RoadVitals

2008 Buell 1125R Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Apr 2, 2009
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

09V109000

SERVICE BRAKES, HYDRAULIC

Apr 2, 2009
3,316 units potentially affected
The defect: BUELL DISTRIBUTION COMPANY IS RECALLING 3,316 MY 2008 1125R, MY 2009 XB12R AND XB12SCG MOTORCYCLES. THE SUBJECT MOTORCYCLES HAVE A FRONT BRAKE LINE WHICH MAY CONTACT THE FRONT TIRE. THE CONDITION COULD CAUSE A HOLE TO DEVELOP IN THE FRONT BRAKE LINE, ALLOWING BRAKE FLUID TO LEAK.
The risk: THIS CONDITION MIGHT CAUSE AN INEFFECTIVE FRONT BRAKE, LEADING TO A POSSIBLE CRASH AND POTENTIAL INJURY OR DEATH OF THE RIDER.
The remedy: DEALERS WILL RE-ROUTE THE FRONT BRAKE LINE. IF DAMAGE TO THE BRAKE LINE HAS OCCURRED, THE BRAKE LINE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 20, 2009. OWNERS MAY CONTACT BUELL DISTRIBUTION COMPANY AT 1-414-343-8400.
HARLEY-DAVIDSON MOTOR COMPANYManufacturer number 0838View on NHTSA.gov
08V267000

POWER TRAIN:CLUTCH ASSEMBLY

Jun 16, 2008
1,579 units potentially affected
The defect: BUELL IS RECALLING 1,579 MY 2008 1125R MOTORCYCLES. THESE VEHICLES CAN EXPERIENCE 5TH GEAR GALLING ON THE CLUTCH SHAFT DUE TO LACK OF LUBRICATION. THIS CONDITION CAN ALLOW THE GEAR TO SEIZE TO THE SHAFT, RESULTING IN REAR WHEEL LOCK-UP.
The risk: THIS COULD RESULT IN A CRASH, WHICH COULD CAUSE INJURY OR DEATH TO THE RIDER.
The remedy: DEALERS WILL INSPECT AND REPAIR THE AFFECTED MOTORCYCLES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2008. OWNERS MAY CONTACT BUELL MOTORCYCLES AT 1-414-343-8400.
BUELL MOTORCYCLE CO.Manufacturer number 0834View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE12035ClosedPreliminary Evaluation

Motorcycle Stalling

Opened Nov 16, 2012
Closed Apr 16, 2013

ODI opened this investigation based on 25 allegations of subject motorcycle stalling, without warning, due to charging system failure (typically involving the stator).As part of this investigation, testing was conducted to assess whether there would be areasonable warning prior to stator-related engine shut-down while underway.A memo describing this testing may be found in the public file for this investigation.Given the relative frequency of alleged stator failures involving Buell 1125's, it is apparent that customers may not be satisfied with their motorcycle.An example of a manufacturer responding to this type of dissatisfaction is found in the Harley Davidson December 7, 2009product improvement campaign to address the stalling issue.However, current test data does not establish that this customer satisfaction issue is also a safety defect that results in an unreasonable risk to motor vehicle safety.In the absence of a safety defect trend related to Buell 1125 charging system failures, this investigation is closed. The 62 ODI complaints we cite may be found by entering the following ODI investigation numbersat www-odi.nhtsa.dot.gov/owners/SearchNHTSAID:10373814,10386008,10397985,10406939,10406967,10406969,10407046, 10407318,10407511,10407672,10410524,10411954,10429450,10429467, 10429481,10429488,10429530,10429531,10429964,10429970,10429985, 10429987,10430176,10430736,10432169,10432891,10445118,10452480, 10457062,10457815,10457829,10462420,10462439,10462834,10463008, 10463483,10463664,10465165,10465225,10465226,10466505,10470386, 10470415,10470428,10473664,10474136,10474363,10479428,10484793, 10494949,10495197,10496446,10496804,10497643,10496127,10496088, 10496048,10496022,10496018,10495355,10495331,10495307

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
PE10004ClosedPreliminary Evaluation

SUDDEN FUEL EXPULSION

Opened Jan 25, 2010
Closed May 10, 2010

We opened this PE based on a single complaint of rapid fuel expulsion while re-fueling from the owner of a Buell 1125CR.After opening this PE, we contacted other owners, Buell dealer service departments and monitored activity of various Buell-related web forums.While Harley Davidson (Buell was a subsidiary) has no owner complaints, it did receive four warranty claims related to this issue.Two involve the fuel line check valve, one a pinched fuel vent hose, and one saturated charcoal cannister due to over-fill.Currently, the data does not indicate a trending safety defect exists.We will continue to monitor this issue and take action as appropriate.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .