2003 BMW F 650 Gs Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2003 BMW F 650 Gs, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical125.0%
- Fuel system125.0%
- Steering125.0%
- Suspension125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
MOST WIRES OUT OF IGNITION SWITCH, INSIDE HARNESS TUBING, ARE EXPOSED & THE MAIN WIRE BROKE. THIS RESULTED IN COMPLETE VEHICLE STALL DURING TURNS. NO ABRASIONS OR SIGNS OF FATIGUE ON OUTSIDE HARNESS COVER. VERY UNSAFE FOR A MOTORCYCLE TO STALL WHILE CORNERING. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
DURING NORMAL RIDING ON A VACATION TRIP I STOPPED TO REFUEL AND GAS WAS LEAKING ON THE GROUND. AFTER REMOVING THE SEAT I FOUND WHAT IS LISTED BELOW. ABOUT ONE HALF GALLON OF GAS LEAKED ON THE GROUND BEFORE I WAS ABLE TO USE EPOXY PUTTY TO STOP THE LEAK. A HAIRLINE CRACK IN THE FUEL PUMP/FILTER ASSEMBLY "CAP" ON TOP OF THE TANK WHICH ALLOWS FUEL TO LEAK OUT OF THE TANK AND POOL UNDER THE SEAT CREATING A FIRE/EXPLOSION HAZARD. THIS IS THE SAME PROBLEM REFERRED TO IN NHTSA CAMPAIGN ID NUMBER : 04V236000 REGARDING THE CS MODEL. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
MOST WIRES OUT OF IGNITION SWITCH, INSIDE HARNESS TUBING, ARE EXPOSED & THE MAIN WIRE BROKE. THIS RESULTED IN COMPLETE VEHICLE STALL DURING TURNS. NO ABRASIONS OR SIGNS OF FATIGUE ON OUTSIDE HARNESS COVER. VERY UNSAFE FOR A MOTORCYCLE TO STALL WHILE CORNERING. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2003 BMW F650 GS MOTORCYCLE. THE CONTACT STATED THAT AFTER DRIVING OVER A ROAD BUMP AT 65 MPH, THE REAR SUSPENSION MALFUNCTIONED AND CAUSED DAMAGE TO THE REAR WHEEL AND AN OIL LEAK. THE OIL LEAK CAUSED THE ENGINE TO MALFUNCTION AS WELL. THE CONTACT HAD VEHICLE TOWED TO THE DEALER BUT THE DEALER REFUSED TO INSPECT THE VEHICLE DUE TO THE DESTRUCTION OF THE REAR SUSPENSION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 4,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .