2022 BMW X5 Problems

The high-voltage battery system (this is a plug-in hybrid) began intermittently displaying a "battery not properly charging" warning approximately 6 months ago; the issue would resolve after plugging in and charging. On July 14, 2026, while driving, the vehicle displayed a "critical battery failure - pull over immediately and drive slowly" warning. The driver pulled over and shut off the vehicle; the warning cleared and the car appeared to drive normally afterward. This warning recurred several times over the following weeks under the same pattern. On August 6, 2026, the same critical battery failure warning appeared while driving; this time steering feel and drivetrain response were abnormal, and the air conditioning and several electronic features stopped working. Our safety, and the safety of other drivers on the road, was put at risk by the sudden loss of full vehicle control while in motion. The vehicle has been at an authorized BMW dealership for inspection since August 7, 2026; a full diagnosis is pending. Dealer service staff independently remarked that two other BMW X-series plug-in hybrids came in that same morning with the identical warning and symptoms, suggesting this may be a widespread component defect rather than an isolated issue.

Over the last approximately 20,000 miles or so I've noticed a studder/shaking of the vehicle when turning and/or accelerating at slow speeds, in particular, while the car is cold (not warmed up). I change the transfer case fluid about 5,000 miles ago and the problem did not resolve. I now see that there is a class action lawsuit against BMW for known failure of the transfer case. I would like my problem noted for the record and hopefully action by BMW.

I took my 2022 BMW X5 xDrive 45e for concerns of shuddering at low speeds and tight turns under warranty. No warning messages on dashboard. I asked specifically what was causing the shuddering. BMW of Raleigh would not respond. But they found that the Transfer Case was affected so they flushed the oil and put an oil mixture replacement in. According to the most recent BMW service bulletin, the technician is only to put in DTF oil. The technician not only put in DTF oil but also an over-the-counter non-approved chemical additive. Reading the service bulletin, the Transfer Case is supposed to have a lifetime warranty. We were charged over $500 for this "oil change", but it was under warranty. Transfer Case failures can result in accidents on highways and other roadways and complete mechanical failure of vehicle.. The oil change did not fix the Transfer Case issue but extended out the vehicle so that it now falls out of warranty. A TC replacement will cost $10,000 or more out of pocket. TC issues is a known BMW issue since 2018. Lawsuit has begun w/thousands of plaintiffs all over USA w/ 2019-2025 BMWs because they refuse to acknowledge that they are at fault even though they continue to put out bulletins for this exact issue. BMW has made sure that Transfer Case is not on any warranty they offer.

I am writing to you as a loyal BMW owner to formally lodge a serious complaint regarding a technical safety failure in my BMW X5 and the subsequent dismissive treatment I received at an authorized service center in New York. The Incident Recently, while reversing, the Driving Assistance and Parking Assistant systems failed without warning. As a result, the vehicle collided with an object, causing damage to the rear bumper. This was not a result of driver negligence, but a direct failure of the safety technology that I trusted to protect my family. Service Center Negligence Upon visiting the service center to address this life-threatening defect, I was met with unacceptable indifference. The service advisor flatly refused to investigate the system failure, stating they would only perform a standard NYC Inspection. I was given a follow-up appointment for May 5th—forcing me to wait weeks to address a critical safety defect. Safety Concerns & Demand for Replacement As a father [XXX], I no longer feel safe operating this vehicle. The integrity of the safety modules has been compromised, and my confidence in this specific car is completely shattered. Repairing a bumper does not fix a failed safety system that could have caused a much more serious accident.And when I provide all of this evidence to BMW North America they Lay to me and asked me to take my vehicle without resolving the problem and the doesn’t care about my family safety INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The high-voltage battery system (this is a plug-in hybrid) began intermittently displaying a "battery not properly charging" warning approximately 6 months ago; the issue would resolve after plugging in and charging. On July 14, 2026, while driving, the vehicle displayed a "critical battery failure - pull over immediately and drive slowly" warning. The driver pulled over and shut off the vehicle; the warning cleared and the car appeared to drive normally afterward. This warning recurred several times over the following weeks under the same pattern. On August 6, 2026, the same critical battery failure warning appeared while driving; this time steering feel and drivetrain response were abnormal, and the air conditioning and several electronic features stopped working. Our safety, and the safety of other drivers on the road, was put at risk by the sudden loss of full vehicle control while in motion. The vehicle has been at an authorized BMW dealership for inspection since August 7, 2026; a full diagnosis is pending. Dealer service staff independently remarked that two other BMW X-series plug-in hybrids came in that same morning with the identical warning and symptoms, suggesting this may be a widespread component defect rather than an isolated issue.

Electronic Shifter goes out when exposed to moisture.. We had the vehicle detailed and it will not move after apparently some moisture got into the shift know that is located next to cup holders.. BMW will not warranty the part and acknowledge it is an issue.. Luckily we have an extended warranty that is covering the 2500.00 part

I took my 2022 BMW X5 xDrive 45e for concerns of shuddering at low speeds and tight turns under warranty. No warning messages on dashboard. I asked specifically what was causing the shuddering. BMW of Raleigh would not respond. But they found that the Transfer Case was affected so they flushed the oil and put an oil mixture replacement in. According to the most recent BMW service bulletin, the technician is only to put in DTF oil. The technician not only put in DTF oil but also an over-the-counter non-approved chemical additive. Reading the service bulletin, the Transfer Case is supposed to have a lifetime warranty. We were charged over $500 for this "oil change", but it was under warranty. Transfer Case failures can result in accidents on highways and other roadways and complete mechanical failure of vehicle.. The oil change did not fix the Transfer Case issue but extended out the vehicle so that it now falls out of warranty. A TC replacement will cost $10,000 or more out of pocket. TC issues is a known BMW issue since 2018. Lawsuit has begun w/thousands of plaintiffs all over USA w/ 2019-2025 BMWs because they refuse to acknowledge that they are at fault even though they continue to put out bulletins for this exact issue. BMW has made sure that Transfer Case is not on any warranty they offer.

While driving, the vehicle displayed a 'Drivetrain malfunction' warning on the dashboard and began jerking. I safely pulled over and turned off the vehicle. Immediately after stopping, there was a distinct, strong electrical burning smell coming from the engine compartment. The vehicle was inspected by an authorized BMW dealership. The dealer diagnosed a catastrophic failure of the starter motor. The vehicle's computer logged fault codes 21611A (excessive counter-torque), 21A511 (Start system: Timeout), and 216119 (Line disconnection). These codes confirm the starter motor suffered a severe electrical overload and thermal event. This premature failure and fire hazard identically matches the safety risks outlined in BMW's recent massive starter motor recalls (such as NHTSA Recalls 25V-636 and 26V-056), but my specific vehicle is currently excluded from those recall campaigns. The starter requires complete replacement due to this overheating damage

I was driving my 2022 BMW X5 on the highway at approximately 78 mph when the vehicle suddenly and unexpectedly applied the brakes without any obstruction or vehicle in front of me. A warning appeared instructing me to release the brakes while driving. This created a dangerous situation and could have caused a rear-end collision. The vehicle has approximately 34,000 miles. This appears to be a malfunction of the automatic emergency braking system. This happened on 2 seperate occasions.

The car accelerated itself when stopping at a red light. The brake was not working and accept the car forward instead.

On July 8, 2026, the vehicle unexpectedly stalled while I was driving in the middle lane on the I-95 highway, creating a safety concern. There was complete loss of engine power and low power to steering. The vehicle had to be towed to BMW of Peabody, Massachusetts. The vehicle had 30850 miles during the incident. During the inspection at service centre, I was informed that the safety fuse box and 12V auxiliary battery had failed which stalled the vehicle.

My relatively brand new BMW X5 with only 7,500 miles was parked in an enclosed parking garage with valet service. The car only had its warranty service about 7 weeks ago and was in fine condition. There were no issues with the suspension or steering. There was no accident and the car has never gone over a hard bump or pothole. The lower right front control arm snapped cleanly as if from metal fatigue as a valet attempted to retrieve my car. The car was rendered inoperable, and thankfully this accident did not occur on the road. The car was towed to the dealership where they informed me the damage would require $16k - $18k of repairs to the axle, steering column and a host of related systems.

The contact owns a 2022 BMW X5. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the rear of the vehicle. There was no warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the transfer case fluid needed to be replaced three separate times. The vehicle was repaired; however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed again and determined that the transfer case fluid needed to be replaced. The transfer case fluid was replaced; however, the failure persisted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 38,000.

The front Continental PremiumContact 6 tires, size 275/35ZR22, DOT [XXX] , developed abnormal and premature tread/shoulder failure. The condition included splitting, tearing, separation along the shoulder area, and exposed internal cords. I first raised concerns about the tire condition at about 20,000 miles. An alignment was performed at 20,142 miles, but the condition later worsened. One of the front tires deteriorated while the vehicle was being driven, creating a serious safety risk. The condition was documented with photographs and dashcam evidence. The vehicle was not safely drivable on the affected tire. The full set was later replaced based on BMW’s recommendation, at a cost of $2,358.75. A warranty/defect claim was submitted through the BMW / Dealer Tire / Continental process, but I did not receive a clear manufacturer-level inspection explanation or meaningful response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The high-voltage battery system (this is a plug-in hybrid) began intermittently displaying a "battery not properly charging" warning approximately 6 months ago; the issue would resolve after plugging in and charging. On July 14, 2026, while driving, the vehicle displayed a "critical battery failure - pull over immediately and drive slowly" warning. The driver pulled over and shut off the vehicle; the warning cleared and the car appeared to drive normally afterward. This warning recurred several times over the following weeks under the same pattern. On August 6, 2026, the same critical battery failure warning appeared while driving; this time steering feel and drivetrain response were abnormal, and the air conditioning and several electronic features stopped working. Our safety, and the safety of other drivers on the road, was put at risk by the sudden loss of full vehicle control while in motion. The vehicle has been at an authorized BMW dealership for inspection since August 7, 2026; a full diagnosis is pending. Dealer service staff independently remarked that two other BMW X-series plug-in hybrids came in that same morning with the identical warning and symptoms, suggesting this may be a widespread component defect rather than an isolated issue.

The electric A/C compressor on my 2022 BMW X5 xDrive45e (VIN [XXX] ) failed internally at approximately 59,000 miles, causing metal debris to circulate throughout the refrigerant system. The failed compressor and contaminated components are at BMW of Sterling (Sterling, VA) and available for inspection. This is a safety concern because the A/C refrigerant circuit provides thermal management for the high-voltage hybrid battery. BMW of Sterling's service advisor confirmed in writing that the A/C system is "a critical component of your vehicle's HV system," that there is no independent backup cooling system, and that the failure "can cause potential high voltage battery failures." Without active cooling, the HV battery is at risk of overheating, which could result in a thermal event. The failure was diagnosed and confirmed by BMW of Sterling. They categorized the repair as "EHV: FULLY ELECTRIC OR HYBRID VEHICLE DRIVETRAIN DIAGNOSTICS" with the complaint "HIGH VOLTAGE SYSTEM ERROR." The repair estimate is $11,356.59 and requires replacement of the compressor, condenser, all expansion valves, and a double system flush. BMW Service Information Bulletin SI B64 09 21 documents this exact failure pattern for the G05 X5 xDrive45e, and BMW created a dedicated repair kit (part 64 50 5 A5B 590) for it. This is my second major HV component failure. A battery cell replacement was performed under warranty in 2025. Both failures were confirmed by the dealership to be component defects unrelated to owner use. Prior to complete failure, a fan noise was present in the front driver's area for a period of time before it stopped, consistent with the compressor degrading before failing entirely. A high voltage system error was displayed. BMW NA (case #XXX) has declined warranty coverage despite the vehicle being within the 8-year/80,000-mile HV battery warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving the car on the middle lane on Northern State Parkway (Long Island, NY) West bound about 55mph. Near exit 26 suddenly my car was automatically moving towards to the right, steering wheel and brake were not working, car was completely out of control, it crossed the right lane and went out of the highway and suddenly stuck in the bushes and stopped. Luckily, there was no car on the right lane at that time. I did not hit anyone and no car hit me. Call automatically went to the police from my car. In short time police came and I came out of the car and found that left rear wheel broke from axel. I do regular service in BMW service center. This year I took to Rallye BMW service center one time in April and one time in August and I did complete servicing as their recommendation. My car is in Rallye BMW for over one and half month but I did not get any information from BMW what happened to my car. I called several times but from service center Mr. Anthony is telling that from BMW corporate one came yet to do inspection.

My relatively brand new BMW X5 with only 7,500 miles was parked in an enclosed parking garage with valet service. The car only had its warranty service about 7 weeks ago and was in fine condition. There were no issues with the suspension or steering. There was no accident and the car has never gone over a hard bump or pothole. The lower right front control arm snapped cleanly as if from metal fatigue as a valet attempted to retrieve my car. The car was rendered inoperable, and thankfully this accident did not occur on the road. The car was towed to the dealership where they informed me the damage would require $16k - $18k of repairs to the axle, steering column and a host of related systems.

My relatively brand new BMW X5 with only 7,500 miles was parked in an enclosed parking garage with valet service. The car only had its warranty service about 7 weeks ago and was in fine condition. There were no issues with the suspension or steering. There was no accident and the car has never gone over a hard bump or pothole. The lower right front control arm snapped cleanly as if from metal fatigue as a valet attempted to retrieve my car. The car was rendered inoperable, and thankfully this accident did not occur on the road. The car was towed to the dealership where they informed me the damage would require $16k - $18k of repairs to the axle, steering column and a host of related systems.

Received the vehicle less than a week ago, rear right damper/shocks need replacement.

Electrical-soy covered wires causes rodents to chew wires causing electrical defaults and faulty control. Windshield - Minor chips causing massive cracks - happened twice in a 2 week time frame. After it was replaced. Cracked again

Sunroof unexpected exploded. No external interfaces (rocks or debris or weather) radio off sunscreen open sunroof closed. Speed was approximately 30 mph. Took car to dealership and was told sunroof don't just explode something had to hit it. They mentioned nothing about the issues with these sunroof, complaints or investigations that has done.

When fully extended, the seatbelt will occasionally twist or fold as it is being retracted, sometimes causing the belt to be stuck or jammed in the retractor and rendering the seatbelt inoperable and in need of repair. BMW considers this an issue caused by "outside influence" (not a manufacturer defect) that is not covered under warranty repair, even if this issue occurs during normal operation of the seatbelt.

I was pulling into a parking spot. I was riding slowly into the correct position. Immediately the car went into full acceleration. Knocked the parked car in front about 8 feet, turned and knocked another car on the side. I stood on the breaks, it went another 10 feet and engine stopped. I never heard this level of acceleration of engine ever before. The airbags for me and my passenger did not open. I think this spurious acceleration is a control system defect.