2018 BMW 640XI Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 BMW 640XI, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags250.0%
- Driver assistance125.0%
- Visibility125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
My BMW's passenger side airbag malfunction light randomly came on and will not turn off. When I went to the dealer, BMW quoted apprx. $3000 to replace the seat sensor mat which they said probably got wet? No water was ever on the seat and no passenger sits there - just my purse. I feel this is a safety related defect after seeing numerous reports and complaints online and trying to fix the issue. The warning message also blocks other important information on my dashboard.
Consistent passenger restraint / passenger airbag failure warning. Took vehicle to BMW dealership and was told that the passenger seat must have moisture damage, causing the issue. There have been no spills or leaks in the vehicle. Quoted $2600 to fix. See attached. Vehicle’s safety in question.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
The contact owns a 2018 BMW 640XI. The contact stated that while pulling up to a red traffic light, the brake pedal was depressed; however, the engine revved unexpectedly, and the vehicle unintendedly accelerated and drove forward approximately 3-feet. The contact turned the vehicle off and restarted the engine and the engine continued to rev very high. The vehicle was restarted a second time and the unintended revving ceased and the vehicle operated normally. The following morning the vehicle was driven to the local dealer. The cause of the failure was not determined. The contact stated that the failure had occurred on one previous occasion. The manufacturer was notified of the failure. The failure mileage was 60,448.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
Moonroof shade failure. Droops, blocking rear window visibility while driving. Happened with no warning. Will bring to service center for inspection.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .