2022 BMW 540I Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2022 BMW 540I, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system228.6%
- Airbags114.3%
- Electrical114.3%
- Engine114.3%
- Powertrain (other)114.3%
- Seat belts114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
While turning my 2022 BMW 540i onto a busy, 50 MPH road, the vehicle suffered a catastrophic drivetrain failure, without any physical trauma such as encountering a curb or pothole. The car experienced a total and immediate loss of motive power (propulsion), leaving me coasting in live traffic. This created an extreme safety hazard as I was unable to accelerate or maintain speed to clear the roadway safely. The failure occurred immediately after a significant temperature stress: taken from a heated garage, driven with no issue for 40 minutes, then parked in 15 degree weather for two hours, then complete failure within moments of starting up after the two hour cold parking block. My reading since the incident reveals that BMW quietly switched a critical drivetrain part from a composite/plastic material to metal in later 2022 production runs, due to temperature tress failures precisely as I experienced. This 'silent fix' suggests a known design defect in early 2022 models that poses a recurring risk of sudden propulsion loss. BMW did not do a recall for this, but they should have: I and other drivers were in real danger when my car spontaneously lost all motive ability in high speed traffic.
On Feb.3, 2023, my wife made a turn into a parking lot. She was driving our 2022 BMW 540. She paused and the engine began to rev up. It then shot forward nearly 50 feet and hurled her over a meridian into another car. She pressed as hard as she could on the brake and suffered a torn meniscus ligament. There were no warning lights and although the car hit front right, no airbags were executed. BMW has not sent an official detailed report from their engineer. BMW advertises brake override so pressing both the brake and accelerator would NOT result in this event.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
Passenger Restraint service message. Possibly related to airbag seat or floor sensor. Checked BMW customer forums and appears to be widespread issue.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
On Feb.3, 2023, my wife made a turn into a parking lot. She was driving our 2022 BMW 540. She paused and the engine began to rev up. It then shot forward nearly 50 feet and hurled her over a meridian into another car. She pressed as hard as she could on the brake and suffered a torn meniscus ligament. There were no warning lights and although the car hit front right, no airbags were executed. BMW has not sent an official detailed report from their engineer. BMW advertises brake override so pressing both the brake and accelerator would NOT result in this event.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
On Feb.3, 2023, my wife made a turn into a parking lot. She was driving our 2022 BMW 540. She paused and the engine began to rev up. It then shot forward nearly 50 feet and hurled her over a meridian into another car. She pressed as hard as she could on the brake and suffered a torn meniscus ligament. There were no warning lights and although the car hit front right, no airbags were executed. BMW has not sent an official detailed report from their engineer. BMW advertises brake override so pressing both the brake and accelerator would NOT result in this event.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
While turning my 2022 BMW 540i onto a busy, 50 MPH road, the vehicle suffered a catastrophic drivetrain failure, without any physical trauma such as encountering a curb or pothole. The car experienced a total and immediate loss of motive power (propulsion), leaving me coasting in live traffic. This created an extreme safety hazard as I was unable to accelerate or maintain speed to clear the roadway safely. The failure occurred immediately after a significant temperature stress: taken from a heated garage, driven with no issue for 40 minutes, then parked in 15 degree weather for two hours, then complete failure within moments of starting up after the two hour cold parking block. My reading since the incident reveals that BMW quietly switched a critical drivetrain part from a composite/plastic material to metal in later 2022 production runs, due to temperature tress failures precisely as I experienced. This 'silent fix' suggests a known design defect in early 2022 models that poses a recurring risk of sudden propulsion loss. BMW did not do a recall for this, but they should have: I and other drivers were in real danger when my car spontaneously lost all motive ability in high speed traffic.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
Passenger Restraint service message. Possibly related to airbag seat or floor sensor. Checked BMW customer forums and appears to be widespread issue.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .