2016 BMW X3 Problems

While driving on a two-lane 40 MPH road in the left lane the vehicle suddenly lost power, stopped in traffic, and displayed a transmission warning message. Multiple warning lights were "on" and the car would not restart. Additionally, the vehicle would not come out of "Park." Occupants needed to await police who stopped traffic in order for occupants to be able to exit the vehicle safely. The vehicle was towed to BMW of Atlantic City located at [XXX]. Technician found ground missing at EGS, inspected ground strap on transmission and found it severely corroded. Technician replaced ground strap and vehicle was repaired. Was advised by dealer service department that when this situation occurs, the only way to get the transmission into neutral in an emergency is to disconnect the transmission linkage under the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Key Details of BMW EGR Recall: • Affected Models: Primarily 2013-2018 BMW 328d/xDrive, 535d/xDrive, 740Ld, X3 xDrive28d, and X5 XDrive35d. • The Problem: The Exhaust Gas Recirculation (EGR) cooler may leak coolant internally, which can mix with soot to form flammable deposits, potentially leading to a Fire I was driving and my car started to smoke out of engine compartment I pulled over and waited called my husband and drove it back home. Took it to a shop and they are saying it’s my erg leaking internally and need it replaced along with the intake manifold. I looked up recalls and only the diesel one is on recall for the exact same issue,

While driving on a two-lane 40 MPH road in the left lane the vehicle suddenly lost power, stopped in traffic, and displayed a transmission warning message. Multiple warning lights were "on" and the car would not restart. Additionally, the vehicle would not come out of "Park." Occupants needed to await police who stopped traffic in order for occupants to be able to exit the vehicle safely. The vehicle was towed to BMW of Atlantic City located at [XXX]. Technician found ground missing at EGS, inspected ground strap on transmission and found it severely corroded. Technician replaced ground strap and vehicle was repaired. Was advised by dealer service department that when this situation occurs, the only way to get the transmission into neutral in an emergency is to disconnect the transmission linkage under the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM). The vehicle was taken to the dealer for the recall repair; however, the dealer refused to perform the recall repair and stated that since the vehicle was manufactured in Canada, the recall repair could not be performed. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2016 BMW X3. The contact stated that while driving 55 MPH and depressing the accelerator pedal, the vehicle stalled with the drive train warning light illuminated. A dealer was contacted. The vehicle was taken to a dealer where it was diagnosed and determined that the high-pressure and the pressure-regulating valves needed to be replaced. The high-pressure fuel pump was replaced three times. The contact stated that the failure had occurred on several occasions. The contact associated the failure with NHTSA Campaign Number: 21V586000 (FUEL SYSTEM, DIESEL); however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was 98,773.

The low-pressure fuel temperature/pressure sensor failed internally, causing diesel fuel to intrude via capillary action into the engine wiring harness and ultimately contaminate the Digital Diesel Electronics (DDE) control unit (ECU). The failed components (sensor, harness, DDE) are available for inspection upon request at BMW of Loveland, CO. My safety was put at risk in two primary ways: Engine Stalling Risk: The DDE is the engine control unit. As the fuel contaminated the electrical connections, the engine's reliability was compromised, creating a significant risk of sudden engine stalling while driving in traffic or at high speeds. Fire Hazard: The intrusion of diesel fuel—a combustible fluid—directly into the electrical wiring harness and the DDE created a clear fire hazard. Fuel near active electrical components poses a serious safety risk. Inaccurate Temperature Readings: The EGT (Exhaust Gas Temperature) sensor received incorrect readings due to the DDE/wiring issue, leading to potential engine damage due to excessively high exhaust temperatures. The problem has been confirmed by BMW of Loveland. The Service Director and their technical team identified the root cause in less than one day and confirmed it requires the replacement of the sensor, harness, and DDE. This was also validated by an internal BMW technical support case (TSARA). Gebhardt BMW failed to diagnose the issue correctly over three prior attempts starting in June 2023 through Aug 2025. Prior symptoms appeared over a period of months and included: Intermittent check engine light/MIL. Multiple, confusing diagnostic fault codes (related to air mass, charging pressure, and DPF efficiency). Increased frequency of DPF regeneration intervals.

We have had several occurrences of the following issue during the last several months. When slowing the vehicle down at a traffic light/stop with the goal of bringing the vehicle to a complete halt, as the vehicle decelerates to almost a stop with the foot firmly on the brake pedal, there have been several instances where the engine suddenly revs up and the vehicle lunges forward instead of stopping. It is an intermittent issue which is very hard to predict. It has occurred on flat roads, or going downhill, a couple of times with the air conditioner on. It's a split second lunge needing one to apply brakes even harder. Since at other times, this doesn't happen it's very concerning since we're questioning the reliability of the vehicle. It's a matter of chance that this may cause rearending the vehicle ahead. Thankfully, that hasn't happened but have come within a hair of happening.

MY EMERGENCY BRAKE KEEPS MALFUNCTIONING, I HAVE BEEN UNABLE TO USE THEM FOR ABOUT 3 MONTHS NOW. ALSO STARTING AROUND 2/20/21 WHEN IM AT A RED LIGHT FOR MORE THAN A MINUTE AND THE LIGHT TURNS GREEN, MY TRANSMISSION GETS STUCK AND THE CAR WONT GO, A WARNING SIGN COMES ON. THEN I HAVE TO RE PUT IT IN DRIVE AND CAN GO.

While driving on a two-lane 40 MPH road in the left lane the vehicle suddenly lost power, stopped in traffic, and displayed a transmission warning message. Multiple warning lights were "on" and the car would not restart. Additionally, the vehicle would not come out of "Park." Occupants needed to await police who stopped traffic in order for occupants to be able to exit the vehicle safely. The vehicle was towed to BMW of Atlantic City located at [XXX]. Technician found ground missing at EGS, inspected ground strap on transmission and found it severely corroded. Technician replaced ground strap and vehicle was repaired. Was advised by dealer service department that when this situation occurs, the only way to get the transmission into neutral in an emergency is to disconnect the transmission linkage under the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The low-pressure fuel temperature/pressure sensor failed internally, causing diesel fuel to intrude via capillary action into the engine wiring harness and ultimately contaminate the Digital Diesel Electronics (DDE) control unit (ECU). The failed components (sensor, harness, DDE) are available for inspection upon request at BMW of Loveland, CO. My safety was put at risk in two primary ways: Engine Stalling Risk: The DDE is the engine control unit. As the fuel contaminated the electrical connections, the engine's reliability was compromised, creating a significant risk of sudden engine stalling while driving in traffic or at high speeds. Fire Hazard: The intrusion of diesel fuel—a combustible fluid—directly into the electrical wiring harness and the DDE created a clear fire hazard. Fuel near active electrical components poses a serious safety risk. Inaccurate Temperature Readings: The EGT (Exhaust Gas Temperature) sensor received incorrect readings due to the DDE/wiring issue, leading to potential engine damage due to excessively high exhaust temperatures. The problem has been confirmed by BMW of Loveland. The Service Director and their technical team identified the root cause in less than one day and confirmed it requires the replacement of the sensor, harness, and DDE. This was also validated by an internal BMW technical support case (TSARA). Gebhardt BMW failed to diagnose the issue correctly over three prior attempts starting in June 2023 through Aug 2025. Prior symptoms appeared over a period of months and included: Intermittent check engine light/MIL. Multiple, confusing diagnostic fault codes (related to air mass, charging pressure, and DPF efficiency). Increased frequency of DPF regeneration intervals.

the passenger restraint system malfunction error came out several times since last month.

The contact owns a 2016 BMW X3. The contact stated that there was a message that the passenger’s side restraint had malfunctioned. The dealer had been contacted to schedule an appointment; however, the vehicle had not been taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 107,000.

the passenger restraint system malfunction error came out several times since last month.

PASSENGER AIRBAG POSSIBLE FAILURE. PASSENGER AIRBAG HAS BEEN TURNED OFF BY THE VEHICLE.

A VERY DANGEROUS AND CATASTROPHIC SITUATION IS CREATED WHEN USING THE START/STOP FEATURE. WHEN STOPPED AT A TRAFFIC LIGHT OR STOPPED IN STOP AND GO TRAFFIC ON THE HIGHWAY THIS FEATURE FAILS. ONCE THIS FEATURE IS ENGAGED WHEN THE VEHICLE IS STOPPED WHEN THE ACCELERATOR IS PUSHED TO START AGAIN THE VEHICLE GOES INTO PARK INSTEAD OF ACCELERATING. THIS PRESENTS A VERY DANGEROUS AND POTENTIALLY CATASTROPHIC SITUATION BECAUSE YOU MAY BE MAKING A MANEUVER BY ACCELERATION TO SWITCH LANES OR SOMETHING SIMILAR AND THE CAR FAILS AND GOES INTO PARK AND DOES NOT MOVE. PERILLO BMW PERFORMED UNSUCCESSFUL SERVICE ON THIS APPROXIMATELY FOUR WEEKS AGO. THIS DID NOT FIX THE PROBLEM. PERILLO PERFORMED SERVICE AGAIN FOR THE SAME ISSUE TWO WEEKS AGO. MY HOPE IS THAT THIS IS A PERMANENT FIX BECAUSE TO NOT TAKE THIS PROBLEM SERIOUSLY AND LEAVE IT TO CHANCE THAT THIS MAY OCCUR WITH SEVERE CONSEQUENCES. THIS IS A SAFETY ISSUE THAT I THINK THE NHTSA SHOULD ADDRESS DIRECTLY WITH BMW. SPECIFICALLY- 1. THE CAR COMES TO A COMPLETE STOP AT A TRAFFIC LIGHT, STOP SIGN OR IN STOP AND GO TRAFFIC ON THE HIGHWAY. 2. THE START/STOP FEATURE IS ENGAGED 3. WHEN THE ACCELERATOR IS PUSHED TO GO AGAIN THE CAR IMMEDIATELY GOES INTO PARK AND THE STEERING WHEEL LOCKS. 4. TO GO AGAIN, THE BREAK MUST BE PRESSED AND THE GEAR SHIFTED MANUALLY INTO DRIVE. PRIOR TO BMW SERVICING THE VEHICLE THIS HAS OCCURRED MORE THAN 20 TIMES IN A THREE-MONTH PERIOD. THERE IS ABSOLUTELY NO CHANCE THAT THE DRIVER ACCIDENTALLY PRESSED THE PARK WHILE STOPPED. THE DRIVER PURPOSELY DOES NOT KEEP THEIR HANDS ON THE SHIFT GEAR.

2016 BMW X3. CONSUMER WRITES IN REGARDS TO VEHICLE SUDDEN ACCELERATION AND EPISODES OF STEERING WHEEL BRIEFLY UNRESPONSIVE WHEN MERGING INTO TRAFFIC. *SMD THE CONSUMER STATED THE VEHICLE WOULD SUDDENLY ACCELERATE WHILE THE VEHICLE WAS MOVING AND STOPPED WITH THE DRIVER'S FOOT ON THE BRAKE. *JS

The contact owned a 2016 BMW X3. The contact received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the dealer had previously performed an engine inspection and pressure test for the coolant system due to coolant loss with the low coolant warning light illuminated. The contact had added a quart of coolant. The contact stated that while his wife was driving at an undisclosed speed, the vehicle lost motive power with a loss of power warning message displayed. The contact's wife was able to pull over on the shoulder of the roadway and noticed there was smoke coming from underneath the hood before it caught fire. The contact's wife was able to safely exit the vehicle. The fire department arrived on the scene and was able to extinguish the fire. Police and fire department reports were filed. The vehicle was towed to a tow yard and then to the contact's residence. The dealer was made aware of the failure and referred the contact to the manufacturer. The vehicle was not yet deemed totaled by the insurance company. The manufacturer was made aware of the failure and informed the contact that an inspector would perform an inspection to determine the cause of the fire. The failure mileage was approximately 88,500. VIN tool confirms parts not available.

VALVE STEM BODY FAILED DURING TIRE INFLATION. IT IS NOT POSSIBLE TO INFLATE TIRE TO SPEC. POSSIBLE RAPID AIR PRESSURE LOSS WHILE DRIVING. BMW OF SAN FRANCISCO REFUSED TO REPAIR UNDER EXISTING MANUFACTURED WARRANTY.

The contact owns a 2016 BMX X3. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The RPM was elevated; however, the vehicle failed to respond as intended. The vehicle was driven to the shoulder of the road. No warning lights were illuminated. The vehicle was towed to an independent mechanic and was diagnosed with Electronic Power Steering Control Unit failure. The contact was informed that the Electronic Power Steering Control Unit needed to be replaced. The vehicle was not repaired. The contact was advised to tow the vehicle to the dealer. The vehicle was towed to the dealer, where the failure was confirmed as an Electronic Power Steering Control Unit failure. The contact referenced an unknown recall with a similar description; however, the VIN was not under recall. The contact was informed that the repair was not covered under the recall. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 70,000.

WHILE APPROACHING A STOPLIGHT, BRAKED, THEN WENT TO ACCELERATE AND THE VEHICLE TOTALLY SHUTDOWN AND STOPPED WHILE DRIVING IN TRAFFIC. THIS WAS A CATASTROPHIC FAILURE, WHICH COULD HAVE KILLED BOTH OCCUPANTS OF THIS VEHICLE. THE CHECK ENGINE LIGHT WAS ACTIVATED. UPON ATTEMPTING TO RESTART THE VEHICLE TO MOVE IT OUT OF THE WAY OF TRAFFIC, THE VEHICLE WOULD NOT START. THE TRANSMISSION WOULD NOT BE PLACED IN NEUTRAL NOR COULD THE PARKING BRAKE BE DISENGAGED SO THE VEHICLE COULD BE PUSHED OUT OF THE WAY OF TRAFFIC. THIS WAS A VERY DANGEROUS SITUATION. THIS VEHICLE IS DANGEROUS AND SHOULD BE TAKEN OFF OF THE MARKET.

The liftgate opened while the car was being driven down the road.

2016 BMW X3 XDRIVE28 I I PULLED INTO A FRIEND'S DRIVEWAY AND APPLIED THE BRAKES APPROXIMATELY 2 FEET FROM THE CLOSED GARAGE DOOR. MY CAR "LEAPT " INTO THE SIDE OF THE HOUSE, THEN CAREENED INTO THE GARAGE DOOR. THE CAR ACCELERATED WITH SUCH FORCE THAT BOTH AIRBAGS WERE DEPLOYED. I AM SURE THAT I DID NOT HIT THE ACCELERATOR BY ACCIDENT. AT THE CLOSE PROXIMITY TO THE GARAGE I COULD NOT HAVE ACCELERATED TO CAUSE SUCH A VIOLENT CRASH THAT DEPLOYED THE AIRBAGS. MY CAR WAS DECLARED A " TOTAL LOSS ". THIS WAS ONE OF THE MORE FRIGHTENING EXPERIENCES OF MY LIFE. IT ALL HAPPENED IN A SPLIT SECOND. I AM THANKFUL THAT I WAS NOT IN TRAFFIC.

BMW TECH LOOKED TIRES OVER AND FOUND REAR TIRES WORN THROUGH INNER EDGE TO THE POINT THAT IT APPEARS ONLY THE INNER LAYER OF RUBBER IS HOLDING THE TIRE TOGETHER. FULL SEPARATION BETWEEN THE SIDEWALL AND FACE OF THE TIRE ON BOTH REAR TIRES IN SOME SPOTS. REAR TIRES ARE DANGEROUS AND SHOULD NOT BE USED ON THE ROAD OR HIGHWAY UNTIL REPLACED. THE CAR HAS ONLY 36,000 MILES AND THE REST OF THE TIRE HAS TREAD. WE FEEL THIS IS WELL BEYOND NORMAL WEAR AND IT APPEARS THAT IS A DEFECT. I'VE ATTACHED PICTURES OF THE 2 REAR TIRES.

TIRE IS A RUN FLAT TYPE OF TIRE AND THE WEAR OF ALL FOUR TIRES WAS SEVERE ON THE INSIDE OF TIRE WHILE TREAD ACROSS THE REST OF THE TIRE WAS STILL SATISFACTORY. REAR TIRE TREAD STARTED SEPARATING AND THE VEHICLE HAD TO BE TAKEN OFF THE ROAD DUE TO THE SEVERITY OF THE TREAD SEPARATION. CONTINUED OPERATION OF THE VEHICLE WOULD HAVE RESULTED IN COMPLETE DESTRUCTION OF THE TIRE AND LOSS OF CONTROL OF THE VEHICLE INTERNET RESEARCH INDICATES THIS TO BE A "COMMON" PROBLEM WITH THIS VEHICLE AND THE MANUFACTURER REFUSES TO RECOGNIZE THE DANGER TO THE PUBLIC.

BOTH HEADLIGHT LENSES ARE CRACKING AND PITTED ON THE INSIDE OF THE LENSES. VEHICLE IS UNDER WARRANTY AND HAS BEEN AT THE DEALER ON TWO SEPARATE OCCASIONS. THE 2ND TIME AT THE DEALER THEY HAD A REGIONAL TECH MANAGER CHECK THE HEADLIGHTS.THE CONCLUSION HE CAME TO IS THAT THE PITTING AND CRACKING IS ON THE OUTSIDE AND THEREFORE NOT A DEFECT. WELL, A CHILD COULD SEE AND TELL, EVEN BY TOUCHING THE FACE OF THE HEADLIGHTS THAT THIS IS ON THE INSIDE OF THE PLASTIC HEADLAMP ASSEMBLIES. I BELIEVE THIS IS A SERIOUS SAFETY ISSUE AT NIGHT, AS WELL AS A CLEAR MATERIALS DEFECT. I BELIEVE THAT BMW DOES KNOW THAT THEY ARE DEFECTIVE, AND SIMPLY DOESN'T WANT TO PAY FOR THE HEADLIGHTS. THEY SAID I COULD REPLACE THEM MYSELF IF I WANTED TO AT A COST OF $5000.00.