2002 BMW M Roadster Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 BMW M Roadster, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure240.0%
- Powertrain (other)240.0%
- Other / unspecified120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2002 BMW M ROADSTER. WHILE DRIVING APPROXIMATELY 35 MPH, A SQUEAKY NOISE WAS HEARD FROM OUTSIDE OF THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE SUB FRAME EXHIBITED SEVERAL CRACKS AND WAS SLIGHTLY SEPARATED. THE DEFECT BECAME PROGRESSIVELY WORSE OVER TIME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.
2002 BMW M ROADSTER TRUNK CROSSMEMBER (SUPPORTS THE REAR DIFFERENTIAL) SEPARATING FROM THE REST OF THE CAR. SPOT WELDS PULLED OUT. DANGER OF THE WHOLE CROSSMEMBER SEPARATING FROM THE CHASSIS. CORRECTED BY AN INDEPENDENT IN TOLEDO, OH. CROSSMEMBER REINFORCED BY AN INTERNAL I-BEAM, WELDED TO NEW CUSTOM-FABRICATED SUPPORTS ON THE LONGITUDINAL RAILS. THE OEM CROSSMEMBER IS NOW MERELY COSMETIC. DIFFERENTIAL COVER REPLACED BY ONE WITH A PAIR OF MOUNTS INSTEAD OF JUST ONE TO DISTRIBUTE LOAD. VEHICLE HAD LESS THAN 25,000 MILES ON THE ODOMETER. JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
REAR DIFFERENTIAL SIMPLY DROPPED WHILE DRIVING. IT AND THE SUBFRAME HAVE TORN UP REAR SHEET METAL UNDER THE TRUNK. I HAVE A REPAIR IN PROGRESS.*AK
THE REAR-SUBFRAME IS SEPARATING FROM THE TRUNK IN MY CAR. AS A RESULT, THE DIFFERENTIAL MOUNT HAS CRACKED AND THERE IS THE RISK OF THE DIFFERENTIAL TOTALLY SEPARATING FROM THE CAR.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
SPEEDOMETER ON NEW VEHICLE READS EXCESSIVLY HIGH (7 MPH AT 65 MPH). THERE WAS NOSPECIFIC INCIDENT. I WOULD LIKE TO KNOW IF THERE ARE ANY STANDARDS REGARDING THIS, AS MANUFACTURER SAYS THIS IS AN ACCEPTABLE ERROR. DATE BELOW IS ENTERED FOR REFERENCE ONLY.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .