2009 BMW 535I Problems

The contact owns a 2009 BMW 535I. The contact stated that while driving at an undisclosed speed, the vehicle vibrated violently with a message displayed to, "Check Engine – Engine Power Reduced”. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with the spark plugs and ignition coil. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who diagnosed failures with the valve cover gasket and upper radiator hose. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who diagnosed failures with the evaporative leak detection assembly, water pump, and high-pressure fuel pump. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but did not assist. The failure mileage was 70,000.

The car stop running completly when I was wainting at the stop light An anounsmemt came out in my dash saying that I have to repleaced the fuel pump I know that there was a recall abuot this problem but I never got any notice or letter from bmw

The contact owns a 2009 BMW 535I. The contact stated that while driving at an undisclosed speed, the vehicle vibrated violently with a message displayed to, "Check Engine – Engine Power Reduced”. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with the spark plugs and ignition coil. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who diagnosed failures with the valve cover gasket and upper radiator hose. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who diagnosed failures with the evaporative leak detection assembly, water pump, and high-pressure fuel pump. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but did not assist. The failure mileage was 70,000.

While driving I have received engine malfunction and steering becomes hard and unsafe. Have had the engine belt shred to pieces and case major issues. Same repair has been completed multiple times. Great vehicle becoming unsafe to have on the road. What component or system failed or malfunctioned, and is it available for inspection upon request? Engine Malfunction, Battery Malfunction and Yes. How was your safety or the safety of others put at risk? This put my safety at risk because I was on the expressway and the steering was hard to turn or direct. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No there were not any other messages or symptoms of the problem prior to the failure. When the light came on, I pulled over in a safe place. This has happened the first time on August 20, 2019; 2nd time November 9, 2019; 3rd time March 22, 2020; 4th time January 20, 2021; 5th time June 6, 2022. This is too costly for BMW certified parts to continue to occur. As reputable as the product is and with certified technicians, there should be a recall on the continuous leaks and belt shredding causing major issues to the vehicle. 17-22-2-245-358 - (2) O-Ring 83-19-2-451-316 - BMW Non-Chlor. Brak 11-28-7-628-653 - Ribbed V-Belt. 11-42-7-573-212 - Thermostat Housing 11-42-8-637-820 - Gasket 17-22-2-245-358 – (2) O-Ring 83-19-2-451-316 - BMW Non-Chlor. Brak 11-42-7-525-334 - Oil Filter Cover 11-42-7-573-212 - Thermostat Housing 11-42-8-637-820 - Gasket 17-22-2-245-358 – (2) O-Ring 83-19-2-451-316 - BMW Non-Chlor. Brak 11-42-7-525-334 - Oil Filter Cover

I believe using the manual shift mode for normal usage of optimal shifting in certain driving situations and gentle downshifting caused a malfunction in the functionality of the transmission that led to a complete transmission failure. I don’t believe it’s a mechanical issue or result of misuse. There were no warning signs. Only that every time the manual shift option was used, it would cause an error to occur that caused an automatic shifting issue that would reset if the vehicle was shut down and restarted.

DRIVING ON FREEWAY 65 MPH AND VEHICLE LOOSES POWER COMPLETELY POWER STEERING POWER BRAKES LOST. ENGINE JUST SHUT OFF ERRORS APPEAR SUCH AS P142E OR MALFUNCTION HOWEVER WHEN RESTARTING VEHICLE 5+MIN LATER NO ERRORS AND CODES APPEAR RESULTING IN NO FAILURES NO POSSIBILTY TO DIAGNOSE FOUND 4 INCIDENTS OCCURED 2 NEAR FATAL COLLISIONS NOTE: BMW CODE LIST HAS NO RECOMMENDATION FOR RESOLVING ONLY THAT P142E IS SHUTDOWN OF ENGINE THIS CODING OF ECU ALLOWED BY BMW IS DANGEROUS TO HUMAN LIVES

The contact owns a 2009 BMW 535i. The contact stated that upon taking the vehicle to an independent mechanic for servicing, he was informed that the vehicle was leaking oil. The oil filter housing and the valve cover gaskets were replaced. Additionally, the contact stated while driving at various speeds, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the spark plugs and the coil pack needed to be replaced. The contact stated that the vehicle was repaired; however, the failure persisted. The vehicle was taken back to an independent mechanic who diagnosed that the coil pack needed to be replaced. Additionally, the contact stated that the turn signals and the horn were no longer operatives. The independent mechanic diagnosed that the steering column had failed. The contact also stated that the rear passenger's side and the rear driver's side windows were no longer operating as needed. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 115,600. The consumer stated there is a recall for this vehicle.

Passenger side safety restraint malfunction. Passenger airbag no longer enabled because seat occupancy sensor is faulty. Passenger is at risk as airbag no longer working. This problem was confirmed and diagnosed by an independent auto technician. BMW fault code 93c3 The vehicle has not been inspected by the manufacturer as BMW wants $2,500 to make the repair. Warning lights on dash say Passenger Restraint System malfunction. Passenger Airbag no longer enabled. Issues started occurring two weeks ago.

The contact owns a 2009 BMW 535I equipped with Mastercraft Tires, Tire Line: Stratus, Tire Size: 225/50/R17. The contact stated while driving at undisclosed speeds, the passenger's side rear tire was bubbling, and the vehicle was unstable. The vehicle was pulled to the side of the road and the contact observed that the tread belt was broken. The tire was not the original equipment. The vehicle was taken to an independent mechanic where the rear tires were replaced. The tires were replaced with the same tire brand and tire line however, the failure recurred with the driver's side rear tire. The tire was replaced with the same tire brand and tire line. The contact discovered NHTSA Campaign Number: 19T024000 (Tires), however, the DOT number was not included. The manufacturer was not made aware of the failure. The vehicle failure mileage was 177,259. The tire failure mileage was unknown.

THIS IS AN ENFORCEMENT COMPLIANCE REQUEST ON A WEEKLY CONTINUUM FOR THE SAFETY OF THE PUBLIC ON THE FOLLOWING : TIRES: GOODYEAR AND MICHELIN , ALL TYPES, TREADS, SIZES, HEIGHTS, WIDTHS. AUTOS: MERCEDES BENZ, BMW, CADILLAC, FERRARI, BUGATTI, ALFA ROMERO, ROLLS ROYCE, BENTLY, LAMBROGHINI, LINCOLN. PLEASE ASSIST WITH ALL PARTS INSPECTIONS, ANALYSIS FOR INTEGRITY, SAFETY, MAINTENANCE - UPKEEP. PLEASE ASSIST TO NOTIFY THE PROPER AUTHORITIES ON THESE FINDING, IF APPLICABLE. PLEASE BEGIN INSPECTIONS FROM ALL 1990 MODELS, MAKES, TO THE PRESENT 2009 YEAR'S PARTS, AUTOMOTIVES. *TR

FUEL PUMP FAILURES, CAR SHUT DOWN WHILE DRIVING ON THE HIGHWAY (NUMEROUS TIMES) LOST POWER STEERING WHILE GOING OVER 60 MPH. COST OVER $10,000 TO MAKE REPAIRS ON THE VEHICLE BECAUSE BMW SAID IT IS NO LONGER UNDER WARRANTY.

FUEL PUMP ERROR WHILE DRIVING AND THE CAR SHUTS DOWN, WE LOSE POWER STEERING AND HAVE DONE SO ON THE HIGHWAY, AND CITY NUMEROUS TIMES.

The contact owns a 2009 BMW 535i. The contact stated that upon taking the vehicle to an independent mechanic for servicing, he was informed that the vehicle was leaking oil. The oil filter housing and the valve cover gaskets were replaced. Additionally, the contact stated while driving at various speeds, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the spark plugs and the coil pack needed to be replaced. The contact stated that the vehicle was repaired; however, the failure persisted. The vehicle was taken back to an independent mechanic who diagnosed that the coil pack needed to be replaced. Additionally, the contact stated that the turn signals and the horn were no longer operatives. The independent mechanic diagnosed that the steering column had failed. The contact also stated that the rear passenger's side and the rear driver's side windows were no longer operating as needed. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 115,600. The consumer stated there is a recall for this vehicle.

WITHIN 15 MIN OF ARRIVING HOME IN SAID VEHICLE, WIFE STARTED CAR IN DRIVEWAY TO GO SHOPPING. IMMEDIATELY, DENSE BLACK SMOKE BEGAN POURING FROM UNDER THE DASH. SHE TURNED THE CAR OFF, BUT LEFT KEY FOB IN COLUMN. SHE SUMMONED ME FROM INSIDE OUR HOUSE AND WHEN I ARRIVED THE SMOKE WAS STILL POURING OUT FROM UNDER CENTER TO DRIVER SIDE OF DASH. I REMOVED THE KEY FOB FROM COLUMN AND APPROX. 1 TO 2 MIN LATER THE SMOKE STOPPED - WAS GOING TO DISCONNECT THE BATTERY, BUT SMOKE STOPPED BEFORE I WAS ABLE TO OPEN GARAGE AND GATHER TOOLS. NO FLAMES WERE EVER SEEN AND ABSOLUTELY NO SMOKE FROM UNDER HOOD AREA - ALL INSIDE CAR. MANY WARNING LIGHTS ARE NOW ILLUMINATED - AWD SYS, DSC, ABS, 4X4, LIGHTING SYS (CHECK DISPLAYS, TURN SIGNALS, HIGH BEAMS, HEADLAMP FLASHER AND FOG LAMPS). NONE OF THE EXTERIOR LIGHTS SEEM TO FUNCTION. THIS ALL OCCURRED WITHOUT WARNING AND FORTUNATELY HAPPENED WHILE STOPPED IN THE DRIVEWAY. CHECKED RECALL LOG ON NHTSA FOR VIN AND FOUND "0" RECALLS. THE VEHICLE ALSO INCLUDES "X-DRIVE" (ALL WHEEL DRIVE SYSTEM).

WITHIN 15 MIN OF ARRIVING HOME IN SAID VEHICLE, WIFE STARTED CAR IN DRIVEWAY TO GO SHOPPING. IMMEDIATELY, DENSE BLACK SMOKE BEGAN POURING FROM UNDER THE DASH. SHE TURNED THE CAR OFF, BUT LEFT KEY FOB IN COLUMN. SHE SUMMONED ME FROM INSIDE OUR HOUSE AND WHEN I ARRIVED THE SMOKE WAS STILL POURING OUT FROM UNDER CENTER TO DRIVER SIDE OF DASH. I REMOVED THE KEY FOB FROM COLUMN AND APPROX. 1 TO 2 MIN LATER THE SMOKE STOPPED - WAS GOING TO DISCONNECT THE BATTERY, BUT SMOKE STOPPED BEFORE I WAS ABLE TO OPEN GARAGE AND GATHER TOOLS. NO FLAMES WERE EVER SEEN AND ABSOLUTELY NO SMOKE FROM UNDER HOOD AREA - ALL INSIDE CAR. MANY WARNING LIGHTS ARE NOW ILLUMINATED - AWD SYS, DSC, ABS, 4X4, LIGHTING SYS (CHECK DISPLAYS, TURN SIGNALS, HIGH BEAMS, HEADLAMP FLASHER AND FOG LAMPS). NONE OF THE EXTERIOR LIGHTS SEEM TO FUNCTION. THIS ALL OCCURRED WITHOUT WARNING AND FORTUNATELY HAPPENED WHILE STOPPED IN THE DRIVEWAY. CHECKED RECALL LOG ON NHTSA FOR VIN AND FOUND "0" RECALLS. THE VEHICLE ALSO INCLUDES "X-DRIVE" (ALL WHEEL DRIVE SYSTEM).

TL* THE CONTACT OWNS A 2009 BMW 535I. THE CONTACT STATED THAT THE REAR DRIVER'S SIDE TAIL LIGHT FAILED. THE VEHICLE WAS NOT TAKEN FOR INSPECTION AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT LISTED UNDER NHTSA CAMPAIGN NUMBER: 13V407000 (EXTERIOR LIGHTING). THE APPROXIMATE FAILURE MILEAGE WAS 68000.

FUEL PUMP FAILURES, CAR SHUT DOWN WHILE DRIVING ON THE HIGHWAY (NUMEROUS TIMES) LOST POWER STEERING WHILE GOING OVER 60 MPH. COST OVER $10,000 TO MAKE REPAIRS ON THE VEHICLE BECAUSE BMW SAID IT IS NO LONGER UNDER WARRANTY.

THIS IS AN ENFORCEMENT COMPLIANCE REQUEST ON A WEEKLY CONTINUUM FOR THE SAFETY OF THE PUBLIC ON THE FOLLOWING : TIRES: GOODYEAR AND MICHELIN , ALL TYPES, TREADS, SIZES, HEIGHTS, WIDTHS. AUTOS: MERCEDES BENZ, BMW, CADILLAC, FERRARI, BUGATTI, ALFA ROMERO, ROLLS ROYCE, BENTLY, LAMBROGHINI, LINCOLN. PLEASE ASSIST WITH ALL PARTS INSPECTIONS, ANALYSIS FOR INTEGRITY, SAFETY, MAINTENANCE - UPKEEP. PLEASE ASSIST TO NOTIFY THE PROPER AUTHORITIES ON THESE FINDING, IF APPLICABLE. PLEASE BEGIN INSPECTIONS FROM ALL 1990 MODELS, MAKES, TO THE PRESENT 2009 YEAR'S PARTS, AUTOMOTIVES. *TR

BMW 2009 535 XI OWNER. OUT OF ALL OF THE TIMES TAKING THE CAR FOR SERVICE FOR VARIOUS REASONS, I DECIDED TO LOOK FOR INFORMATION REGARDING MY LATEST ISSUE. TWIN TURBO. I WAS TOLD THE REAR TURBO WAS BAD AND IT IS RECOMMENDED TO DO BOTH. I HAD THE CAR SERVICED IN OCTOBER, THEY TOLD ME THE OIL SMELL WAS DUE TO THE SPRING FROM OIL CAP MISSING. BEFORE OCT 2019 I COMPLAINED ABOUT THE OIL SMELL AND WAS TOLD IT WAS A LEAK FROM A HOSE (I NEVER SAW ANY FLUIDS ON GROUND) THIS LAST INCIDENT, I WAS ON THE ROAD WHEN I EXITED THE HIGHWAY I GOT AN ENGINE WARNING TO SHUT OFF THE ENGINE IMMEDIATELY. OIL WAS LOW. I TOOK IT BACK TO BMW AND I WAS TOLD THE REAR TURBO WAS BAD. THEY NOW WANT $6,900. I READ IN A FEW POSTS THAT THE TWIN TURBO ISSUE WAS EXT. TO 10 YEARS OR 120,000 MILES. MY CAR WAS FIRST PURCHASE IN MAY 2009. I AM ASSUMING I AM OUT OF TIME. I WAS NEVER NOTIFIED OF A RECALL. MY VIN NUMBER DOES NOT COME UP WITH ANY RECALLS, EVEN THOUGH MOST OF THE ISSUES ARE THE SAME AS OTHER 2009 BMW OWNERS. MY CAR DOES NOT HAVE 120,000 MILES YET. I TOOK THE CAR TO BMW FOR VANOS SOLENOIDS IN OCT 2019. AND ANOTHER TIME IN OCT BECAUSE THE CAR OVER HEATED SUDDENLY IN LESS THAN HALF A MILE. IT WAS THE FAN. RECENTLY I LEARNED THAT SOME OF THE 2009 BMW 535 HAD A RECALL BUT I NEVER RECEIVED ANYTHING. I QUESTIONED THE DEALER BUT HE SAID HE HAD NOTHING ON FILE. FURTHER READING I FOUND OUT THAT THE COMPANY I BELIEVED CALLED VANOS WAS DOING THE RECALLS. IN OCTOBER 2019 I SPENT ABOUT $3,000 IN REPAIRS. I NOW BELIEVE I COULD HAVE BEEN COVERED BY A RECALL OR EXT. WARRANTY. OVERALL ON DIFFERENT ISSUES I THINK I HAVE SPENT OVER $13,000 IN REPAIRS (INCLUDING TRANSFER CASE AND DIFFERENTIAL THAT THE WARRANTY DID NOT PAY BECAUSE THE CAR DID NOT HAVE SPECIFIED 17' TIRES: BUT I BOUGHT WITH STAGGERED 18' TIRES). I STILL OWE APPROXIMATELY $7,500 TO THE BANK. I TAKE IT TO BE SERVICED ALL THE TIME, SO I'M BAFFLED.

THIS IS AN ENFORCEMENT COMPLIANCE REQUEST ON A WEEKLY CONTINUUM FOR THE SAFETY OF THE PUBLIC ON THE FOLLOWING : TIRES: GOODYEAR AND MICHELIN , ALL TYPES, TREADS, SIZES, HEIGHTS, WIDTHS. AUTOS: MERCEDES BENZ, BMW, CADILLAC, FERRARI, BUGATTI, ALFA ROMERO, ROLLS ROYCE, BENTLY, LAMBROGHINI, LINCOLN. PLEASE ASSIST WITH ALL PARTS INSPECTIONS, ANALYSIS FOR INTEGRITY, SAFETY, MAINTENANCE - UPKEEP. PLEASE ASSIST TO NOTIFY THE PROPER AUTHORITIES ON THESE FINDING, IF APPLICABLE. PLEASE BEGIN INSPECTIONS FROM ALL 1990 MODELS, MAKES, TO THE PRESENT 2009 YEAR'S PARTS, AUTOMOTIVES. *TR

SEEMS TO BE A COMMON PROBLEM WHERE LIGHT KEEPS COMING IN...NOT SURE IF AIRBAG OR SEAT BELT RESTRAINTS WILL HELP IN AN ACCIDENT

I GOT A PASSENGER RESTRAINT SYSTEM MALFUNCTION: FAULT IN PASSENGER-RESTRAINT SYSTEM AFFECTING AIRBAG, BELT TENSIONER OR BELT-FORCE LIMITER RESTRAINT PROBLEM. THIS RESULTED IN A RED AIRBAG LIGHT AND RED PASSENGER BELT TO COME ON THE DASH AND IDRIVE. THE PASSENGER RESTRAINT SYSTEM AND BELT TENSIONER IS SAID TO BE BAD . THIS TIME WITH A RED AIRBAG LIGHT ON ALL THE TIME, AND THE SEAT BELT UNBUCKLED LIGHT ON AS WELL. *TR

THIS IS AN ENFORCEMENT COMPLIANCE REQUEST ON A WEEKLY CONTINUUM FOR THE SAFETY OF THE PUBLIC ON THE FOLLOWING : TIRES: GOODYEAR AND MICHELIN , ALL TYPES, TREADS, SIZES, HEIGHTS, WIDTHS. AUTOS: MERCEDES BENZ, BMW, CADILLAC, FERRARI, BUGATTI, ALFA ROMERO, ROLLS ROYCE, BENTLY, LAMBROGHINI, LINCOLN. PLEASE ASSIST WITH ALL PARTS INSPECTIONS, ANALYSIS FOR INTEGRITY, SAFETY, MAINTENANCE - UPKEEP. PLEASE ASSIST TO NOTIFY THE PROPER AUTHORITIES ON THESE FINDING, IF APPLICABLE. PLEASE BEGIN INSPECTIONS FROM ALL 1990 MODELS, MAKES, TO THE PRESENT 2009 YEAR'S PARTS, AUTOMOTIVES. *TR

WITHIN 15 MIN OF ARRIVING HOME IN SAID VEHICLE, WIFE STARTED CAR IN DRIVEWAY TO GO SHOPPING. IMMEDIATELY, DENSE BLACK SMOKE BEGAN POURING FROM UNDER THE DASH. SHE TURNED THE CAR OFF, BUT LEFT KEY FOB IN COLUMN. SHE SUMMONED ME FROM INSIDE OUR HOUSE AND WHEN I ARRIVED THE SMOKE WAS STILL POURING OUT FROM UNDER CENTER TO DRIVER SIDE OF DASH. I REMOVED THE KEY FOB FROM COLUMN AND APPROX. 1 TO 2 MIN LATER THE SMOKE STOPPED - WAS GOING TO DISCONNECT THE BATTERY, BUT SMOKE STOPPED BEFORE I WAS ABLE TO OPEN GARAGE AND GATHER TOOLS. NO FLAMES WERE EVER SEEN AND ABSOLUTELY NO SMOKE FROM UNDER HOOD AREA - ALL INSIDE CAR. MANY WARNING LIGHTS ARE NOW ILLUMINATED - AWD SYS, DSC, ABS, 4X4, LIGHTING SYS (CHECK DISPLAYS, TURN SIGNALS, HIGH BEAMS, HEADLAMP FLASHER AND FOG LAMPS). NONE OF THE EXTERIOR LIGHTS SEEM TO FUNCTION. THIS ALL OCCURRED WITHOUT WARNING AND FORTUNATELY HAPPENED WHILE STOPPED IN THE DRIVEWAY. CHECKED RECALL LOG ON NHTSA FOR VIN AND FOUND "0" RECALLS. THE VEHICLE ALSO INCLUDES "X-DRIVE" (ALL WHEEL DRIVE SYSTEM).