2025 BMW X5 Problems

While driving eastbound on [XXX] on XXX between approximately 9:29 and 10:21 AM, the vehicle suddenly displayed a red warning instructing the driver to “Take over braking function immediately.” At that moment, adaptive cruise control braking and automated braking assistance disengaged without warning, requiring the driver to manually brake while in traffic. This created an unexpected safety hazard for the driver, passengers, and surrounding motorists. Prior to this event, the vehicle had exhibited repeated Driver Assistance instability across multiple service visits, including inconsistent adaptive cruise control behavior, braking‑related restrictions, and GPS mislocation affecting ADAS functions. The vehicle has been inspected by the manufacturer’s authorized dealer across five service visits, including replacement of the head unit and multiple software resets. The underlying malfunction has occurred repeatedly, but the specific braking alert has not been reproduced by the dealer. No crash, fire, or injury occurred. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Our 2025 BMW X5 50e was involved in an accident while slowly pulling into a parking spot at Bryce Canyon National Park in Utah. While turning right into the striped parking spot, the car suddenly accelerated, swiping the car parked to the right and continued on to break through a rung of the log fence barrier before manual hard braking stopped it from plunging into the canyon below. There was no audible alarm heard and apparently no emergency braking engaged to prevent impact with the other car or log fence. No airbags deployed. Emergency braking was enabled. Drive mode was Hybrid. With the grill damaged and a front sensor hanging below the damaged bumper. We are still awaiting the Park Ranger report.

I was driving my 2025 BMW X5 sDrive40i at approximately 60 mph when the vehicle in front of me stopped abruptly. I immediately applied the brake pedal firmly in an attempt to make an emergency stop. Despite applying heavy and continuous pressure to the brake pedal, the braking force felt unusually weak. The vehicle slowed gradually but continued rolling forward much farther than I expected and did not stop before I made low-speed contact with the rear of the vehicle in front of me. The vehicle did not skid, I did not feel the tires sliding, and I did not observe skid marks. My concern is that the vehicle did not provide the amount of braking force I expected despite firm emergency braking. Because BMW X5 vehicles have been subject to recalls involving the Integrated Brake system, ABS, DSC, and potentially increased stopping distance, I am reporting this incident as a possible safety-related braking defect.

2025 BMW X5...warning lights appeared and voice said emergency stop... emergency stop and tried to pull me off the road. shut down the vehicle for a while... and started up. finished errands. got home. vehicle would not start in the morning. dealership said it was an issue with the braking system... electronics and dead battery . said repaired. got it back. happened again...but got it going. dealership said if it happened again... press the gas pedal and it would clear up the problem. recent issue August 18, 2026. vehicle would not start. got a jump and emergency lights again.. emergency stop. vehicle towed to dealership. was told it had faults with the brake control unit. believed to be fixed but further testing to make sure. I'm worried this will happen on highway or the vehicle is not sellable if I ever want to sell or trade it in

2025 BMW X5...warning lights appeared and voice said emergency stop... emergency stop and tried to pull me off the road. shut down the vehicle for a while... and started up. finished errands. got home. vehicle would not start in the morning. dealership said it was an issue with the braking system... electronics and dead battery . said repaired. got it back. happened again...but got it going. dealership said if it happened again... press the gas pedal and it would clear up the problem. recent issue August 18, 2026. vehicle would not start. got a jump and emergency lights again.. emergency stop. vehicle towed to dealership. was told it had faults with the brake control unit. believed to be fixed but further testing to make sure. I'm worried this will happen on highway or the vehicle is not sellable if I ever want to sell or trade it in

The vehicle shut off and would not start while at a stop light. It is new: under one year old and still within warranty. The error was a “Restart not possible. Drivetrain fault” as shown in the picture. My safety as well as my passenger’s were put at risk due to being in a congested roadway and unable to move. After attempting to restart the system software, I then observed a “High voltage battery” warning. At that point my passenger and I exited the vehicle. As I was on the phone with emergency roadside assistance while out of the vehicle for about 10 minutes, the vehicle was able to start with the warning now displaying “Drivetrain. You can continue driving. Have the problem checked by your local service center.” I hesitantly drove the vehicle home. While parked, I checked about 15 minutes later and the issue resurfaced (as pictured). The problem has not yet been taken to the dealership. It will be tomorrow. The issue has not yet been inspected by any other representatives. There were no warning signs whatsoever before the issue occurred. The vehicle simply shut off, and upon attempting restart the aforementioned errors were observed.

The vehicle shut off and would not start while at a stop light. It is new: under one year old and still within warranty. The error was a “Restart not possible. Drivetrain fault” as shown in the picture. My safety as well as my passenger’s were put at risk due to being in a congested roadway and unable to move. After attempting to restart the system software, I then observed a “High voltage battery” warning. At that point my passenger and I exited the vehicle. As I was on the phone with emergency roadside assistance while out of the vehicle for about 10 minutes, the vehicle was able to start with the warning now displaying “Drivetrain. You can continue driving. Have the problem checked by your local service center.” I hesitantly drove the vehicle home. While parked, I checked about 15 minutes later and the issue resurfaced (as pictured). The problem has not yet been taken to the dealership. It will be tomorrow. The issue has not yet been inspected by any other representatives. There were no warning signs whatsoever before the issue occurred. The vehicle simply shut off, and upon attempting restart the aforementioned errors were observed.

drivetrain lights came on out of no where. i was coming to a red light and when car stopped the light on dash came on and message came on for drivetrain malfunction. Car was turned off and on and message went away. Car was brought to dealer and they were able to diagnose saying 3 injector problem and need to replace cylinder head. Was told this a problem with the new V8 engines. can be dangerous if driving and message is gone and continue driving.

Incident Description: While driving with my two [XXX] children and husband under normal conditions, the panoramic sunroof glass on my 2025 BMW X5 xDrive50e suddenly and unexpectedly shattered without warning. At the time of the incident: There were no weather events (no hail, debris, or extreme conditions) I did not observe any object striking the vehicle There was no prior damage to the sunroof The glass failure was abrupt and loud, sounding like an explosion, consistent with a sudden break rather than gradual damage. There were no warnings or symptoms or sounds of impact prior to the explosion. I immediately documented the damage with photographs taken at the scene, prior to any inspection or handling. Safety Concern: This incident raises serious safety concerns: The sudden shattering of the sunroof could startle or distract the driver, increasing the risk of an accident Broken glass could fall into the vehicle cabin, posing a risk of injury to occupants The unexpected nature of the failure creates a hazard at highway speeds This type of failure appears consistent with reports of spontaneous tempered glass breakage, sometimes referred to as “exploding sunroofs.” Manufacturer Response: The vehicle was inspected by the dealership, BMW of San Rafael, and escalated to BMW of North America. BMW determined that the damage was caused by “impact” and denied warranty coverage. However: No clear point of impact (such as a chip, crater, or penetration point) has been identified No foreign object residue or evidence of impact has been provided The determination appears to rely on a visual interpretation of crack patterns, rather than confirmed physical evidence Based on my observations, the fracture pattern appears irregular and distributed, including along the edges, which may be consistent with stress-related or spontaneous failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have owned my BMW for only 19 months and in that short period of time, I have had to replace my windhsield (with OEM BMW Glass) 2x due to small road debris impacts (normal gravel/sand) becoming major fractures in less than a day. I have been driving for 40 years and only replaced 3 windshields in my life--2 of them in the past 10 months in this brand new BMW. Same roads and weather I have driven on for the past 24 years, in the south [XXX] ) so no unusual road gravel of weather conditions. I have to believe that these windshields are somehow more fragile than they should be. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

drivetrain lights came on out of no where. i was coming to a red light and when car stopped the light on dash came on and message came on for drivetrain malfunction. Car was turned off and on and message went away. Car was brought to dealer and they were able to diagnose saying 3 injector problem and need to replace cylinder head. Was told this a problem with the new V8 engines. can be dangerous if driving and message is gone and continue driving.

While driving this new 2025 BMW X5 M60i vehicle with only 6200 miles, all of a sudden battery failure indicator came on in the middle of traffic, followed by drivetrain failure / malfunction indicator came on. BMW roadside assistance was contacted, and advised me to have vehicle stopped and pulled over immediately and towed. Situation was dangerous as the traffic was flowing at 40 mph. Vehicle Eventually totally lost power. It was towed to local BMW dealership where it was purchased from. The dealership service department was able to reproduce the issue, confirmed that it was a cracked transmission casing, resulting in fluid leak, causing electrical failure and leading to mechanical failure. BMW head office was contacted By the dealership service department and new transmission was requested. Please refer to pages 3 and 4 of the service report attached for details. This is a brand-new vehicle, bought directly from dealership 5 months ago, and had been driven with caution and care. No prior indicators were ever noticed. My safety and safety of nearby vehicles was compromised due to the fact that power was suddenly lost and engine failure unexpectedly occured at such low mileage in fastr flowing traffic. It is incomprehensible that a brand-new vehicle such as this would all of a sudden develop a serious malfunction without prior warning, and have a cracked / broken transmission casing which was found to be leaking fluids. It seems it was defective to begin with.

Reduced steering effort error message. No accident or injuries. Seems to be a known issue on BMWs. Likely covered under warranty but I feel should be reported

See attached document for complaint.

The contact owns a 2025 BMW X5. The contact stated that while his wife was driving at an undisclosed speed, for an unknown reason, she lost control of the vehicle and hit a telephone pole, where the vehicle came to a stop. The driver-side and passenger-side air bags did not deploy. No warning lights were illuminated. A police report was filed. The contact's wife was taken to the hospital by ambulance. The contact's wife did not suffer injuries. The vehicle was towed to a towing yard. The insurance company was notified. The manufacturer was made aware of the failure. The manufacturer advised the contact that a field inspector would be sent to inspect the vehicle. The field inspector inspected the vehicle. However, no information was provided regarding why the air bags did not deploy. The failure mileage was approximately 8,000.

On September 2, 2025, my 2025 BMW X5 xDrive50e was involved in a head-on collision with another vehicle. Despite the severity of the impact, the following safety systems failed to deploy: Front airbags Driver seatbelt pretensioner BMW Assist / automatic emergency notification Witnesses reported that my vehicle briefly went airborne before landing with the rear wheels up on a curb. I suffered neck injuries, and my vehicle sustained significant frontal damage. BMW later downloaded the Event Data Recorder (EDR) and confirmed: A frontal non-deployment event Three fault codes in the airbag control module (ACSM) post-crash The crash algorithm activated and reset ΔV reached approx. 12.4 mph longitudinal Forward Collision Mitigation system issued an acute warning 0.5 seconds before impact BMW states the “impulse was not sufficient” to trigger restraint deployment BMW has refused to provide: The deployment thresholds (ΔV criteria) for airbags or pre-tensioners Any engineering explanation for why restraint systems did not activate Any technical rationale for the ACSM fault codes Any escalation beyond Customer Relations All I have been given is an unsigned summary letter and the raw EDR file. BMW Customer Relations stated that engineering is “not customer-facing” and that no additional information will be provided. This leaves serious concerns that: The restraint systems did not function properly in a real-world impact. BMW is refusing to disclose the engineering basis for its conclusions. Consumers may be at risk if this is a repeatable failure mode. I am requesting NHTSA review this incident as a potential defect in the airbag, pretensioner, and/or crash-sensing system in the 2025 BMW X5. I can provide the EDR report, photos, BMW’s letter, and full correspondence upon request. VIN: [XXX] Mileage: ~10,700 Crash Date: 09/02/2025 BMW Case #: XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While the daytime running lights are on (this vehicle has front and rear daytime running lights, so when the DRL’s are on, the taillights are illuminated as well as the front daytime running lights). When the DRL’s are on, and you use a turn signal, the rear turn signals are almost invisible to the naked eye during the day time. Reason being, the DRL’s are on, so the rear tail lights are slightly illuminated. This vehicle also has a pulsating (fade on/off) turn signals in the front and rear. It’s not a sharp on/off like a typical LED. So when using the turn signal, the rear turn signals (which also act as the taillight and brake light) are very very dim and hard to see as compared to when the DRL’s are off. The photo I will provide shows the left turn signal at its brightest point, the one on top with the daytime running lights off, are very bright and visible, whereas the bottom photo (which shows the rear daytime running taillights on) also shows the left turn signal at its brightest point, and is almost indistinguishable as to whether the turn signal is flashing. Again, both have the left turn signal on at its brightest point. This is very unsafe, and applies to all 2024-2026 BMW X5’s. J would like this rectified.

BRAND NEW X5 BMW 50E CAME TO A STOP AND ENTIRE CAR WENT DEAD. NO START, LIGHTS, IN TOTAL DARKNESS WITH NO EMERGENCY LIGHTS. DASH SCREEN DID SHOW A DRIVE TRANE MALFUNCTION BEFORE IT TOTALLY DIED. CAR WAS REPAIRED AFTER 2 MONTHS AND REPLACEMENT PARTS MALFUNCTION. CAR STILL HAS ELECTRONIC ISSUES AND HAS BEEN IN THE SHOP 3 TIMES SINCE MAJOR FAILURE. SAFETY ISSUE WITH NO EMERGENCY LIGHTS AND IF I HAD BEEN DRIVING AND VEHICLE WENT DEAD I WOULD HAVE HAD A CRASH.

On September 2, 2025, my 2025 BMW X5 xDrive50e was involved in a head-on collision with another vehicle. Despite the severity of the impact, the following safety systems failed to deploy: Front airbags Driver seatbelt pretensioner BMW Assist / automatic emergency notification Witnesses reported that my vehicle briefly went airborne before landing with the rear wheels up on a curb. I suffered neck injuries, and my vehicle sustained significant frontal damage. BMW later downloaded the Event Data Recorder (EDR) and confirmed: A frontal non-deployment event Three fault codes in the airbag control module (ACSM) post-crash The crash algorithm activated and reset ΔV reached approx. 12.4 mph longitudinal Forward Collision Mitigation system issued an acute warning 0.5 seconds before impact BMW states the “impulse was not sufficient” to trigger restraint deployment BMW has refused to provide: The deployment thresholds (ΔV criteria) for airbags or pre-tensioners Any engineering explanation for why restraint systems did not activate Any technical rationale for the ACSM fault codes Any escalation beyond Customer Relations All I have been given is an unsigned summary letter and the raw EDR file. BMW Customer Relations stated that engineering is “not customer-facing” and that no additional information will be provided. This leaves serious concerns that: The restraint systems did not function properly in a real-world impact. BMW is refusing to disclose the engineering basis for its conclusions. Consumers may be at risk if this is a repeatable failure mode. I am requesting NHTSA review this incident as a potential defect in the airbag, pretensioner, and/or crash-sensing system in the 2025 BMW X5. I can provide the EDR report, photos, BMW’s letter, and full correspondence upon request. VIN: [XXX] Mileage: ~10,700 Crash Date: 09/02/2025 BMW Case #: XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

We are reporting a safety issue with the BMW X5 xDrive50e model year 2025. I purchased this car on December 9, 2024, from BMW of Pembroke Pines, 14800 Sheridan Street Pembroke Pines FL 33331. Within two months of purchase, we found that car has unintended acceleration while it is about to be parked at very slow speed. I reported this safety issue to BMW dealer in Pembroke Pines FL where I purchased the Car. The dealership kept this car of investigation. After about five weeks they returned the car with a comment on my invoice that car is working normally. On October 24, 2025, while on vacation to St. Augustine FL and parking at the visitor center SUV accelerated and hit the wall of the visitor center. All the airbags opened and saved us from serious injuries. The crash report of this incident is attached to this report. BMW failed to investigate this issue and put us and others at high risk.

On April 15, 2026, while driving on the highway with my family in my 2025 BMW X5 (purchased new on September 25, 2025 from Principal BMW of Corpus Christi for approximately $75,000), the panoramic sunroof suddenly and violently exploded. The explosion sounded like a gunshot. Shards of glass sprayed throughout the cabin and got into our eyes. I was barely able to maintain control of the vehicle and prevent a serious accident that could have resulted in hospitalization or worse. Photos of the sunroof taken immediately after the explosion are attached to this email. These images clearly show the large shattered section, missing glass fragments, and debris inside the sunshade right after the failure. You can also see from the picture submitted from the front, the glass is pushed out from the car. This was an extremely dangerous safety failure that put my entire family at immediate risk. Because of this incident, I no longer feel safe driving the vehicle. I am now constantly on high alert, worried that the sunroof could explode again at any moment. This traumatizing experience has completely ruined my ability to enjoy what was supposed to be a luxury vehicle. Instead of the premium driving experience I paid for, I am left with fear and anxiety every time I get behind the wheel. This is not an isolated or “unheard of” incident. BMW has faced multiple reports and a class action lawsuit regarding exploding sunroofs dating back to at least 2017. Despite this known issue, when I contacted Principal BMW of Corpus Christi, the dealership claimed the problem was unheard of and showed absolutely no sense of urgency or willingness to address it properly. The service person took a quick look and told me that this incident has happened two other times within the last two months. Since the incident happened on 4/15/26 @ 6:35PM I was unable to speak to a service member.Service person told me to bring my car in for further evaluation on 4/20/26 since he’s only one working.