2021 BMW 540I Owner Complaints

Starter engine failure. Car failed to start multiple times. Major safety hazard that can cause a short circuit, melt wiring harnesses, and spark an engine bay fire posing an immediate threat to life. Problem was inspected and confirmed by a dealer. Multiple waring lamps and messages appeared. Dealer report stated: STARTER MOTOR FAULTY. ENGINE ELECTRICAL SYSTEM CONCERN: C/S: REPEAT START ATTEMPT INTERMITTEN WARNING LIGHTS. Please issue recall for the safety of all drivers.

NHTSA ID

11749530

Incident

May 26, 2026

The contact owns a 2021 BMW 540I. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was an abnormal sound coming from the vehicle before the vehicle lost motive power. No warning lights were illuminated. The contact stated that the vehicle failed to respond while in drive(D) or reverse(R). The vehicle was towed to the dealer, where it was diagnosed with a driveshaft failure. The contact was informed that the driveshaft needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 21V046000 (Power Train); however, the VIN was not associated with the recall. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 66,700.

NHTSA ID

11727007

Incident

Mar 22, 2026

Mileage

66,700 mi

In November 2025 my breaks quit working. I had AAA haul my car to a repair shop. They ran the codes on the car and found that it was related to a recall on 2021 BMW 540i's for the oil vacuum pump assembly, pan and gasket. I then had it towed to BMW and found out that my vin was not in the recall. BMW quoted me $4587 to repair this on a car with 45,000 miles. I then had it towed to a repair shop that replaced the oil vacuum pump assembly, oil pan, gasket and bolts for about $3700. I think that my vin should have been included in the recall. It was a obviously a common problem with my model and I should not have to pay this much on a car with 45,000 miles. I also had to pay $283.81 for BMW to diagnose it.

NHTSA ID

11717479

Incident

Nov 9, 2025

We notice the lose of braking power right after we started the car on 4/30 morning. The car was totally fine before that. took it to the BMW dealer they said the problem is "Vacuum/oil pump failing internally. fault for brake booster pressure switch, no brake boost" I find that there is a recall for the exact problem but it doesn't include my vehicle The "Part 573 Safety Recall Report 21V-598" stated that when It does happen it will cause damage to the oil/vacuum pump. I think recall 21V-598 should include my vehicle

NHTSA ID

11658906

Incident

Apr 30, 2025

Unintended car acceleration, with complete brake failure. No software warning icons in dash, no collision avoidance or ABS triggered even though car so equipped. Crashed into rear end of stationery vehicle,. [XXX] , MN police were called. Incident report # attached. (1st image) Western National Insurance Co. notified.Claim # attached (2nd image) Car will be inspected @ BMW dealership in Bloomington, MN 7/25/23. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11533979

Incident

Jul 22, 2023

The contact owns a 2021 BMW 540I. The contact stated that on multiple occasions, the front and rear passenger’s and driver’s side seat belts failed to detach after being connected. The contact stated that he forced the rear passenger’s side seat belt to detach with a screwdriver. No warning lights was illuminated. The vehicle was taken to the dealer where the dealer stated that candy was lodged in the buckle. The contact stated that the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 10,000.

NHTSA ID

11490291

Incident

Oct 7, 2022

Mileage

10,000 mi

Intermittent vibration at highway speeds. Brought to the BMW dealership and they stated the right front wheel was out of round. I never hit a pothole or anything that would cause damage. The dealer "repaired" the wheel, but the problem still exists. Brought the vehicle back and am now told that BMW has started offering non-run flat tires on new cars. I feel that the run flat tires coupled with the low-profile wheels could be the issue. Also, feel that the wheels are poorly made and are prone to being warped.

NHTSA ID

11488196

Incident

Sep 8, 2022

2021 BMW 540I. CONSUMER WRITES IN REGARDS TO MULTIPLE DEFECTS DUE TO BATTERY MANAGEMENT ISSUE. THE CONSUMER STATED THE VEHICLE HAS EXPERIENCED MULITPLE OCCASIONS OF FAILURES WITH THE BREAKING SYSTEM. THE DRIVER HAD TO PRESS THE PEDAL TO THE FLOOR IN ORDER TO STOP THE VEHICLE. THE EMERGENCY BRAKING SYSTEM ENGAGED WITHOUT WARNING, THE AUTOSTART ENGAGED INDEPENDTLY, AND LIGHTING/SPEAKER/SUNROOF MALFUNCTION.

NHTSA ID

11449238

Incident

Jan 28, 2022