RoadVitals

2001 BMW R1150GS Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Feb 3, 2012
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2001 BMW R1150GS, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Powertrain (other)3100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

3
reports

From owner reports, verbatim

WHILE ON A CROSS COUNTRY MOTORCYCLE TRIP. I WAS TRAVELING AT HIGHWAY SPEEDS WHEN THE MOTORCYCLE BEGAN TO HAVE A GRINDING NOISE AND VIBRATION FROM THE REAR. I STOPPED TO FIND OIL LEAKING FROM THE FINAL DRIVE ALL OVER THE REAR TIRE AND WHEEL ASSEMBLY. WHILE ATTEMPTING TO STOP, THE REAR ABS SYSTEM ACTIVATED BECAUSE THE GEAR OIL SATURATED THE BRAKE ROTOR AND PADS. I ALMOST CRASHED THE MOTORCYCLE BECAUSE OF THE OIL ON THE TIRE. THE FINAL DRIVE WAS SERVICED PER BMW SPECIFICATIONS OF GEAR OILTYPE AND WEIGHT DAYS PRIOR TO THE TRIP. THERE WERE NO INDICATORS PRIOR TO THE FINAL DRIVE FAILING. THE GEAR OIL ESCAPED THE HOUSING DUE TO A TORN BEARING SEAL ON THE BACK SIDE OF THE HOUSING NEXT TO THE BRAKE ROTOR. TEARDOWN OF THE FINALDRIVE ASSEMBLY FOUND A DISINTEGRATION OF THE MAIN BEARING INCLUDING BALL BEARINGS. THE METAL IN THE HOUSING TEARING THE BEARING SEAL LEAKING OIL ON TO THE REAR WHEEL ASSEMBLY. THE METAL IN THE HOUSING ALSO DAMAGED THE SECOND SMALLER BEARING WHICH HAD TO BE REPLACED. THE FOLLOWING ARE THE BMW PART NUMBERS FOR THE FAILED PARTS 33121242210 GROOVED BALL BEARING 33121451188 TAPERED BEARING 33127663482 SHAFT SEAL *KB

NHTSA ID 10446389 · filed Feb 3, 2012

BMW MOTORCYCLE REAR DRIVE FAILURE, COULD LEAD TO CATASTROPHIC CRASH IF REAR WHEEL LOCKS UP. DRIVE FAILED WITH NO ADVANCE SYMPTOMS. DRIVE REBUILT.*AK

NHTSA ID 10091356 · filed Sep 20, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .