2015 BMW X3 Engine Problems

While driving under medium acceleration, vehicle made a loud popping noise and engine power was severely reduced. Drivetrain warning light immediately appeared and said vehicle could be driven but at reduced power and needed to be serviced soon as possible. At highway speeds on a major interstate, this created several close calls being struck by traffic while trying to reach a safe area on shoulder. On site inspection revealed the plastic turbo charge pipe had blown away from the throttle body. Pieces of plastic and metal were found in engine bay and under vehicle. Vehicle was driven to nearby residence and towed to closest suitable garage for more detailed assessment and repair. Facility confirmed the Air Duct, BMW part number 13717604033 had failed. Repair made costing approximately $825 US dollars.

NHTSA ID

11743975

Incident

Jun 5, 2026

The contact owns a 2015 BMW X3. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The check engine warning light was illuminated, and the "Service Engine Soon" message was displayed on the instrument panel. The vehicle was taken back to the residence. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 140,000.

NHTSA ID

11721744

Incident

Mar 3, 2026

Mileage

140,000 mi

Our vehicle alerted us to over heating and to pull over immediately. Our car then stopped running. We had it towed and was told there was an issue with the water pump sensor and corrosion issues. They alerted us that there was a recall for these issues on our vehicle. We researched and found this to be true. When I contacted BMW they stated our vin number was not part of the recall but our vehicle match the exact models listed in the recall. We took it to the dealership and they repaired it for $2500 and the reason for the repair was the exact reason for the recall. Spoke with BMW again regarding this and they said if our vin was not on the recall list there was nothing they could do. I would think when your vehicle make and model matches the recall and the issues are the same you would be part of the recall no matter the vin number. I would like for this to be reviewed and see if we can get a reimbursement from bmw for the charges we paid out of pocket for an issue that should have been covered by the recall. The recall form attached is one my friend received who has the exact same car we have. The other documents are the service invoice and verification of our payment. Thank you!

NHTSA ID

11706812

Incident

Sep 24, 2025

The contact owns a 2015 BMW X3. The vehicle was repaired under NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM). The contact stated that on a separate occasion, the vehicle was taken to an independent mechanic for maintenance, and the contact was informed that the water pump had failed. The contact showed the independent mechanic the receipt for when the vehicle was repaired under the recall for the water pump. The contact was informed that the water pump was not replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 71,245.

NHTSA ID

11695924

Incident

Oct 27, 2025

Mileage

71,245 mi

Engine over heating alert issued and to pull over immediately. We had car towed to bmw dealership who stated it is water pump issue. This is a known issue for this make and model but recall not in effect for our vin. We are having the same issues as stated in recall for water pumps and temperature control issues. Just because our vin number is not associated with this recall they will not repair this issue unless we pay out of pocket. This is a known issue for our make and model of car and should be a covered expense by bmw. I have attached a link to the recall issues. Please review and respond accordingly. Thank you!

NHTSA ID

11692085

Incident

Sep 25, 2025

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

NHTSA ID

11672429

Incident

Jul 10, 2025

I received a recall notice from BMW in October 2024 for Recall 24V-608 involving a water pump electrical connector defect in my vehicle. According to the notice, this defect may cause liquid to drip onto the water pump’s electrical connector, potentially leading to a short circuit and, in rare cases, a fire. As of June 2025, nearly eight months later, there is still no remedy available. I have contacted BMW, and although they acknowledge the risk, they have not offered a loaner vehicle or any alternative despite the known fire hazard. I am concerned for my safety and do not feel comfortable continuing to drive a vehicle with a known, unresolved safety defect. I am submitting this complaint because I believe this delay is unreasonable and puts drivers at risk. The vehicle is currently operational, but the issue has not been fixed or properly addressed.

NHTSA ID

11669515

Incident

Oct 1, 2024

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. Additionally, the contact stated that the high-beam headlights failed to operate as needed; however, the vehicle was not diagnosed by the dealer. The vehicle was not repaired. The failure mileage was 18,000. VIN tool confirms parts not available.

NHTSA ID

11661419

Incident

Sep 15, 2024

Mileage

18,000 mi

The contact owns a 2015 BMW X3. The contact stated while driving 40-50 MPH, the check engine warning light illuminated and the message "Engine Overheated -Stop Vehicle Immediately" was displayed. The contact parked and turned off the vehicle. The vehicle was later restarted, but the message "Engine Overheated Stop - Vehicle Immediately" was displayed again. The contact stated that the vehicle stalled while driving. The vehicle was taken to an independent mechanic, who determined that the water pump had overheated and needed to be replaced. The vehicle was then towed to the dealer, who also determined that the water pump needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 63,000.

NHTSA ID

11660863

Incident

May 9, 2025

Mileage

63,000 mi

Vehicle was idle in the driveway next to my home and had not been driven since the night before. That morning, I started to smell what I thought was an electronic overheat of some sort in the house. When I inspected outside, the entire front end of the vehicle was on fire and the fire department needed to respond. The fire spread rapidly along the side of my home causing significant damage to my property as well as my neighbor's property. Our safety was put at risk because this fire could have occurred overnight while my wife, children and I were sleeping since the vehicle was not being operated at the time the fire happened. Representatives from my insurance company removed the vehicle and had it inspected at their facility, where they determined the vehicle to be a total loss as the entire front half of the car burned. Further, I did not receive notice of the known recall on my vehicle (with no know remedy as yet) which could be the cause of the fire, until a week after the incident occurred in October.

NHTSA ID

11656361

Incident

Oct 17, 2024

A low oil pressure signal flashed after regular service and my engine died as a result. No warning just died after years of regular service

NHTSA ID

11649418

Incident

Mar 20, 2024

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated there was an abnormal burning odor coming from the engine compartment. There were no warning lights illuminated. The dealer was contacted. The manufacturer was made aware of the issue. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 120,000. VIN tool confirms parts not available.

NHTSA ID

11646764

Incident

Aug 13, 2024

Mileage

120,000 mi

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11646491

Incident

Mar 5, 2025

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11645335

Incident

Oct 1, 2024

The contact owns a 2015 BMW X3. The contact received notification of the NHTSA Campaign to Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11644087

Incident

Feb 21, 2025

The contact owns a 2015 BMW X3. The contact was notified of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11638227

Incident

Oct 1, 2024

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving at approximately 30 MPH, there was a burning odor coming through the vents on the dashboard. The contact stated that she had not observed any warning lights being illuminated. The contact stated that the odor was intermittent but had been occurring for almost 4 months. The contact had stopped driving the vehicle out of concern that the vehicle might catch on fire. The dealer and the manufacturer were contacted. The contact was advised by the dealer that a second letter would be sent when parts were available for the recall repair. The failure mileage was approximately 50,000. VIN tool confirms parts not available.

NHTSA ID

11638040

Incident

Oct 1, 2024

Mileage

50,000 mi

The vehicle was driven 30 miles and parked at 9am weather was in the 30s-40s F. There were no check engine light, warning lights or abnormal readings on the gauges during the commute. At approximately noon, the vehicles was started and idled for approximately 20 min, it was not driven or moved from the parking spot, the car did not reach full operating temp. Smoke with a burnt plastic and electrical odor was noted emanating from under the hood while parked idling. The car was immediately shut off and exited. The driver went inside to get help. After returning to the vehicle in approximately 5minutes it was fully engulfed in flames. The fire department came to put out the fire. The vehicle is a total loss. The fire damaged adjoining vehicles and the property where it was parked. The vehicle was towed back to my residence where it remains for evidence. Upon review of BMW recall 24v-608 i performed an inspection of the water pump electrical connection plug and identified there is evidence of an electrical short on the plug which appears to have burnt through the connector prior to the major engine compartment fire. I have contacted BMW to file a complain and have followed up multiple times with the point of contact identified to me by BMW, but have been unsuccessful to date to establish communications with the BMW representative.

NHTSA ID

11636209

Incident

Jan 8, 2025

The contact owns a 2015 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was parked in the driveway, the contact noticed a coolant leak on the floor. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 125,000. VIN tool confirms parts not available.

NHTSA ID

11626787

Incident

Nov 18, 2024

Mileage

125,000 mi

The contact owns a 2015 BMW X3. The contact stated that while operating the vehicle, the engine overheated, and the messages "Low Coolant" and "Service Engine" were displayed. Upon inspection, the contact identified a damaged coolant hose causing coolant to leak onto several electrical wires within the engine compartment. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 120,000.

NHTSA ID

11626236

Incident

Oct 1, 2024

Mileage

120,000 mi

On 07/06/2024, I turned on my car and hear a loud ticking noise that ticked faster or slower when I tried to accelerate or decelerate the car. I turned the car off and towed it to a AAA mechanic. They reported my engine was damaged and I’ll need a new engine. I towed it to a second mechanic for a second opinion, at Jindal-Andre Automotive/Yellow Cab and the reported engine rod bearings failure on my BMW that has only 86,880 miles.

NHTSA ID

11605415

Incident

Jul 30, 2024

The contact owns a 2015 BMW X3. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The vehicle was towed to an independent mechanic where it was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 153,000.

NHTSA ID

11581747

Incident

Apr 1, 2024

Mileage

153,000 mi

Yesterday I was driving on the highway and in the fast lane, with only a break down lane off of the slow lane, the car just shut off. I was extremely lucky that I was able to coast over to the slow lane and then to the break down lane. I could have caused an accident or been hurt myself traveling at high speeds and the car just shutting off. I had the vehicle towed and was told the timing chain broke. This is a known issue and a class action lawsuit was filed against BMW and they settled outside of court. BMW has failed to admit they made a mistake when designing my vehicle and others like it that use the same engine and features. They have refused to admit this should be a recall. The timing chain is inside the engine and is very labor intensive for to be replaced or if it can be at all. There are so many BMW owners that have had this problem that it is known, the timing chain can be replaced before it breaks but once it breaks the entire engine has to be replaced. The only warning light I had was while it was happening. There was not pre-warning that I should take it to the shop and have it replaced. If there was, I would have had the work done! Now I am left with a totaled vehicle that isn't covered by insurance and BMW won't back their product and help in any way. I called BMW North America and several BMW dealerships, no one is willing to do anything. They are telling me I have too many miles on the vehicle. I brought the vehicle in to a BMW dealer (with 98k miles) for a noise and that it was shutting off. They said it was the battery. They replaced it and sent me on my way. Never mentioned the lawsuit or bad part. Now the timing belt has broken at 113k miles. BMW is supposed to be known for their longevity but they will not back their product.

NHTSA ID

11506007

Incident

Feb 6, 2023

NHTSA Recall Number 21V907 It has been over a year since I received notification that there was a recall on my vehicle. I have contacted BMW for this to be repaired several times, but the local dealer always says, "We're sorry, there aren't any parts available for your recall." This recall is NOT being performed in a timely manner and based on my interpretation of the recall notice that keeps appearing in my mailbox every few months, my car may burst into flames at any moment. I'm living in fear. Please help.

NHTSA ID

11497400

Incident

Dec 1, 2022

2015 BMW X3. CONSUMER WRITES IN REGARD TO BMW DESIGN DEFECTS. THE CONSUMER STATED THE DEALER INFORMED THE REPAIRS FOR THE VEHICLE REQUIRES BUYING A NEW ENGINE. THE CONSUMER STATED THE REPAIRS WERE MADE AT THE OWNERS COST BUT THEY WANT TO BE DISCUSS REIMBURSEMENT FOR REPAIRS.

NHTSA ID

11496044

Incident

Dec 5, 2022