1999 BMW Z3 Powertrain (other) Problems

VERY WELL KNOWN FAILURE, JUST SEARCH FOR "BMW Z3 SUBFRAME FAILURE". IT IS A DESIGN FLAW BY BMW THAT AFFECTS A LOT OF Z3'S THROUGH ALL MODEL YEARS. MINE STARTED TO POP ONE WELD AT 88K MILES. IT CAN CAUSE THE REAR ALIGNMENT TO BE OFF, IN WORST CASE THE TRUNK FLOOR IS TORN OUT AND THE DIFFERENTIAL FALLS TO THE GROUND. CLUNKING FROM THE BACK WHILE SHIFTING IN THE FIRST TWO GEARS IS ONE INDICATOR THIS DAMAGE IS NOT FAR AWAY. THIS IS ONE FORUM THREAD THAT DESCRIBES THE ISSUE WELL: HTTPS://WWW.BIMMERFORUMS.COM/FORUM/SHOWTHREAD.PHP?1979601-SUBFRAME-TRUNK-FLOOR-DIFFERENTIAL-MOUNT-FAILURE

NHTSA ID

11032127

Incident

Oct 6, 2017

Mileage

88,000 mi

TL* THE CONTACT OWNS A 1999 BMW Z3. AFTER THE VEHICLE WAS STARTED AND PLACED INTO REVERSE, A CLANKING SOUND EMERGED FROM THE REAR END WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 99V272000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

NHTSA ID

10874771

Incident

Jun 13, 2016

Mileage

140,000 mi

THE REAR DIFFERENTIAL HOUSING IS SEPARATING FROM THE SUBFRAME OF THE CAR, UNDER OR NEAR THE TRUNK AREA. THIS IS A WELL DOCUMENTED ISSUE WITH THE Z3 SERIES OF VEHICLES. THIS COULD BE A SAFETY HAZARD WHILE OPERATING THE VEHICLE IF THE READ DIFFERENTIAL SEPARATES FROM THE SUBFRAME, AND COULD CAUSE A HAZARD TO OTHER MOTORIST. THIS APPEARS TO BE DUE TO A DESIGN FLAW. THE FRAME WAS DESIGNED FOR A 1.9L ENGINE, AND BMW DID NOT REDESIGN THE SUBFRAME TO ALLOW FOR THE LARGER ENGINES IT LATER SOLD IN THE Z3 SERIES OF CARS. BMW ALSO HAD THIS SAME ISSUE ON 3XX SERIES OF VEHICLES, AND AGREED TO REPAIR THOSE CARS DUE TO A CLASS ACTION LAW SUITE SETTLEMENT. BMW SHOULD BE HELD ACCOUNTABLE FOR THE DESIGN ISSUE, AND ACKNOWLEDGE THE SAFETY HAZARD. *TR

NHTSA ID

10676809

Incident

Nov 26, 2014

Mileage

101,000 mi

TL* THE CONTACT OWNS A 1999 BMW Z3. THE CONTACT STATED THAT THE VEHICLE WAS INCREASINGLY HARD TO CONTROL AND THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR AN ALIGNMENT. THE MECHANIC ADVISED THE CONTACT THAT THE REAR DIFFERENTIAL HAD FAILED AND WAS CAUSING THE WHEELS TO FRACTURE FROM THE SUB FRAME. THE MECHANIC ALSO ADVISED THE CONTACT OF THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 99V272000 (POWER TRAIN: DRIVELINE: DIFFERENTIAL UNIT). THE MANUFACTURER WAS CONTACTED AND THE CONTACT WAS ADVISED TO HAVE THE VEHICLE TOWED TO THE DEALER. THE VEHICLE WAS TOWED AND THE CONTACT WAS AWAITING DIAGNOSIS AND REPAIRS. THE FAILURE AND CURRENT MILEAGE WAS 105,000.

NHTSA ID

10378668

Incident

Jan 16, 2011

Mileage

105,000 mi

DT*: THE CONTACT STATED WHILE DRIVING 70 MPH DURING CLEAR CONDITIONS, THE FRONT DRIVER SIDE AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT TO THE VEHICLE. THERE WAS NO DEBRIS OR POTHOLES PRESENT. THE CONTACT SUFFERED CUTS, BRUISING AND SCARING TO THE LEFT ARM. THE CONTACT DROVE TO THE HOSPITAL. THE SERVICE DEALER AND MANUFACTURER WERE NOTIFIED AND PHOTOS WERE TAKEN OF THE VEHICLE AND INJURIES. UPDATED 11/16/2006 -THE GAS GAUGE AND ODOMETER WERE INOPERATIVE. THE DEALER REPLACED THE INSTRUMENT CLUSTER. THE DRIVER'S DOOR GRAB HANDLE WAS REPLACED. THE REAR SHOCKS AND MOUNTS WERE REPLACED. THERE WAS A POWER STEERING LEAK. THE DEALER REPLACED THE POWER STEERING HOSE RES TO PUMP. THE DEALER REPLACED THE FLEX COUPLER ON THE DRIVE SHAFT. *NM

NHTSA ID

10171793

Incident

Sep 6, 2006

Mileage

87,950 mi

I PURCHASED MY CAR FROM ROSE IMPORTS IN VALLEJO, CA. ON 08-22-2006. APPROXIMATELY 1 MONTH LATER, I STARTED TO HEAR A NOISE FROM THE REAR. I WOULD HEAR IT OCCASIONALLY. ON 10-10-2006, I WAS DRIVING HOME ON I-80 AND AS I WAS DRIVING, SUDDENLY I HEAR A LOUD "POP". I PULL OVER AND DID A VISUAL CHECK BUT FOUND NOTHING I COULD SEE SO I CONTINUED TO DRIVE HOME AND HEARD METAL SOUNDS COMING FROM THE BACK. THE NEXT DAY WHILE DRIVING TO WORK, I CONTINUED TO HEAR THE SOUND AND WHEN I RETURNED HOME, ME AND A FRIEND LIFTED THE CAR AND THAT'S WHEN I DISCOVERED THE SNAP OR BREAK IN THE DIFFERENTIAL SUPPORT BRACKET. IT HAS COMPLETELY SEPARATED FROM THE DIFFERENTIAL. THE DEALER WHERE I PURCHASED THE CAR TOLD ME GOOD LUCK. THEY'RE NOT GOING TO DO ANYTHING SINCE IT PASSED THEIR SAFETY INSPECTION. I CALLED MY LOCAL BMW DEALER AND SPOKE TO THE SERVICE DEPT. AND THEY TOLD ME IT WAS NOTHING THEY CAN OR WILL DO BECAUSE IT'S 86K MILES AND OUT OF WARRANTY. NOW I'M STUCK WITH A CAR I JUST PURCHASED AND HAVE A MAJOR BILL 2 MONTHS LATER. *NM

NHTSA ID

10170795

Incident

Oct 10, 2006

Mileage

86,410 mi

THE VEHICLE WAS PARKED WHEN THE DRIVER NOTICED THAT THE DIFFERENTIAL WAS HANGING FROM UNDERNEATH THE VEHICLE. THE DRIVER HAD THE VEHICLE TOWED TO THE DEALER. THE MECHANIC INFORMED THE DRIVER THAT THE REAR TRUNK SUB FRAME NEEDED REPLACEMENT AND WELDING. *NM *SC

NHTSA ID

10107383

Incident

Jan 13, 2005

Mileage

115,000 mi

I OWN A 1999 BMW Z3 2.3 ROADSTER. THE DIFFERENTIAL MOUNT HAS TORN AWAY FROM THE UNDERBODY OF THE CAR WHERE IT WAS WELDED WHEN DESIGNED. THIS IS THE THIRD COMPLAINT ABOUT THIS PARTICULAR DEFECT ON THIS WEBSITE BUT THERE ARE SEVERAL MORE ON BIMMERFEST.COM. BMW NA SHOULD BE MADE AWARE OF THIS DESIGN FLAW AND FORCED TO DO A RECALL ON ALL CARS THEY MADE WITH THIS FLAW. I WILL SEEK ALL NECESSARY LEGAL ACTION TO HOLD THEM ACCOUNTABLE. YOU DON'T PAY $40,000 FOR A CAR THEY CLAIM AS THE BEST CAR ON THE ROAD TO HAVE A MAJOR SAFETY ISSUE LIKE THIS EXIST. *AK

NHTSA ID

10100977

Incident

Dec 1, 2004

Mileage

118,000 mi

THE DIFFERENTIAL MOUNT ON MY 1999 BMW Z3 COUPE 2.8 HAS CRACKED. SHOULD THIS MOUNT FAIL COMPLETELY, I FEAR THAT SERIOUS HARM MAY COME TO ANOTHER DRIVER, PASSENGER OR MYSELF.*AK

NHTSA ID

10062290

Incident

Mar 10, 2004