RoadVitals

1991 BMW 535I Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
5
Latest Mar 22, 2001
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
4
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1991 BMW 535I, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Engine240.0%
  • Airbags120.0%
  • Electrical120.0%
  • Transmission120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

2
reports

From owner reports, verbatim

CONSUMER HAD REPLACED MOST OF ENGINE COOLING SYSTEM PARTS. EACH TIME THAT TAKES VEHICLE TO DEALER THEY WILL REPLACE A PART, AND PRESENTLY, VEHICLE NEEDS TO BE FIXED AGAIN.*AK

NHTSA ID 883871 · filed Mar 22, 2001

WHILE DRIVING ABOUT 55 MPH VEHICLE STALLED WITHOUT PRIOR WARNING. CONSUMER HAD TAKEN VEHICLE TO DEALER A FEW TIMES FOR THE SAME PROBLEM. BUT PROBLEM IS STILL THERE. *AK

NHTSA ID 860989 · filed Apr 26, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Airbags

Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.

1
report

From owner reports, verbatim

AIRBAG WARNING LIGHT CAME ON BECAUSE OF A WIRE BURNING OUT. DEALER SAYS IT NEEDED TO BE REPLACED. SHORTLY AFTER WIRE WAS REPLACED, THE WARNING LIGHT CAME BACK ON. DEALER SAID IT WAS THE CONTACT RING LOCKING TAB. *AK

NHTSA ID 845187 · filed Aug 17, 1999

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

FAULTY IGNITION SWITCH CAUSED THE STARTER TO BURN UP, RESULTING IN THE VEHICLE LOOSING ALL POWER WHILE DRIVING ON THE HIGHWAY. NLM

NHTSA ID 784630 · filed May 16, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Transmission

Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.

1
report

From owner reports, verbatim

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID 717380 · filed Jan 15, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .