILURE OF THE SEAL WILL LIKELY HAPPEN AGAIN DURING THE (EXPECTED) LIFE OF THE CAR. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
TWO FAILURES OF FUEL THROTTLE ON SAME VEHICLE: ONE NEW AND ONE REPLACEMENT: DANGER TO LIFE!!! DT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .