RoadVitals

1994 BMW 740I

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
7
Latest Oct 23, 2008
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Aug 19, 1997
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 7 NHTSA owner-reported complaints for the 1994 BMW 740I, most frequently naming the engine, steering and driver assistance categories. 2 safety recalls have been issued covering this model year; and 3 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Engine444.4%
  • Steering222.2%
  • Driver assistance111.1%
  • Suspension111.1%
  • Transmission111.1%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
97V131000

VEHICLE SPEED CONTROL

Aug 19, 1997
410,000 units potentially affected
The defect: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
The risk: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov
96V111000

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

Jul 1, 1996
180,000 units potentially affected
The defect: THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
The risk: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
BAYERISCHE MOTOREN WERKEView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Driver assistance
Filed Oct 23, 2008

TL*THE CONTACT OWNS A 1994 BMW 740I. THE CONTACT STATED THAT HIS CRUISE CONTROL LOCKED UP AT FULL THROTTLE. WHILE DRIVING 65 MPH, THE VEHICLE ACCELERATED TO OVER 100 MPH WHEN THE CRUISE CONTROL WAS ACTIVATED. HE LOST CONTROL OF THE VEHICLE AND DEPRESSED THE BRAKES, AS WELL AS ENGAGED THE EMERGENCY BRAKE TO STOP. HE DROVE TO A SERVICE STATION AND SOMEONE DISCONNECTED THE CRUISE CONTROL. THE VEHICLE WAS ABLE TO BE DRIVEN AWAY NORMALLY WITHOUT USING THE CRUISE CONTROL. THE BMW DEALER ADVISED HIM TO HAVE THE VEHICLE TOWED TO THEM ON OCTOBER 27, 2008. THE FAILURE MILEAGE WAS 102,000. UPDATED 11/14/08 *CN UPDATED 11/18/08.*JB UPDATED 12/12/08 *CN UPDATED 12/15/08. *JB

NHTSA ID
10246543
Incident
Oct 21, 2008
Mileage
102,000 mi
Engine
Filed Aug 3, 2007

LTR FROM SENATOR ON BEHALF OF CONSUMER REGARDING THE GOVERNMENT ALLOWING BMW TO IMPORT AUTOMOBILES INTO THE US MARKET WITH A DEFECTIVE ENGINE**CC THE CONSUMER OWNS A 1994 BMW 740I WHICH HAD A PROBLEM KNOWS AS A LEAK DOWN PROBLEM WHICH RESULTED IN THE ENGINE BLOCK HAVING TO BE REPLACED. THE CONSUMER STATED THE MANUFACTURER USED NIKASIL, AN ALUMINUM NIKEL AND SILICON ALLOY TO LINE THE CYLINDERS OF THE M60 ENGINE. THE CROSS-HATCHED NIKASIL LININGS REACT WITH HIGH SULFUR CONTENT GASOLINE. THE REACTION CAUSED DAMAGED TO THE VERY TOP OF THE CYLINDER BORE, WHERE THERE WAS MOST CONTACT OF THE BURNING MIXTURE AND CYLINDER LINING. THE DAMAGED PREVENTED A GOOD SEAL FROM FORMING BETWEEN THE PISTON CYLINDER WALL WHICH CAUSED A LOSS OF COMPRESSION IN THE COMBUSTION CHAMBER. *JB

NHTSA ID
10199160
Incident
Jan 1, 1901
Engine
Filed Jan 10, 2007

1994 740I BMW LEAK DOWN PROBLEM THAT DESTROYED THE ENGINE**CC THE LEAK DOWN FLAW CAUSED THE ENGINE TO DEVELOP WORN LININGS AND EXHIBIT A ROUGH IDLE. THE CONSUMER STATED THE MANUFACTURER USED NIKASIL, AN ALUMINUM, NICKEL AND SILICON ALLOY TO LINE THE CYLINDERS OF THE M60 ENGINE. THE CROSS HATCHED NIKASIL LININGS REACTED WITH HIGH SULFUR CONTENT FOUND IN LOWER-QUALITY GASOLINE. THE REACTION CAUSED DAMAGE TO THE VERY TOP OF THE CYLINDER BORE, WHERE THERE IS MOST CONTACT OF THE BURNING MIXTURE AND THE CYLINDER LINING. THE DAMAGE PREVENTED A GOOD SEAL FROM FORMING BETWEEN THE PISTON AND THE CYLINDER WALL, WHICH CAUSED A LOSS OF COMPRESSION IN THE COMBUSTION CHAMBER. THE CONSUMER STATED THE ONLY PERMANENT FIX FOR THE PROBLEM IS TO REPLACE THE SHORT BLOCK WITH THE EQUIVALENT BLOCK USING ALUSIL LININGS, WHICH DO NOT EXHIBIT THE CORROSION PROBLEM. *JB

NHTSA ID
10178546
Incident
Jan 1, 1901
Engine
Filed May 18, 2004

SINCE 1999 MY 1994 740I WITH 41,367 MILES HAS INTERIM CAR SHAKES ON THE STREET AND AT FREEWAY SPEEDS. FOR TWO YEARS THE DEALER TOLD ME IT WAS NOTHING AND WE SHOULD REPLACE THE MOUNTS. *AK NOW IN 2004 THE ENGINE SHAKES REAL BAD, LACKS POWER, AND A LOT OF GREY SMOKE IS COMING OUT OF THE EXHAUST SYSTEM. WE'VE GONE BACK TO THE DEALER AND AFTER CHARGING US $350 FOR A CYLINDER LEAK TEST WE HAVE CONFIRMATION THAT ALL 8 CYLINDERS HAVE BETWEEN A 38%-60% LEAK. BMW NOW STATES THAT AT 73,114 WE NEED TO REPLACE THE ENGINE AT A COST OF $14,732.

NHTSA ID
10072791
Incident
May 17, 2004
Mileage
41,367 mi
Engine
Filed Jan 23, 2004

I HAVE LISTED A NUMBER OF COMPLAINTS THAT ARE EQUAL TO THE TYPE OF PROBLEM THAT I AM HAVING. TELL IF THIS TRUE AND WHAT CAN I DO. I HAVE A 1994 BMW 740I WITH 89,000 MILES. 1) 740I M60 SLIGHT SHAKING VIBRATING AT IDLE HELLO, MY 740I MODEL 1994 95,000 MILES (BUILT SPET. 1993) IS SHAKING A LITTLE AT IDLE. I HEARD ABOUT THE NIKASIL ISSUE, BMW SHOP SAYS THAT'S NOT THE REASON. THE AIR PRESSURE HAS BEEN TESTED FOR LEAKAGE (AT OIL FILL IN) AND WITH 2.5 (OF WHATEVER) IT IS OKAY, SAYS THE MECHANIC. 3.5 AND ABOVE WOULD BE BAD, HE SAYS. THEIR SOLUTION TO SOLVE THE SHAKING IS TO REPLACE THE ENGINE AND TRANSMISSION MOUNTS (890.00 US$ TOTAL), BUT I DON'T AGREE WITH THEM, SINCE THE SHAKING IS VISIBLE AT THE ENGINE BLOCK, AND THAT IS NOT NORMAL. EVERY NOW AND THEN (+-3 SECONDS) A SLIGHTLY STRONGER SHAKE IS NOTICEABLE. IT IS NOT REALLY DRAMATICAL, JUST ANNOYING, AND DEFINITELY NOT NORMAL, SINCE THE ENGINE DOESN'T RUN SMOOTHLY ROUND (MY DAD HAS THE SAME CAR, SO I KNOW HOW NICE IT CAN BE). RECENTLY THE SPARK PLUGS AND ROCKER GASKETS HAVE BEEN REPLACED. IF ANYONE HAS ANY IDEA WHAT TO LOOK FOR NEXT, I WOULD REALLY APPRECIATE COMMENTS! 2) THE PROBLEM IS LISTED AT HTTP://WWW.KOALAMOTORSPORT.COM/TECH/MISC/V8SHORTBLOCK.HTM TELL ME IF THIS MY PROBLEM? ARE YOU GOING TO FIX. 180,000 UNITS AFFECTED. *LA

NHTSA ID
10054756
Incident
Jan 16, 2004
Mileage
89,411 mi
SteeringSuspensionTransmission
Filed May 23, 2002

WHEN PUTTING VEHICLE IN NEUTRAL, IT ROLLS BACK LIKE VECHICLE IS STILL IN REVERSE. DEALER CONTACTED.*JB REPLACED BUSHINGS AND IDLER ARM AND WHEEL ALIGNMENT. LEFT VALVE COVER GASKET REPLACED. REPLACED POWER STEERING RETURN CLAMP. REPLACED FRONT CONVERTER TO WELD. TRANSMISSION NEEDS TO BE REBUILT. *TT

NHTSA ID
8010419
Incident
May 1, 2002
Steering
Filed Sep 21, 1999

DRIVER TURNED ON TO HEAVILY TRAVELED STATE HIGHWAY WHEN STEERING WHEEL FAILED TO TURN TIRES. CAR TRAVELED ACROSS HIGHWAY AND CAME TO REST JUST SHORT OF DITCH. CAR HAD TO BE TOWED TO DEALERSHIP FOR REPAIR.

NHTSA ID
711714
Incident
Sep 13, 1999

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

B510819

ELECTRICAL SYSTEM; VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The basic conditions for initializing the power windows are not met.

B122917

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SERVICE ACTION: PROGRAM DME: The incorrect dataset could be programmed into DME 5.2.1 control module.

72/07/96

EQUIPMENT:OTHER:LABELS

CHILD AIRBAG LETTER, WARNING LABEL AND SAFETY REFERENCE CARD. *TW

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

BMW 740I by model year
YearComplaintsRecallsInvestigationsIssue Index
2026000—
2025030—
2024350—
2023109048.3
2022000—
2021120—
2020120—
2019410—
2018500—
2017700—
2016120027.1
2015110—
2014110—
2013110—
2012410—
2001154055.6
2000122049.2
1999810—
1998810—
1997330—
1996130—
1995950—
1994Viewing720—
1993152048.9

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.