2007 BMW X3 Sav Electrical Problems

TL* THE CONTACT OWNS A 2007 BMW X3. WHEN THE VEHICLE WAS WARMING UP, THE CONTACT STEPPED AWAY FOR A FEW MINUTES. UPON RETURNING, THE INTERIOR WAS FILLED WITH SMOKE. THE CONTACT NOTICED THAT THE FRONT DRIVER SEAT WAS BURNING. THE CONTACT TURNED THE ENGINE OFF AND WAITED FOR THE SEAT TO COOL DOWN. THE CONTACT DROVE THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRIC WIRING FOR THE SEAT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

NHTSA ID

10984819

Incident

Jan 4, 2017

Mileage

58,000 mi

TL* THE CONTACT OWNS A 2007 BMW X3 SAV. AFTER A SEAT WARMER WAS ACTIVATED, THE HEAT GENERATED BECAME SO INTENSE THAT IT BURNED A HOLE IN THE SEAT, AS WELL AS THE CONTACT'S JACKET AND JEANS. THERE WERE NO INJURIES. THE CONTACT WAS ALTERED TO THE FAILURE DUE TO A BURNING ODOR. THE FAILURE OCCURRED WITHOUT WARNING. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE FAILURE WAS CAUSED BY A FAULTY HEATING ELEMENT AND THE SEAT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 111,000.

NHTSA ID

10948899

Incident

Feb 1, 2017

Mileage

111,000 mi

IN COOL CLIMATE ON NOVEMBER 1, 2016. TURN ON MY HEAT SEAT, THEN I SMELLED SOMETHING BURNED, THEN I FELT SHARP BURN ON LEFT BUTT CHEEK. THEN I KNEW SOMETHING WRONG WITH HEAT I TURNED OFF, , ON NOVEMBER 7, 2016, I TRIED AGAIN,,, BURNING SMELL IS SO BAD, THE HEAT STILL BURNED ALMOST THROUGH OUT SIDE LAYER OF SEAT

NHTSA ID

10926115

Incident

Nov 1, 2016

Mileage

105,000 mi

BMW X3 HEATED SEAT BURNED HOLE THROUGH SEAT. IF HEATED SEAT IS TURNED ON, VISIBLE SPARKS OR FIRE WILL COME THROUGH HOLE. HOLE IS DIRECTLY BELOW DRIVER'S LEFT THIGH. BMW HAS ISSUED A RECALL FOR OTHER MODELS, BUT NOT THE X3. THE X3 IS SUSCEPTIBLE TO THE SAME ISSUE.

NHTSA ID

10852535

Incident

Mar 27, 2016

Mileage

110,000 mi

MY 2007 BMW X3'S DRIVER SIDE SEAT HEATER OVERHEATED WHILE I WAS DRIVING AND BURNT MY THIGH. I REACTED TO THE BURN AND ALMOST RAN OFF THE ROAD. WHEN I STOPPED I FOUND A BLACK BURNED SPOT ON MY SEAT. FROM MY RESEARCH IT SEEMS THIS HAS BEEN A COMMON PROBLEM WITH THIS MODEL. I THINK THE COMPANY SHOULD HAVE TO FIX THIS PROBLEM BEFORE SOMEONE IS HURT BADLY.

NHTSA ID

10826090

Incident

Nov 1, 2015

Mileage

107,000 mi

DUE TO COLD WEATHER, ENGAGED THE DRIVER SIDE SEAT HEATER. NOTICED A SHARP PAIN IN MY LEG AND THEN BEGAN TO SMELL AND SEE SMOKE. FORTUNEATLY, I WAS QUICKLY ABLE TO REALIZE THE SEAT HEATER APPEARED TO HAVE A SHORT IN IT, AND TURNED OFF BEFORE BURNING THROUGH THE LEATHER AND SETTING MY CLOTHS ON FIRE. I WILL BE CONTACTING MY LOCAL BMW DEALERSHIP TO SEE WHAT, IF ANYTHING THEY ARE WILL TO DO. I FEEL THERE SHOULD BE A RECALL BEFORE SOMEONE IS SERIUOSLY HURT OR KILLED. THE ENGINE WAS IDLING WHEN SEAT HEATER WAS ON. I WAS BACKING OUT OF DRIVEWAY AND DRIVING DOWN STREET WHEN I NOTICED. IF I WOULD HAVE HAD SEAT HEATER ON AND THEN STEPPED AWAY FROM VEHICLE AS IT WAS WARMIMG UP, I AM CONFIDENT THE DRIVER SEAT WOULD HAVE CAUGHT ON FIRE OR AT LEAST SEVERLY DAMAGED IT.

NHTSA ID

10821939

Incident

Jan 21, 2016

Mileage

147,000 mi

WHILE DRIVING THIS MORNING THE DRIVERS SIDE HEATED SEAT WAS IN USE SINCE IT WAS COLD OUTSIDE. I BEGAN TO SMELL THE ODER OF SOMETHING BURNING AND MY LEFT LEG FELT EXTREMELY WARM. NOT KNOWING WHAT WAS BURNING I TURNED OFF MY HEATED SEAT AND MY PASSENGERS SEAT WHICH WAS OCCUPIED. I ALSO TURNED OFF THE VEHICLE HEATER AND DEFROSTERS. UPON ARRIVAL AT MY DESTINATION I FOUND THAT THE DRIVERS SEAT HAD TWO BURN MARKS JUST ABOVE THE ELECTRIC SEAT CONTROLS WHERE MY LEG WAS AS I WAS POSITIONED WHILE DRIVING.

NHTSA ID

10821338

Incident

Jan 20, 2016

Mileage

131,154 mi

THE CAR IS EQUIPPED WITH SEAT HEATERS. ONE OF THE HEATING ELEMENTS FAILED, OVERHEATED AND BURNED THROUGH THE SEAT SURFACE. IN DOING RESEARCH, THIS APPEARS TO BE A PROBLEM WITH THE VEHICLES. BMW DID DO A RECALL ON THE X5, BUT DOES NOT SHOW A RECALL ON THE X3. ON VARIOUS SITES, THIS ISSUE HAS OCCURRED MANY TIMES WITH OWNERS, SOME WITH THE VEHICLE CATCHING ON FIRE. I FOUND COMPLAINTS ON THE FOLLOWING SITES; CARCOMPLAINTS.COM, BIMMERFEST.COM AND ARFC.ORG. JUST ON CARCOMPLAINTS, THIS COMPLAINT IS SHOWN 23 TIMES; MADBURY, NH, PORTLAND, OR, WESTFIELD, IN, DERWOOD, MD, TAMPA, FL, ANNAPOLIS, MD, LOUISVILLE, KY, BERGENFIELD, NJ, HOLDERNESS, NH, LIBERTY TOWNSHIP, OH, LAUREL, MD, NOVI, MI, CROMWELL, CT, PRAIRIE VILLAGE, KS, HILLSBOROUGH, NC, DALY CITY, CA, ALEXANDRIA, VA, SAGINAW, TX, BETHESDA. MD, PITTSBURG, PA, SELAH, WA. SAME ISSUE WITH EACH. BMW OF NORTH AMERICA WAS CONTACTED AND THEIR RESPONSE WAS "IT'S A PART OF WEAR AND TEAR....NO OFFER TO ASSIST" FROM BMW NA. YET, THE ISSUE HAS CONTINUED TO ARISE AND BMW NA DID REPLACE THE HEATER ELEMENT AND SEAT SURFACE IN SOME INSTANCES, MAKING THE REPLACEMENT A MATTER OF PREFERENCE OR DISCRIMINATION, OR DEALER'S OPINION OF THE CAR OWNER VERSUS CORRECTING THE MANUFACTURING/DESIGN DEFECT PROBLEM. I WOULD REQUEST THE ASSISTANCE OF NHTSA TO REVIEW THIS MATTER AND PROTECT THE PUBLIC FROM HAZARDOUS OVER-HEATING/ FIRE THREATS. I WAS FORTUNATE TO HAVE BEEN JUST GETTING INTO THE VEHICLE AND SMELL THE BURNING LEATHER AND TURNED OFF THE SEAT HEATING SYSTEM BEFORE A FIRE COULD OCCUR.

NHTSA ID

10810681

Incident

Nov 27, 2015

Mileage

125,000 mi

WHILE DRIVING SMELLED SOMETHING BURNING AND ALSO REALIZED MY UPPER LEG WAS IN PAIN. TURNED OFF THE SEAT WARMER AND INVESTIGATED AFTER REACHING MY DESTINATION. THERE WAS A SCORCH MARK IN THE SEAT NEAR THE BOTTOM LEFT BOLSTER. LUCKY THIS DIDN'T CAUSE A FIRE OR BODILY INJURY. *TR

NHTSA ID

10676948

Incident

Jan 19, 2015

Mileage

68,000 mi

EXPERIENCING RECURRENT ELECTRICAL ISSUES INCLUDING MULTIPLE EPISODES OF COMPLETE LOSS OF ENGINE POWER, POWER STEERING, AND POWER BRAKING WHILE DRIVING AT 15-25 MPH. THIS INCLUDES AN EPISODE OF THE VEHICLE'S ENGINE CUTTING OFF WITHOUT WARNING DURING A TURN ON A BUSY STREET RESULTING IN IMMEDIATE LOSS OF POWER STEERING AND BRAKES, NEARLY RESULTING IN A HEAD-ON COLLISION. VEHICLE WILL RESTART IMMEDIATELY AND WITHOUT DIFFICULTY AFTER INCIDENT OCCURS. VEHICLE HAS ALSO EXPERIENCED MULTIPLE EPISODES OF A BATTERY DRAWING DOWN VOLTAGE AND NON-START IN THE MORNING DESPITE A NEW AND FULLY CHARGED BATTERY. BATTERY HAS BEEN REPLACED AND PROBLEM PERSISTED. SOFTWARE WAS UPDATED YET PROBLEM CONTINUES TO PERSIST. NO ISSUES FOUND BY MECHANIC. *TR

NHTSA ID

10633069

Incident

Aug 16, 2014

Mileage

89,000 mi

I PURCHASED THE VEHICLE ON FEBRUARY 07, 2014 AND WHILE DRIVING HOME FROM WORK MY VEHICLE STARTED JERKING. IT WOULD JERK REALLY HARD AND WHEN YOU WOULD TRY TO STOP BY PRESSING ON THE BRAKE THE VEHICLE WOULD JERK HARDER AS IF IT IS ABOUT TO BREAK DOWN. THE SECOND TIME WAS IN APRIL, I BELIEVE THE 5TH I WAS HAVING THE SAME PROBLEM AND THEN SEVERAL WARNING LIGHTS CAME ON. I CALLED THE DEALERSHIP AND BROUGHT THE CAR IN. AS SOON AS THE SERVICE ADVISOR CHECKED ON THE VEHICLE SHE SAID THE CAR IS NOT DRIVABLE AND HOW IT IS UNSAFE TO DRIVE. THERE WAS ANOTHER PROBLEM WITH THE VEHICLE. I BROUGHT THE VEHICLE IN MAY FOR AN OIL CHANGE BUT WHEN I WAS DRIVING THE VEHICLE TOWARDS THE END OF JUNE IT SAID I WAS REALLY LOW ON OIL. I WENT TO TURN THE VEHICLE IN AND IT WOULD NOT START. *TR

NHTSA ID

10611325

Incident

Feb 18, 2014

Mileage

70,000 mi

23 MONTH OLD TODDLER GAINED ACCESS TO VEHICLE KEYS AND LOCKED HIMSELF IN WITH THE REMOTE KEY. AFTER SEVERAL ATTEMPTS OF HIM TRYING TO OPEN THE DOORS WITH THE DOOR LEVERS, THEY WOULD NOT OPEN. WE HAD A LOCK SMITH ATTEMPT TO UNLOCK THE DOORS BY PUSHING THE DOOR LOCK/UNLOCK BUTTON LOCATED ON THE UPPER CENTER CONSOLE, BUT THIS ALSO DIDN'T UNLOCK THE DOORS. THE DRIVER SIDE DOOR FINALLY OPENED AFTER PUSHING THE CENTER LOCK/UNLOCK BUTTON AND THEN PULLING ON THE DOOR LEVER TWO TIMES TO ACTUALLY BE ABLE TO UNLOCK AND OPEN THE DRIVER DOOR. THIS ENTRY SYSTEM REQUIRES THE USE OF ELECTRICS PRIOR TO THE MECHANICAL SYSTEM BECOMING ACTIVE. THIS SITUATION COULD BE VERY DANGEROUS DURING HIGH TEMPERATURE DAYS IF A PERSON IS LOCKED INSIDE AND DANGEROUS IN THE EVENT OF AN ESCAPE IF THE ELECTRIC SYSTEM FAILS WITH THE DOORS IN THE LOCKED POSITION. *TR

NHTSA ID

10550286

Incident

Oct 30, 2013

Mileage

67,698 mi

TL* THE CONTACT OWNS A 2007 BMW X3. THE CONTACT STATED THAT WHILE DRIVING WITH THE HEATED SEAT WARMER ACTIVATED, THE CONTACT SMELLED A BURNING ODOR. THE HEATED SEAT WARMER HAD BURNED A HOLE THROUGH THE DRIVER'S SEAT AND THE CONTACT'S PANT LEG, BURNING THE CONTACT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 96,000 AND THE CURRENT MILEAGE WAS 100,000.

NHTSA ID

10549539

Incident

Sep 1, 2012

Mileage

96,000 mi

TL* THE CONTACT OWNS A 2007 BMW X3. THE CONTACT STATED THAT THE BATTERY AND BATTERY CABLES FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS ADVISED THAT THE BATTERY CABLE CONNECTERS NEEDED TO BE REPLACED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE UNKNOWN. *TR

NHTSA ID

10512977

Incident

Apr 9, 2012

DRIVING VEHICLE NOTICED A BURNING SMELL, AT FIRST THOUGHT IT WAS COMING FROM OUTSIDE OF CAR, THEN WHILE IN HEAVY TRAFFIC AND UNABLE TO PULL OVER FELT A BURNING PAIN ON THIGH. IMMEDIATELY TURNED OFF SEAT WARMER AND TRIED TO PULL OVER. FOUND THAT DRIVERS SIDE SEAT WARMER HAD BURNT A HOLE THRU THE LEATHER SEAT COVER AND BURNED MY PANTS. THIS COULD HAVE VERY EASILY CAUSED A WRECK! *TR

NHTSA ID

10504294

Incident

Mar 8, 2013

Mileage

78,653 mi

I HAD CAR HEATING SYSTEM ON AND FELT SOME THING VERY HOT UNDER MY THIGH. I GOT DOWN TO INSPECT AND FOUND A HOLE IN THE CAR SEAT. I PUT OFF THE HEATING SYSTEM TO REACH HOME SAFELY. I HAVE SENT PICTURES AND MY COMPLAINT TO BMW AG AND BMW USA. *TR

NHTSA ID

10489201

Incident

Dec 17, 2012

Mileage

150,000 mi

TURNED ON HEATED SEAT ON DRIVER'S SIDE. AFTER APPROXIMATELY 2 MINUTES, FELT BURNING ON LEFT SIDE OF SEAT. TURNED OFF THE HEATED SEAT, TURNED ON THE LIGHT AND THE SEAT WAS SMOKING SUBSTANTIALLY. A SMALL HOLE WAS BURNED THROUGH THE LEATHER SEAT (ABOUT THE SIZE OF A DIME) AND THROUGH MY PANTS. I HAVE A SMALL RED MARK ON THE TOP OF THE BACK OF MY LEG. THE VEHICLE SMELLS LIKE SMOKE. LUCKILY, I WAS IN THE DRIVEWAY WHEN THIS HAPPENED OR AN ACCIDENT MIGHT HAVE OCCURRED. VERY CONCERNING AND WILL LIKELY BE A COSTLY REPAIR. HAVE NOTED SEVERAL OTHER SIMILAR INCIDENTS REPOTED ON-LINE. *TR

NHTSA ID

10487290

Incident

Dec 4, 2012

Mileage

87,000 mi

DRIVER'S SIDE SEAT HEATER HAS MALFUNCTIONED AND HAS BURNT THE LEATHER AND CAUSED DISCOMFORT WHILE DRIVING. HEAVY BURNT SMELL IN THE CABIN RESULTED FROM USING THE SEAT HEATER. *TR

NHTSA ID

10442472

Incident

Dec 15, 2011

AFTER MULTIPLE ATTEMPTS TO REMEDY THE SITUATION, BMW HAS BEEN UNABLE TO RESOLVE THE TRANSMISSION AND THE INTERMITTENT LOSS OF POWER AND MOST RECENTLY "LIMP-HOME" MODE OCCURRENCE ASSOCIATED WITH THE DRIVETRAIN ON THE 2007 BMW X3. THE SYMPTOMS 1ST PRESENTED ITSELF AS A LOSS OF POWER FROM A START. UPON PRESSING THE ACCELERATOR, THE VEHICLE DID NOT RESPOND AND THEN RESPONDED WITH A SURGE OR LURCHING FORWARD. THIS MAKES FOR UNPREDICTABLE AND DANGEROUSLY ERRATIC VEHICLE PERFORMANCE. AFTER MULTIPLE VISITS (+4) AND MULTIPLE COMPLAINTS ALONG WITH THE SOUND OF GEAR OR DIFFERENTIAL NOISE, THE DEALERSHIP FINALLY DID SOME TYPE OF ECU UPDATE THAT APPEARED TO RESOLVE THE PROBLEM. THE NOISE NEVER SUBSIDED AND RECENTLY THE CAR WAS INOPERABLE FORCING A TOW AFTER UPON PRESSING THE ACCELERATOR THE VEHICLE WENT INTO TRANSMISSION LIMP-MODE. AS USUAL, THE SYMPTOMS "CAN'T BE DUPLICATED" ONCE CODES ARE CLEARED YET THE ECU IS THROWING MULTIPLE CODES FOR TRANSMISSION LIMP-MODE AND CODE 56BE FOR CLUTCH GEARS 2 AND 6. I BELIEVE THAT THIS IS A VERY DANGEROUS SITUATION TO EITHER PRESS THE ACCELERATOR AND FOR IT TO BE NON-RESPONSIVE THEN HAVE A DELAYED VEHICLE SURGE NOT PROPORTIONAL TO THE INPUT AND TIMING OF THE ACCELERATOR DEPRESSION AND/OR PRESS THE ACCELERATOR AND EXPERIENCE SIGNIFICANTLY CURTAILED VEHICLE POWER DUE TO THE "LIMP-HOME" CONDITION. THIS HAS BEEN A RECURRING ISSUE SINCE THE PURCHASE OF THE VEHICLE ON 5/31/2009.

NHTSA ID

10383489

Incident

Feb 26, 2010

Mileage

21,000 mi

BMW X3 NEEDS NEW COMPUTER SYSTEM DUE TO WATER DAMAGE ALLEGEDLY EMANATING FROM A CLOGGED DRAIN IN THE SUNROOF. NEW COMPUTER COSTS APPX $2,000. DEALER AND BMW SAY THE DRAIN CAN'T BE SEEN OR ACCESSED BY OWNER AND IT ISN'T CLEANED AS PART OF ANY SERVICING. CLEAR DESIGN FLAW. I KNOW OF OTHERS WHO HAVE HAD THE SAME SITUATION AND BMWS RESPONSE IS TO TRY AND FILE AN INSURANCE CLAIM. *TR

NHTSA ID

10259809

Incident

Feb 12, 2009

Mileage

30,000 mi

TL*THE CONTACT OWNS A 2008 (NA) BMW X3. THE CONTACT STATED THAT THE BRAKE LIGHTS ILLUMINATED AUTOMATICALLY SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR SERVICE, BUT THEY FOUND NO FAILURES. THE LIGHT ILLUMINATED AGAIN AND THE CONTACT WAS ABLE TO RESET THE SYSTEM BY TURNING OFF THE VEHICLE. THE LIGHT ILLUMINATED AGAIN AND REMAINED LIT. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE ELECTRICAL SWITCH FAILED. IN ADDITION, THE BRAKES FAILED WHILE DRIVING AT AN UNKNOWN SPEED. THE CONTACT DROVE ONTO A CURVE AND CRASHED INTO A TREE. THERE WERE NO INJURIES. THE GEAR SHIFTER FAILED AND STUCK TO THE FLOOR WHEN IT WAS PULLED. THE TRANSMISSION IS ALSO FAILING. DURING ACCELERATION, THE VEHICLE PULLS BACKWARDS VIOLENTLY AND THE CONTACT'S HANDS RELEASED THE STEERING WHEEL. THE INSTRUMENT PANEL INDICATORS ALSO ILLUMINATE. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT NOTHING WAS WRONG WITH THE VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE WAS 7,300 AND THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10253940

Incident

Nov 20, 2008