2007 BMW K1200 GT Problems

ABS FAILED. ON FREEWAY. NO WARNING. LESS THEN 36K MILES. THIS TURNS OUT IS COMMON PROBLEM WITH BMW. PLEASE READ: HTTP://WWW.BMWLT.COM/FORUMS/K1200-1300GT-NEXT-GENERATION/67353-ABS-PUMP-FAILURE.HTML HTTP://WWW.XS-ADVENTURE.COM/MOTORCYCLE/BMW-MOTORCYCLE-BRAKE-FAILURE HTTP://WWW.I-BMW.COM/SHOWTHREAD.PHP?T=33170

BRAKE LIGHT CAME ON AFTER ONLY 8000 MILES. MOTORCYCLE IS ADULT DRIVEN, LIGHTLY USED, REGULARLY MAINTAINED AND GARAGED. BMW CAN DO BETTER THAN THIS.

FOR THE SECOND TIME THE ENING SHUT OFF COMPLETELY UNDER ACCELARATION. THE ELECTRONICS AND ENGINE WENT TOTALLY DEAD. HAD TO PULL OVER TO RESTART. THE BIKE WAS BEING SHIFTED FROM 1ST GEAR INTO SECOND WHEN IT DIED.

THIS MOTORCYCLE HAS REPEATEDLY STALLED AS I DECELERATE TO A STOP. THE DAY OF THIS REPORT IT STALLED 5 TIMES. THE DEALER HAS NOT BEEN ABLE TO DETERMINE WHY THIS HAPPENS AFTER SEVERAL INSPECTIONS BY THE DEALER. THE MOTORCYCLE RESTARTS IMMEDIATELY BUT IT IS A SAFETY ISSUE SINCE BRAKING AND TRAFFIC FLOW PROBLEMS ARE CREATED BY THIS STALLING. THIS ISSUE HAS BEEN RECURRING FOR THE YEAR I HAVE OWNED THIS VEHICLE. *TR

FUEL STRIP FAILURE FOR SECOND TIME AFTER BMW EXTENDED WARRANTY TO 12 YEARS AFTER ORIGINAL DATE OF PURCHASE. THIS IS A SAFETY ISSUE BECAUSE THE LOW FUEL LIGHT REMAINS ON CONSTANTLY. COULD CAUSE A CRASH IF THE MOTORCYCLE WERE TO RUN OUT OF FUEL.

FUEL PUMP MOUNTING BOSS FOR FUEL LINE CONNECTION CRACKED. FUEL SPRAYS ONTO BACK OF ENGINE AND FLOWS ON TO THE EXHAUST SYSTEM, I SAW SMOKE COMING FROM UNDER BIKE WHEN STOPPED AT END OF DRIVEWAY. SAW FUEL RUNNING DOWN THE SIDE OF THE ENGINE ON TO THE EXHAUST. THE MOTORCYCLE WAS NOT FULLY WARM, IT HAD BEEN RUNNING ONLY 1-2 MINUTES. BASED ON THE FLOW OF LEAKING FUEL, THE MOTORCYCLE WOULD HAVE CAUGHT FIRE WHEN THE ENGINE AND EXHAUST REACHED NORMALLY OPERATING TEMPERATURE. THIS FAILURE HAS BEEN DOCUMENTED AT K-BIKES.COM AND I-BMW.COM AND ON THIS COMPLAINT SITE. *TR

I HAVE A 2007 K1200GT MOTORCYCLE, AN EARLY PRODUCTION MODEL, THAT HAS DEVELOPED A PROBLEM WITH THE ENGINE SPEED CONTROL - THE ENGINE EXPECTEDLY REVS UP AND DOWN (HUNTS). I DID AN INTERNET SEARCH AND FOUND BMW NORTH AMERICA SERVICE BULLETIN 13 003 07 (058), WHICH DESCRIBES THE EXACT PROBLEM WITH THE BIKE. THE SERVICE BULLETIN WAS INTENDED FOR THESE EARLY PRODUCTION BIKES. HOWEVER, THE ISSUE ONLY SURFACED RELATIVELY RECENT ON MY BIKE, WHICH IS NOW OUT OF WARRANTY EVEN THOUGH THERE WAS ONLY 12,000 MILES ON THE BIKE AT THE TIME. I TOOK THE BIKE INTO THE SAN FRANCISCO BMW DEALER AND THEY REFUSED TO COVER THE RECOMMENDED REPAIRS. THEN CONTACTED BMW NORTH AMERICA AND THEY HAVE ALSO REFUSED TO FIX THE ISSUE. THE ISSUE IS PARTICULARLY HAZARDOUS, AS THE BIKE WILL CUT OUT UNEXPECTEDLY AND/OR ACCELERATE DESPITE CLOSING THE THROTTLE, AS IS NECESSARY WHEN APPROACHING A CORNER. AS A SENIOR PRODUCT SAFETY ENGINEER WITH OVER 20 YEARS EXPERIENCE, I FIND THIS A SIGNIFICANT SAFETY ISSUE, AND AM SHOCKED THAT BMW NA HAVE NOT VOLUNTARILY ADDRESSED THIS ON ALL EARLY PRODUCTION UNITS.

AFTER ABOUT AN HOUR OF RIDING THROTTLE WILL NOT SHUT OFF WHEN RETURNED. DEAD SPOTS AT LOW RPM AND ROUGH IDLE. THERE ARE THOUSANDS OF POOR BUYERS WITH THIS EXACT PROBLEM BUT STILL NO SERVICE BULLETIN? WILL SOMEONE GET KILLED FIRST? *TR

THE ABS MODULE FAILED ON THIS VEHICLE THE LOCAL DEALER HAS INDICATED SEVERAL OF THE SAME MODEL AND YEAR HAVE HAD THE MODULE FAIL SEVERAL INTERNET FORUMS INDICATE THIS IS A COMMON FAILURE AND THE QUANTITY OF FAILURES EXCEEDS 10% OF THE MODEL AND YEAR OF VEHICLE FAILURE. *TR

2007 BMW1200GT WITH 15,000 MILES RUNS GOOD HOWEVER ENGINE HAS STALLED FOUR TIMES IN ONE WEEK WHEN COMING TO STOP ' OCCURS WHILE GEARING DOWN FOR STOP AND WHEN SHIFTING UP. ONCE WHILE TURNING AND DOWNSHIFTING BETWEEN 3RD TO 2ND CUT OUT AND NEARLY LOST THE BIKE. SEARCHED WEB AND PROBLEM IS PERVASIVE -- WHEN WILL YOU ACT AND I WILL CONTACT CONGRESSMAN, SENATOR AND CALIFORNIA CONSUMER BUREAU. *TR

FAILURE OF FINAL DRIVE (BOTH U-JOINTS, DRIVE SHAFT, FINAL DRIVE BEARINGS AND GEARS), MODEL SELECTION DOES NOT INCLUDE THE MY MODEL. K1200LT, THERE ARE TWO LISTINGS FOR K1200GT. THESE ARE NOT THE SAME BIKE. *TR

(NOTE: 2000 CHARACTERS IS TOO SHORT!) 2007 BMW K1200GT MOTORCYCLE 15,433 MILES EVENT DATE/PLACE: AUGUST 4, 2011; RIDING HOME FROM WORK (24 MILES). PRIMARY DEFECT: COMPLETE AND SUDDEN DRIVE DIFFERENTIAL OIL LOSS! (THIS ENDANGERED MY LIFE THROUGH POSSIBLE SUDDEN GEAR FAILURE--HENCE, LOST POWER TO DRIVE WHEEL; OIL COATED REAR TIRE, OIL SATURATED REAR BRAKE PADS.) SECONDARY DEFECT: MANUFACTURER PROVIDES NO WARNING OF THIS DESIGN FLAW--NEITHER AT POINT OF SALE OR IN MEAGER MAINTENANCE DATA. EXPECTATION IS THIS UNIT WILL EXCEED 100,000 MILES WITH OIL CHANGES EVERY 6,000 MILES. THIS IS A RELATIVELY NEW, $21,000 BIKE; 11 MONTHS BEYOND WARRANTY. I CHANGED OIL EVERY 3,000 JUST TO BE SAFE. (EVEN MY OLD TRUCK DIFFERENTIAL WITH 140,000 DOESN'T LEAK OIL--MUCH LESS SUFFERING A TOTAL LOSS OF LUBRICANT! NEVER MIND DRIVING A TRUCK IS A SIGNIFICANTLY LESS CHALLENGING TASK!) SOLUTION: RECALL THESE BIKES AND HAVE THE MANUFACTURER PROVIDE APPROPRIATE ENGINEERING REDESIGN--SUCH THAT ONLY 1 DIFFERENTIAL FAILS IN EACH 100 UNITS PER 100,000 MILES, OR HAVE FACTORY PROVIDE AND INSTALL NEW DIFFERENTIALS EVERY 10,000 MILES FOR THE LIFE OF THE MOTORCYCLE, OR PULL THESE MACHINES OFF THE ROAD BEFORE SOMEONE GETS KILLED. RESOLUTION: NONE. I HAVE CONTACTED THE MANUFACTURER (LAST WEEK) AND I AWAIT THEIR REPLY. I FEAR I MAY HAVE TO GO TO COURT--WE SHALL SEE. EVEN IF BMW AGREES TO REPAIR THIS MACHINE, THEY WILL NOT HAVE ADDRESSED THE DESIGN FLAW SINCE NO RECALL NOTICE HAS BEEN FORTH COMING. WILL THE NEXT DIFFERENTIAL SUDDENLY DUMP ITS OIL AT 5,000 MILES? OR AT 12,000 MILES? AGAIN, THERE EXIST NO MAINTENANCE CRITERIA OR FACILITATION FOR MAINTAINING THE INTEGRITY OF THESE SEALS. AND NEW MOTORCYCLES ARE BEING PRODUCED WITH VERY MUCH THE SAME DESIGN! (THE INTERNET REFLECTS OTHER, SIMILAR FAILURES.) IF INTEGRITY OF THIS UNIT CANNOT BE GUARANTEED FOR 100,000 MILES, THEN DESIGN CAPACITY SHOULD ALLOW FOR EASE AND FREQUENT SEAL CHANGES--AND SO SPECIFIED BY MAINTENANCE DATA. *TT