2006 BMW 750LI

In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770

In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat

BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.

IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).

The contact owns a 2006 BMW 750Li. The contact stated that while attempting to start the vehicle, the check engine warning light was illuminated, and the message "Transmission Fault - Drive Moderate" was displayed. The vehicle was taken to a dealer, where the contact was advised that the vehicle would need to be kept over the weekend, but the contact declined. The vehicle was taken to Pep Boys, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 159,857.

NHTSA ID

11708033

Incident

Feb 15, 2025

Mileage

159,857 mi

The contact owns a 2006 BMW 750LI. The contact stated that while driving at an undisclosed speed, the gear shifter independently shifted into park. The contact also stated that water was entering the trunk of the vehicle. The contact stated that the battery had been replaced twice. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000.

NHTSA ID

11542182

Incident

Aug 8, 2022

Mileage

180,000 mi

In 2009, we bought this 2006 BMW 750Li as pre-owned and certified warranty from BMW of Tenafly, New Jersey. We have registration address maintained in New Jersey, and have not updated, even though we moved to Chicago, Illinois in summer of 2011. BMW issued 6 recalls for 7-series manufactured between 2005 and 2008. The recalls on manufacturer defects on electric and transmission in 2012 and 2013, and again in 2017. We missed all of the notices for these recalls. The vehicle was driven for less than 50,000 miles, from 2009 to 2019. The vehicle was inspected, and in good mechanical conditions, as well as body, since the vehicle has been garaged most of times. Since 2019, the vehicle has been in shops for repairs for electric and transmission and engine. It has been more than 3 years for our vehicle in the shops, and over $21,000 spent, there is no sign that the vehicle can be driven. Thus, we checked the online and found out the BMW recalls on this vehicle in 2012 and 2013. We called BMW Customer Relations & Services, multiple times. BMW denied the recalls. We checked with the attorneys, including the ones who filed class action suits against BMW with billion dollars win for the customers on BMW defects. All said BMW shall honor their recalls. Further, the recalls will never be expired. Now BMW has declined taking calls, responding email, and recently shifting the failing repair to a BMW dealer. What shall we do? We have sent letter to their legal department. A shop who tried to repair over 2 years reported to us that this 2006 BMW 750Li has a very bad reputation on electric and transmission. He said this is a common agreement among BMW dealers. Since BMW customer relations and services now shut us out, what department within BMW shall we go to. Shall we find an attorney for another class action suit, which occurred already? The consumer is requesting reimbursement of $21k for repairs made as well as payment made to purchase the vehicle.

NHTSA ID

11504344

Incident

Aug 20, 2019

On Oct 29, 2012, BMW recalled its 7-Series luxury cars due to reports of transmission control problems. The National Highway Traffic Safety Administration reported in the NHTSA campaign #12V502000 (power train and electric system) has caused at least 14 crashes and possibly 5 injuries, and in the NHTSA campaign #13V564000 (air bags). The recall involved 45,500 cars with model years from 2005 to 2008 that includes 2006 BMW 750LI. Our 2006 BMW 750LI’s VIN is WBAHN83586DT34592. Our purchase was from BMW of Tenafly, 301 County Road, Tenafly, NJ 07670 on 3/19/2009. Odometer reading at the time of the purchase is 45,450 miles. Sale price is $35,777.84. Our BMW 750LI was vocationally used, and mostly garaged, from 2009-2011, in New Jersey; and completely garaged, from 2011-2014, in New Jersey. The vehicle was vocationally used, from 2014-2019, in Chicago. Since 2019, the vehicle has been repaired in shops for electric and transmission failures: 3 years by Bridgeport Transmission (930 W 31st Street, Chicago, IL 60608, Tel 312 842-1887, Richard, the owner), and now already 6 months with Field BMW Northfield (700 Frontage Road, Northfield, IL 60093, Tel: 847-441-5300 x 8396, Chris Goodrich, the service advisor). Except for the electric and transmission issues, our vehicle is in wonderful condition. The body looks new. The current odometer reading is 92,000 miles. Since 2019, we have spent $1,500 for battery (as it was first suspected of the issue) by Field BMW Northfield, $6,500 for electric and transmission by Bridgeport Transmission, $650 for programming by a BMW dealership, and $5,350 for DSC control unit, and multiple tows 4 x $350 = $1,400. Total expenditure is $15,400. Currently, Field BMW Northfield asks additional $8,700 for transmission, but does not guarantee the vehicle can be repaired.

NHTSA ID

11502144

Incident

Jul 10, 2019

The drivers side (soft close door) motor or components is malfunctioning and not closing. It’s making a grinding noise.

NHTSA ID

11485370

Incident

Sep 19, 2022

The contact owns a 2006 BMW 750LI. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. Additionally, there was oil leaking onto the ground and also onto the engine. The vehicle was taken to an independent mechanic who diagnosed that the brake vacuum pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA. The failure mileage was approximately 129,000.

NHTSA ID

11477374

Incident

Aug 3, 2022

Mileage

129,000 mi

THE TRANSMISSION IS VERY DANGEROUS, WHEN PRESSING ON THE ACCELERATOR IT WILL REV THE ENGINE HIGH, THEN JUMP INTO GEAR AND LUNGE FORWARD. IF STOPPED AT A LIGHT, IT WOULD DEFINITELY KILL SOMEONE, AND WHEN STOPPING THE VEHICLE, IT FEELS LIKE YOU ARE GETTING REAR-ENDED. ON THIS DATE, THE TRANSMISSION LAUNCHING THE VEHICLE FORWARD ALMOST CAUSED A CASE OF WHIPLASH.

NHTSA ID

11403628

Incident

Mar 17, 2021

Mileage

85,000 mi

THE DOORS FROM INSIDE DON'T OPEN UP WHEN THE CAR LOSES POWER YOU ARE LOCKED INSIDE ALSO THE ENGINE SMOKES EVEN WHEN THE GASKETS AND SEALS HAVE BEEN REPLACED.THE CAR SUSPENSION IN THE REAR IS TERRIBLE ALSO AIR BAG LIGHT GOES ON AND OFF EVEN WHEN THE DEALER RAN DIAGNOSIS ON THE CAR CAR IS PARKED

NHTSA ID

11355444

Incident

Aug 19, 2020

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle’s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.

Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.

Component-Specific Limited Warranty Extension For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's front and rear air suspension strut assemblies (item # 1 Front and # 2 Rear, shown) to: 8 years/80,000 miles, as determined by the vehicle's original in-service date. Other air suspension system-related components/issues are excluded from this coverage. This component-specific limited warranty extension applies to defects in materials or workmanship. This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusions that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks.