RoadVitals

2006 Buell XB12S Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Mar 4, 2009
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Aug 31, 2007

What this page shows

Our database holds 3 NHTSA owner-reported complaints for the 2006 Buell XB12S. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–3 of 3

Electrical
Filed Mar 4, 2009

MOTORCYCLE STARTED STALLING WHILE DRIVING AND AT LIGHTS. THROTTLE WAS UNRESPONSIVE AND ALMOST CAUSED AN ACCIDENT. BIKE WOULD BACKFIRE AND NOT IDLE. AT 6250 MILES SIX WIRES FROM THE ECM HARNESS RUBBED THE SHARP METAL SHOCK FLUID LINE AND SHORTED OUT THE COIL, TPS, O2 SENSOR AND INJECTORS. THE BIKE WAS UNDRIVEABLE. DEALER RESOLDERED HARNESS. THIS IS THE SECOND RUB THROUGH HARNESS PROBLEM. ENGINE HARNESS WAS COVERED WITH ELECTRICAL CONDUIT AND SHARP FLUID LINE WAS COVERED WITH RUBBER FUEL LINE. *TR

NHTSA ID
10260706
Incident
Feb 18, 2009
Mileage
6,250 mi
Electrical
Filed Dec 10, 2008

REMOVED SEAT AND NOTICED HARNESS TO ECM CHAFFING ON SEAT. PROBLEM COULD CAUSE ENGINE NOT TO RUN. WIRE HARNESS FELT WAS RUBBED COMPLETELY THROUGH EXPOSING MULTIPLE COPPER WIRES IN HARNESS. MILEAGE OF MOTORCYCLE IS 4925. CAUSE IS HARNESS VIBRATES AGAINST THE SHARP EDGE OF UNDERSIDE OF SEAT. DEALER STATES THIS IS A COMMON PROBLEM. DEALER REPAIRED HARNESS AND SECURED HARNESS TO A LOWER POSITION WITH TIE STRAPS. NO KNOWN SOLUTION FROM BUELL HAS BEEN RELEASED. *TR

NHTSA ID
10251273
Incident
Nov 22, 2008
Mileage
4,925 mi
Body & structure
Filed Aug 31, 2007

TL*THE CONTACT OWNS A 2006 BUELL XB12S. WHILE DRIVING VARIOUS SPEEDS UP TO 130 MPH, THE KICKSTAND ALMOST DETACHED FROM THE VEHICLE. WHEN RIDING AROUND CURVES, THE KICKSTAND PROTRUDED AND NEARLY CAUSED A CRASH. THE CONTACT WAS ABLE TO RIDE THE VEHICLE TO HIS RESIDENCE AND, WHEN HE PROPPED UP THE VEHICLE WITH THE KICKSTAND, IT FELL FORWARD. THE DEALER RETORCHED THE BOLTS, HOWEVER, THE CONTACT BELIEVES THIS WAS DONE IMPROPERLY BECAUSE THEY DID NOT LOCK THE BOLTS TIGHTLY. THE CURRENT MILEAGE WAS 4,200 AND FAILURE MILEAGE WAS 3,800.

NHTSA ID
10201606
Incident
Jul 29, 2007
Mileage
3,800 mi

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .