2006 Cadillac Sts Fuel system Problems

The contact owns a 2006 Cadillac STS. The contact stated while inspecting the vehicle, he noticed fuel dripping from the fuel tank. The contact stated no warning light was illuminated. The vehicle was not taken to a dealer. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 14V542000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 140,000.

NHTSA ID

11439244

Incident

Nov 3, 2021

Mileage

140,000 mi

WHILE DRIVING, THE ENTIRE PANEL GOES "OFF" SHUTTING DOWN THE CAR COMPLETELY. THE PANEL BOARD IS COMPLETELY DARK, NO ELECTRIC SUPPLY, NO GAS SUPPLY.

NHTSA ID

11342769

Incident

Jul 3, 2020

Mileage

56,000 mi

LEAKS FUEL IF YOU FILL THE TANK TO CAPACITY. THIS WAS AN EARLIER RECALL, EXACT SAME THING HAPPENING AGAIN.

NHTSA ID

11235027

Incident

Jan 2, 2019

Mileage

100,000 mi

CERTAIN TIMES WHILE DRIVING, THE TRACTION ASSIST COMES ON, AND ALL POWER IS LOST TO THE ENGINE. LIGHTS ARE STILL ON, CAR IS STILL ON, BUT GAS DOES NOT ACCELERATE AND CAR IS HARD TO STEER. I HAVE HAD TO PULL OVER 6 TIMES IN THE LAST FEW MONTHS, TURN THE CAR OFF, RESTART AND HOPE IT DOES NOT HAPPEN AGAIN.

NHTSA ID

11231527

Incident

May 25, 2019

Mileage

99,500 mi

PUMP IS GOING OUT

NHTSA ID

11189889

Incident

Feb 27, 2019

DRIVING OUT OF TOWN STOP GOT GAS EVERYTHING FINE 20 MIN FROM THEN I PULL OVER THE SIDE OF ROAD TURN CAR GET SOMETHING OUT THE TRUNK BACK IN THE CAR TURN FUEL GAUGE READS ALMOST EMPTY NOW I'M WAY OUT IN THE MIDDLE OF NOWHERE.DID GET ANY WARNING ETC BUT NOW I DON'T KNOW IF I'VE GAS IT'S READING EMPTY.SO HAD TO CUT THE TRIP TURN AROUND TO DRIVE ALL BACK WHICH WAS THE SIX-HOUR DRIVE I'VE TO SPEND OVER $200 GAS IN THE FEAR OF NOT RUNNING FINALLY GETS IN THE SHOP WORK ON DECIDE TO TAKE ANOTHER ROAD TRIP AND I CANT BELIEVE THIS DOES IT AGAIN NOW ITS BACK IN SHOP.

NHTSA ID

11083197

Incident

Mar 6, 2018

Mileage

73,000 mi

THE CAR WENT IN FLAMES BY ITSELF WHILE TURNED ON.

NHTSA ID

10785146

Incident

Oct 18, 2015

Mileage

160,000 mi

THIS COMPLAINT PERTAINS TO GM RECALL #14405-2. ALSO LISTED UNDER THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION CAMPAIGN ID NUMBER OF 14V542. HERE IS MY ISSUE: WHEN A MANUFACTURER, IN THIS CASE CADILLAC, ISSUES A RECALL THAT IS AN INCONVENIENCE TO THEIR CUSTOMERS, WHY DOESN'T THE GOVERNMENT REQUIRE THEM TO GIVE A LOANER CAR AND/OR ADDITIONAL COMPENSATION TO THE VEHICLE OWNER TO COVER THE COST AND HASSLE OF TAKING OFF WORK AND GETTING A RENTAL CAR TO USE? I ASKED THE DEALERSHIP, THE CADILLAC CUSTOMER SERVICE LINE REPRESENTATIVE, AHMED, AND THE CADILLAC CUSTOMER SERVICE SUPERVISOR, MICHELLE FOR A LOANER CAR AND THE REQUEST WAS DENIED. I THINK THAT AS PART OF THE COST OF RECALLS THE MANUFACTURER SHOULD LIMIT THE CUSTOMER'S INCONVENIENCE TO AN ABSOLUTE MINIMUM. PLEASE CONSIDER REQUIRING MANUFACTURERS TO PROVIDE A LOANER CAR WHEN A RECALL IS ISSUED IN THE FUTURE. THIS IS NOT A "FREE" REPAIR IF I HAVE TO TAKE TIME OFF OF WORK AND PAY FOR A RENTAL CAR. ALSO THE NEED FOR THIS REPAIR HAS BEEN DETERMINED BY THE GOVERNMENT AND/OR THE MANUFACTURER'S LAWYERS SO THAT FURTHER COST AND LAWSUITS WILL NOT BE INCURRED. YOU WOULD THINK THAT THE MANUFACTURER WOULD WANT TO LIMIT DELAYS IN GETTING REPAIRS DONE DUE TO ADDITIONAL COSTS AND INCONVENIENCE TO THE OWNER OF THE VEHICLE.

NHTSA ID

10762802

Incident

Sep 10, 2015

Mileage

107,000 mi

AIR BAG LIGHT CONSTANTLY STAYS ON, ALONG WITH THE CHECK ENGINE LIGHT. SEAT BELT CHIME CONSTANTLY RINGS WITH THE SEAT BELT CONNECTED. GAS LOW NOTIFICATION LIGHT DOES NOT COME ON UNTIL ON EMPTY. NO HEATED SEATS. I THINK THE ECM NEEDS TO BE RESET.SUN ROOF GOES UP BUT NOT SLIDES OPEN. PASSENGER SIDE DOOR WON'T OPEN.AUTOMATIC CAR STARTER DOESN'T WORK. 2 YEARS AGO, MY SON IN LAW, STARTED THIS CAR IN BELOW ZERO TEMP AND IT STARTED ON FIRE. HE PUT IT OUT AND RESTARTED IT AND IT WAS OK. SOMETHING MAKES NOISE OCCASIONALLY FOR NO APPARENT REASON.

NHTSA ID

10749790

Incident

Jan 28, 2014

Mileage

63,000 mi

TIMING BELT AND ASSOCIATED ITEMS IN ENGINE HAVE FAILED AT 108000 MILES.

NHTSA ID

10731944

Incident

Jul 2, 2015

Mileage

108,000 mi

TL* THE CONTACT OWNS 2006 CADILLAC STS. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V542000 (FUEL SYSTEM, GASOLINE) AND STATED THAT THE PARTS WERE UNAVAILABLE. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE TO SERVICE THE VEHICLE UNDER THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND STATED THAT THEY WERE ALSO UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 8/27/15*CN THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED. UPDATED 09/08/15*JB

NHTSA ID

10726791

Incident

Jun 23, 2015

4/14 - CAR WAS SHUTTING OFF INTERMITTENTLY, PULLED OVER IN HOTEL PARKING LOT AND A GENTLEMEN CAME UP TO CAR TO TELL ME THAT IT WAS SMOKING, GOT OUT AND THERE WAS A FIRE AT THE REAR OF THE CAR. RAN INTO HOTEL AND GOT FIRE EXTINGUISHER TO PUT IT OUT, HAD TOWED TO REPAIR SHOP. THERE DETERMINED THAT THE TERMINAL ON THE TOP OF THE FUEL PUMP OVER HEATED AND MELTED A HOLE IN THE TOP OF THE PUMP, CAUSING FUEL TO LEAK OUT AND CATCH FIRE -$6000 WORTH OF DAMAGE, ONLY USED PARTS AVAILABLE TO FIX CAR. 8/14 RECALL WAS RELEASED ABOUT FUEL MODULE AND HARNESS. 6/15 - CALLED DEALER ABOUT UNRELATED ISSUE (DOOR LOCK), VIN# WAS RAN AND WAS TOLD PARTS WERE AVAILABLE TO FIX RECALL. I MENTIONED I DID NOT RECEIVE THE LETTER THAT PARTS WERE AVAILABLE AND WAS TOLD DEALER HAD TO ORDER THEM, 4 DAYS LATER PARTS CAME IN AND WORK WAS SCHEDULED. CAR WAS THERE FOR 10 DAYS "HAVING TROUBLE GETTING PARTS". WHEN CAR WAS PICKED UP THE FUEL GAUGE WAS NOW OFF ONLY READING 3/4 WHEN FULL AND CHECK ENGINE LIGHT ON. TOLD HARNESS IS NOT AVAILABLE TO FINISH RECALL AND IT WILL TAKE CARE OF BOTH PROBLEMS. THIS SAFETY RECALL IS BEYOND A REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER SHOULD NOT HAVE TORN INTO CAR IF ALL PARTS WERE NOT AVAILABLE. CAR IS DUE FOR INSPECTION 9/15 AND AS IT CURRENTLY STANDS IT WILL NOT PASS INSPECTION DUE TO THE CHECK ENGINE LIGHT BEING ON AND NOW THE GAS GAUGE DOES NOT READ AT ALL. THIS HAS BEEN A HUGE INCONVENIENCE AND AM VERY DISPLEASED WITH THE LACK OF SUPPORT FROM CADILLAC AND THE DEALERSHIP. I NOW HAVE A VEHICLE THAT I CAN NOT GET PARTS TO FIX RECALL, WILL NOT PASS INSPECTION, AND I CAN NOT SELL IT OR TRADE IT IN.

NHTSA ID

10725628

Incident

Apr 7, 2014

Mileage

103,723 mi

TL* THE CONTACT OWNS A 2006 CADILLAC STS. WHILE DRIVING AT 60 MPH, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP WIRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

NHTSA ID

10723064

Incident

Jun 1, 2015

Mileage

70,000 mi

TL* THE CONTACT OWNS A 2006 CADILLAC STS. THE CONTACT STATED THAT THERE WAS FUEL LEAKING WITHOUT WARNING. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V542000 (FUEL/PROPULSION SYSTEM) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE DEALER INFORMED THE CONTACT THAT THE PART MIGHT BECOME AVAILABLE IN JUNE OF 2015. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

NHTSA ID

10715854

Incident

Feb 1, 2015

Mileage

103,000 mi

TL*THE CONTACT OWNS A 2006 CADILLAC STS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V542000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ID

10692299

Incident

Mar 5, 2015

THE FUEL DELIVERY SYSTEM HAS BEEN FAILING IN THE SAME MANNER THAT I HAVE SEEN MANY OTHER CADILLAC OWNERS HAVE GOTTEN REPAIRED THROUGH A RECALL ALREADY IN PLACE. EVERY SINGLE TIME I PUT GAS IN THE TANK THE CAR REFUSES TO TURN ON WITH THE FIRST ATTEMPT. THE ONLY WAY TO GET THE CAR TO TURN ON IS AFTER MULTIPLE ATTEMPTS AND FINALLY ENOUGH FUEL GETS DELIVERED TO THE SYSTEM. SIMILARLY, THE CAR WILL HESITATE OR FEEL LIKE NO GAS IS BEING DELIVERED TO THE ENGINE WHILE DRIVING ON THE HIGHWAY. OFTEN, IT WILL CAUSE A DRAMATIC DROP IN SPEED CAUSING A DANGEROUS SITUATION. GM DEFINITELY NEEDS TO TAKE THIS INTO CONSIDERATION BECAUSE IT IS FAULTS EQUIPMENT RATHER THAN WEAR AND TEAR. ALSO, THERE SEEMS TO BE A SOME MAJOR ISSUE WITH THE OIL SYSTEM IN THE CAR. ONE WEEK AFTER A SYNTHETIC OIL CHANGE, THERE IS OVER 1 QUART OF OIL MISSING IN THE RESERVE. THERE HAS BEEN OVER 4 QUARTS MISSING AT A TIME. *TR

NHTSA ID

10661288

Incident

Nov 1, 2013

Mileage

45,000 mi

THE ENGINE SHUT OFF WHEN I WAS DRIVING ON A SIDE STREET AT 20 MPH, AND ALSO SHUT OFF 5 TIMES AS I WAS DRIVING ON THE HIGHWAY AT 65 MPH. THE CLUSTER PANEL TURNED OFF, BUT THE RADIO STAYED ON. THE ODOMETER SHOWED A MESSAGE ENGINE CONTROL MODULE (ECM). I PULLED OVER, PUT THE CAR IN PARK, AND RESTARTED THE VEHICLE EACH TIME. THE CADILLAC DEALERSHIP SAID THAT REAR AXLE PINION SEAL WAS THE ONLY RECALL FOR MY STS, BUT I AM EXPERIENCING NHTSA CAMPAIGN NUMBER: 06V020000 , AND NHTSA CAMPAIGN NUMBER: 06V007000 ALSO. *TR

NHTSA ID

10505490

Incident

Mar 30, 2013

Mileage

78,142 mi

CAR STALLED ON BUSY STREET AND WOULD NOT RESTART. AFTER LATER INVESTIGATION IT TURNS OUT THAT THE ELECTRICAL CONNECTOR IN FUEL MODULE ASSEMBLY SHORTED OUT AND MELTED THE PLASTIC CONNECTOR. IT ALSO MELTED PART OF THE BOTTOM SIDE OF THE TOP OF MODULE. GM HAS RECALLED EARLIER MODELS OF VEHICLES FOR THE SAME SITUATION. I BELIEVE THIS TO BE VERY DANGEROUS FOR MULTIPLE REASONS:STALLING ON BUSY STREET AND NOT BEING ABLE TO RESTART, FUEL LEAKS DUE TO HOLE MELTING IN MODULE TOP, AND ITS A FIRE HAZARD. *TR

NHTSA ID

10502031

Incident

Feb 25, 2013

Mileage

35,000 mi

AFTER PURCHASING A USED 2006 STS AWD FROM CADILLAC NJ IN DECEMBER 2009, WIFE NOTICED WHILE MAKING RIGHT HAND TURNS ON SMOOTH PAVEMENT, CAR SEEMS TO STALL TEMPORARILY NOT ALLOWING ME TO ACCELERATE FOR A FEW SECONDS AND MESSAGE TRACTION ACTIVE IS DISPLAYED. JANUARY 18, 2010,I BROUGHT THE CAR BACK TO DEALERSHIP TO COMPLAIN. THEY SAID PROB BAD GAS IN LINES. PUT NEW GAS IN AND GAS TREATMENT FOR WATER IN TANK. DID THAT, DIDN'T HELP. FEBRUARY 1, 2010 I RETURNED TO DEALERSHIP TO COMPLAIN IT WAS STILL DOING IT ON OCCASION. I ASKED IF THERE WERE ANY COMPLAINTS ON THIS VEHICLE. GOT A NO RESPONSE. MAY 2010 BROUGHT CAR BACK TO DEALERSHIP TO COMPLAIN. BY THIS TIME MY WIFE HAS REFUSED TO DRIVE IT FOR SAFETY REASONS (PEOPLE THINK SHE IS LETTING THEM INTO ONCOMING TRAFFIC WHEN CAR SLOWS DOWN). LOOKED ON INTERNET AND FOUND OTHER COMPLAINTS. I WAS TOLD GM ENGINEERING IS AWARE OF ISSUE AND ARE WORKING ON SOLUTION. MADE COMPLAINT TO GM IN SEPT 2010 WAS TOLD SOFTWARE UPDATE WILL BE READY IN 2 MONTHS. AFTER GETTING DODGED FOR 2 1/2 MORE YEARS, MADE SECOND COMPLAINT TO GM APRIL 2012. GM EXECUTIVE STATED I CAN USE A RENTAL DUE TO THE SERIOUSNESS OF THE CONDITION LOSING POWER WHILE DRIVING. THEY SAID IT WAS FIXED. A WEEK LATER IT STARTED AGAIN. GM EXECUTIVE AND SERVICE MANAGER OF CADILLAC CALLED TO SAY THAT THE CAR WAS DESIGNED THAT WAY. THERE IS NO FIX ON IT. I TOLD THEM THE 2011 STS RENTAL I DROVE DID NOT HAVE ANY PROBLEM LOSING POWER WHILE IN A TURN. THEY SAID IT IS A DIFFERENT SYSTEM. I SAID "SO THERE WAS A PROBLEM WITH THE OLD SYSTEM" . I WAS LET OUT OF THE DOOR WITH AN OFFER FROM GM EXEC'S, $4,500 OFF PRICE OF A NEW CAR AT THEIR DEALERSHIP. I ASKED, WHAT ABOUT SAFETY? I TOLD THEM I OWN A CAR THAT MY WIFE REFUSES TO DRIVE DUE TO LOSS OF POWER. I ONLY DRIVE CAR BECAUSE MY WIFE DRIVES MY TRUCK. GM KNOWS OF THIS SAFETY ISSUE. SERVICE SAID PROBLEMS ON 2006-07 STS'S. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT

NHTSA ID

10459155

Incident

Jan 18, 2010

Mileage

53,393 mi

CATALYTIC CONVERTER FAILED AT APPROXIMATELY 83,000 MILES. CHECK ENGINE LIGHT COMES ON AND THE MANUFACTURER AND THE DEALER REPLACED THE CONVERTER. AT 93,000 MILES, RECEIVED CHECK ENGINE LIGHT WARNING AGAIN AND THE CODE INDICATES THAT THE CATALYTIC CONVERTER IS A PROBLEM. THE SIDE AFFECT IS THAT THE CAR LACKS POWER WHEN HAVING A NEED ACCELERATE. GM HAS RECALLED THE 2005 CONVERTER, BUT NOT THE 2006. *TR

NHTSA ID

10459026

Incident

May 14, 2010

Mileage

82,000 mi