2007 BMW Z4 Engine Problems

The contact owns a 2007 BMW Z4. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11497566

Incident

Dec 1, 2017

The contact owns a 2007 BMW Z4. The contact stated that after driving in the vehicle for approximately 20 minutes, he would become disoriented, experienced headaches, and blurred vision. Upon inspection, it was discovered that the muffler welding material had deteriorated and was damaged. The vehicle was taken to the local dealer who was unable to determine the cause of the failure and indicated that no exhaust leak was present. The contact later received a notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The manufacturer was contacted regarding the failure but no assistance was offered. The failure mileage was 9,200. This is in regards to the complaint that consumer made about an overlooked exhaust leak and a PCV valve recall by BMW. Consumer had an exhaust leak on my car a little more than three years ago and had the exhaust replaced… The exhaust and the muffler on it are only about 3 years old. It's already being corroded through.

NHTSA ID

11461659

Incident

Apr 1, 2022

Mileage

9,200 mi

THE CONTACT OWNS A 2007 BMW Z4. THE CONTACT STATED WHILE DRIVING 70 MPH, THERE WAS AN ABNORMAL KNOCKING SOUND COMING FROM THE ENGINE. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND INSPECTED UNDER THE HOOD AND UNDERNEATH THE VEHICLE. THE CONTACT FOUND NO ISSUES. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED BACK TO THE RESIDENCE. THE VEHICLE WAS NEXT TOWED TO THE LOCAL DEALER BMW DEALER TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 81,000.

NHTSA ID

11417683

Incident

May 15, 2021

Mileage

81,000 mi

WHILE IN MOTION THE VEHICLE ACCELERATES FOR 2 TO 3 SECONDS PERIODICALLY ON HIGHWAY AND IN CITY. WHILE IN MOTION AT LOW SPEED AND WHEN STATIONARY AFTER DRIVING ONLY A FEW MILES THE VEHICLE ENGINE SHUTS DOWN. WHILE IN MOTION AT HIGH SPEED THE VEHICLE ENGINE STUTTERS BADLY BUT DOES NOT TURN OFF. THE IGNITION SWITCH HAS TO BE TUNED OFF AND THEN ON AGAIN, AND THEN THE ENGINE TURNS OVER AND I'M ABLE TO CONTINUE TO DRIVE IT. BOTH VALVE COVER GASKETS LEAK OIL ONTO THE ENGINE. THE WORST WAS FRONT OF THE ENGINE WHICH HAS BEEN REPLACED. THERE IS AN ELECTRICAL ISSUE: SEATBELTS DON'T RETRACT AUTOMATICALLY AND ARE NOT WORKING PROPERLY, GET CAUGHT IN THE DOOR. BOTH E-KEYS HAVE STOPPED WORKING AND NOT ABLE TO BE REPROGRAMMED FOR EN. THE HORN DOES NOT WORK AT ALL. THE AIRBAG WARNING LIGHT REMAINS ON AT ALL TIMES. THE CIG LIGHTER AND SEAT WARMERS ARE WORKING FINE. THE THERMOSTAT WARNING COMES ON BUT IN GAUGE IS NOT SHOWING ANY SIGN OF TROUBLE. BOTH THE HEAT AND THE AC WORK FINE WHILE IN MOTION AND STATIONARY.

NHTSA ID

11153666

Incident

Oct 23, 2017

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2007 BMW Z4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT CALLED A LOCAL DEALER (PRESTON BMW, 7830 MARKET ST, BOARDMAN, OH 44512) AND WAS ADVISED THAT THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE PART MAY BE AVAILABLE BY THE END OF JUNE 2018. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.

NHTSA ID

11091001

Incident

Dec 11, 2017

TL* THE CONTACT OWNS A 2007 BMW Z4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. BMW OF LOUISVILLE (4 AUTOCENTER DR, LOUISVILLE, KY) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *TT *TR

NHTSA ID

11074972

Incident

Dec 18, 2017

TL* THE CONTACT OWNS A 2007 BMW Z4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11073322

Incident

Oct 30, 2017

TL* THE CONTACT OWNS A 2007 BMW Z4M. WHILE DRIVING 10 MPH, THE CONTACT STATED THAT HE HIT A BUMP IN THE ROAD WHEN HE HEARD A LOUD SNAP COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE DEALER ADVISED HIM THAT THE PASSENGER SIDE ENGINE BOLTS HAD FRACTURED AND THAT THE ENGINE WAS NOT ATTACHED TO THE VEHICLE. THE MANUFACTURER WAS WAS AWARE OF THE FAILURE. THE VEHICLE WAS AWAITING REPAIRS. THE CURRENT AND FAILURE MILEAGES WERE 34,000.

NHTSA ID

10419995

Incident

Aug 16, 2011

Mileage

34,000 mi

MINI COOPER MADE BY BMW. TROUBLE LIGHT APPEARS. ENGINE SWITCHES TO LOW POWER. CAN HAPPEN AT FREEWAY SPEEDS WITHOUT NOTICE. LESS THAN 100 MILES ON CAR AT FIRST INCIDENT. AT FIRST DEALER SERVICE, DEALER SUGGESTED IN MIGHT BE BRAND OF GASOLINE. MULTIPLE INCIDENTS SINCE PURCHASE WITHOUT NOTICE AND WITH DIFFERENT BRAND NAME GASOLINE. *JB

NHTSA ID

10199450

Incident

Jul 24, 2007

Mileage

100 mi