2019 BMW X7 Engine Problems

I am reporting a safety concern involving BMW vehicles equipped with the B58 Technical Update (B58TU) engine, commonly found in model years 2019–2021. These vehicles utilize a variable-displacement engine oil pump containing an internal thermoplastic adjusting component responsible for regulating oil pressure. Field failures are increasingly being reported in which this internal component fractures, resulting in sudden loss or instability of engine oil pressure/lubrication. Loss of lubrication can cause the vehicle to become disabled without warning while driving or shortly after startup. This creates a safety hazard, particularly when vehicles become immobilized in active traffic or during winter conditions the cold is when they fail the most, where occupants may be exposed to freezing temperatures while awaiting assistance. Owners are currently unable to determine whether their vehicles contain the original thermoplastic oil pump design or a later revised version utilizing metal internal components, as VIN-based parts information now identifies updated components in the car even when no replacement has occurred and the old components are actually in the car. Also, BMW has actively removed the plastic part number out of all dealer networks, demonstrating knowledge of the defective component.

NHTSA ID

11755865

Incident

Aug 10, 2026

The contact owns a 2019 BMW X7. The contact stated that the Auto START/STOP feature failed to function as intended. There was a fire message displayed. The vehicle was taken to the local dealer, where it was diagnosed; however, the dealer was unable to update the control unit. The control unit was not communicating as intended. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 24V576000 (Electrical System, Engine, and Engine Cooling). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 134,000.

NHTSA ID

11753481

Incident

Jul 10, 2026

Mileage

134,000 mi

I was told today that my BMW engine oil pump is failing because of plastic internal components which will cause irreversible catastrophic engine damage during operation which is extremely dangerous and that I was informed by the dealer that BMW quietly changed them 2 years after due to the failure rate. If the oil pump shatters, debris can permanently damage the engine during operation jeopardizing my safety and those driving around me, making replacement with the upgraded, all-metal oil pump, that BMW quietly changed due to this failure, nearly $6k -$8k to fix and is not covered though they admit it is a known failure/safety issue. As of XXX, BMW Korea is running a free repair campaign (recall) to address oil pump failures affecting the B58TU engine in that country. Affected vehicles include models manufactured between XXX and XXX. BMW Korea replaces the non-safe original plastic oil pump with BMW's upgraded metal design, and even covers prior out-of-pocket replacements. NHTSA needs to hold BMW accountable and force BMW USA to complete the same safety recall for the exact same issue of faulty engine oil pumps they installed to save money as BMW Korea for the United States. Safety recalls should NOT be optional in USA and especially so if BMW is already doing the recall in another country for same issue identified in their cars sold here in the [XXX] too. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11749887

Incident

Jul 11, 2026

The contact owns a 2019 BMW X7. The contact stated that while driving at an undisclosed speed, the engine overheated and the engine seized. The check engine warning light was illuminated. While attempting to restart the vehicle, the vehicle restarted with the power train warning light illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed, and the failure reoccurred. The failure was a persistent failure. The contact stated that there was thick white smoke coming from the exhaust. The contact noticed a fuel odor on the interior and exterior of the vehicle. In addition, the RPM was elevated. The vehicle was towed to the dealer. The contact stated that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under recall or warranty. The failure mileage was approximately 102,000.

NHTSA ID

11733949

Incident

Apr 17, 2026

Mileage

102,000 mi

The contact owns a 2019 BMW X7. The contact stated that while driving approximately 40 MPH, the vehicle started to vibrate, and the vehicle lost motive power. The contact stated that the message "Timing Chain Failure - Contact Manufacturer" was displayed. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that there was no failure. The vehicle was not repaired. The contact stated that the loss of motive power and vibration was a recurring failure and occurred at 40 MPH or faster. The manufacturer was informed of the failure and was advised that there was no recall related to the failure, and referred the contact to the dealer. The failure mileage was approximately 50,000.

NHTSA ID

11705867

Incident

May 18, 2024

Mileage

50,000 mi

My 2019 BMW X7 is under Safety Recall 25V-644 for an overheating/fire-risk defect, but the recall remedy is unavailable. The vehicle has now experienced multiple safety-related failures that appear to be progressing. BMW diagnosed the following failures: • Emergency Call System Malfunction • GPS and maps not working • Failure of the TCB telematics module • Failure of the antenna and TCB battery due to fluid ingress • Battery voltage in the red zone • All four tire pressure sensors beginning to fail • Collapsed engine mounts attributed to heat • $11,296 in repair estimates related to electrical and heat damage Immediately after picking up the vehicle from BMW service, a new battery/charging system warning light appeared that was NOT present before the visit. This suggests further deterioration of the electrical system. The combination of: • an open fire-risk recall with no fix available, • fluid ingress damaging telematics components, • multiple electrical and safety-system failures, and • new warning lights appearing after service makes this vehicle unsafe to operate, especially for long-distance highway travel. I am requesting that NHTSA document this as a safety-defect case and assist in ensuring BMW provides a safe resolution.

NHTSA ID

11702931

Incident

Nov 20, 2025

Explosion when turning on my car.

NHTSA ID

11691965

Incident

Oct 6, 2025

The contact owns a 2019 BMW X7. The contact stated that after depressing the Push-To-Start button, the vehicle hesitated to start. No warning light was illuminated. The vehicle was towed to a local independent mechanic who related the failure to NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling). The vehicle was towed to a local dealer where it repaired under NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling). In addition, the contact was advised that the starter needed to be replaced; however, the vehicle was not repaired due to the cost not covered under the warranty. The manufacturer was made aware of the failure. The failure mileage was approximately 20,000. The VIN was not available.

NHTSA ID

11669190

Incident

Jun 16, 2025

Mileage

20,000 mi

My vehicle just stopped, in the middle of a busy 95 South Cross Bronx Expressway.

NHTSA ID

11666662

Incident

May 22, 2025

Hello, This USV problem with starter and my vehicle have been replace 3 times for starter, I received letter from BMW for recall starter and update firmware and brought to Sterling BMW in Newport Beach California and dealer only update firmware also denied to replace the starter, I told them this starter issue for many time during the factory warranty and each starter last only 16 months after replacement Now they want to charge $1500 for replace starter again

NHTSA ID

11666134

Incident

Apr 25, 2025

The contact owns a 2019 BMW X7. The contact stated that while attempting to start the vehicle, the message that the starter motor was overheating was displayed and the vehicle failed to start. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the starter motor. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The manufacturer was not notified of the failure. The failure mileage was 54,000.

NHTSA ID

11660474

Incident

May 12, 2025

Mileage

54,000 mi

The contact owned a 2019 BMW X7. The contact stated while the vehicle was occupied and parked in the garage at the residence, the contact’s husband attempted several times to start the vehicle, and the vehicle failed to respond as needed. The contact stated that the failure had occurred on several occasions. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the starter needed to be replaced. The vehicle was not repaired. The contact related the failure to the NHTSA Campaign Number: 24V576000 (ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and escalated the issue to the claims department. The failure mileage was 49,447.

NHTSA ID

11652377

Incident

Mar 30, 2025

Mileage

49,447 mi

The contact owns a 2019 BMW X7. The contact stated that upon a warm start of the engine, a "System Overheating re-starting engine possible after cooling" message intermittently appeared on the instrument panel. The contact would be forced to open the hood to allow the engine to cool for several minutes before the vehicle would start up and resume normal operation. The dealer was notified of the failure and the contact was informed that the vehicle was not included in NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling). The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 58,000.

NHTSA ID

11647722

Incident

Dec 11, 2024

Mileage

58,000 mi

When trying to start the vehicle it will say that the starter has overheated and to try restarting again in xx seconds. This occurs randomly and the car does not indicate that the engine is over heating, just the starter. When looking online it appears there is an active recall for this very issue but my VIN is not registered with the recall. BMW believes that my car should be covered under this warranty and advised filing a report with the NHTSA to have it extended to my car. The vehicle is a 2019 and was produced in March of 2019.

NHTSA ID

11641212

Incident

Feb 5, 2025

Engine starter of my BMW X7 failed and required replacement. BMW has issued a safety recall "campaign number 24V-576: Engine Starter" related to this issue. Engine starter on my vehicle failed before I had a chance to get software upgrade as suggested by BMW.

NHTSA ID

11634245

Incident

Nov 29, 2024

Vehicle starter failed to crank the engine. You can smell electric type smoke coming from the under carriage. Vehicle stopped at a light and could not move. Nearly caused a crash or worse a fire. No warning lights or indicators. Just won’t start and smoke.

NHTSA ID

11572446

Incident

Feb 16, 2024