RoadVitals

2005 Cadillac Xlr Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest Feb 28, 2011
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

11E009000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Feb 28, 2011
4,887 units potentially affected
The defect: TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
The risk: A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
The remedy: TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
TI GROUP AUTOMOTIVE SYSTEMS, LLCView on NHTSA.gov
06V263000

EXTERIOR LIGHTING:TURN SIGNAL

Jul 19, 2006
7,689 units potentially affected
The defect: ON CERTAIN PASSENGER VEHICLES, THE DAYLIGHT RUNNING LIGHTS (DRL), TURN SIGNAL, AND PARKING LAMPS USE THE SAME BULB. THE BULB MAY BECOME DAMAGED FROM VIBRATION WITHIN A LOOSE FITTING SOCKET OR AIR ENTERING THE BULB DUE TO AN INADEQUATE SEAL. BOTH OF THESE CONDITIONS WILL CAUSE THE BULB TO BURN OUT PREMATURELY.
The risk: IF THIS WERE TO OCCUR, THE DRIVER WOULD NOTICE THAT THE ARROW IN THE INSTRUMENT PANEL WOULD FLASH FASTER THAN NORMAL WHEN THE TURN SIGNAL IS ACTIVATED. THE LOSS OF THE DRL AND TURN SIGNALS COULD FAIL TO WARN OTHERS OF THE DRIVER'S PRESENCE OR INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
The remedy: DEALERS WILL REPLACE THE SOCKET AND BULB IN BOTH LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.
GENERAL MOTORS CORP.Manufacturer number 06013View on NHTSA.gov
04V525000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Nov 3, 2004
5,225 units potentially affected
The defect: CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH ONE OR BOTH REAR BRAKE HYDRAULIC LINES THAT CAN COME IN CONTACT WITH OR BE AFFECTED BY HEAT FROM THE LEFT ENGINE EXHAUST MANIFOLD AND THE LEFT EXHAUST PIPE. THE BRAKE FLUID COULD REACH ELEVATED TEMPERATURES AND BOIL.
The risk: IF THE BRAKE FLUID BOILS IN A REAR BRAKE LINE, THE EFFECTIVENESS OF THE REAR BRAKE SYSTEM WOULD BE REDUCED WHICH COULD RESULT IN A BRAKE LINE LEAK AND LOSS OF BRAKE FLUID. IF ENOUGH FLUID LEAKS FROM THE REAR BRAKE SYSTEM SO THAT BRAKE PEDAL APPLICATION CAN NO LONGER BUILD PRESSURE TO THE REAR BRAKES. THE OPERATOR OF THE VEHICLE WILL EXPERIENCE LIMITED BRAKING WHICH COULD RESULT IN A CRASH.
The remedy: DEALERS WILL (1) INSPECT THE LEFT ENGINE EXHAUST MANIFOLD CLIP FOR PROPER ALIGNMENT AND PLACEMENT ON THE BODY-MOUNTED STUD. IF INCORRECT, THEY WILL REPOSITION THE CLIP ON THE BRAKE LINES AND REINSTALL THE CLIP ON THE STUD; (2) THE DEALER WILL VERIFY THAT BOTH REAR BRAKE LINES HAVE THE PROPER CLEARANCE TO THE LEFT EXHAUST PIPE. THEY WILL REPOSITION THE LINES BY BENDING AS NECESSARY; (3) DEALERS WILL REMOVE THE MACHINING TAB FROM THE REAR DIFFERENTIAL HOUSING. ALSO, DEALERS ARE TO INSPECT THE BRAKE LINES FOR WEAR IN THESE RELATED AREAS AND REPAIR OR REPLACE IF THERE IS ANY SIGN OF WEAR-THROUGH ON THE NYLON OVERCOATING. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239 OR CHEVROLET AT 1-800-630-2438.
GENERAL MOTORS CORP.Manufacturer number 04086View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE19001ClosedPreliminary Evaluation

Roof Skin Separation While Driving

Opened Feb 1, 2019
Closed Dec 12, 2019

On August 23rd, 2018 - the Office of Defects Investigation (ODI) received a media inquiry pertaining to a motorist experiencing separation of the roof skin from their Cadillac XLR while driving.Based on the data in-hand at that time and a subsequent (December) consumer complaint, ODI opened PE19-001 on February 1, 2019 to evaluate the scope of this condition in the 2004 - 2005 XLR population.The subject vehicle model is a two-seat roadster equipped with an electrically powered retractable roof system. The outer roof skin is a Sheet Molded Composite (SMC) which is adhered to the magnesium alloy roof frame.ODI's February 7, 2019 Information Request (IR) letter to General Motors (GM) covered the entirety of XLR production: MY 2004 - 2009. GM's March 21, 2019 IR response attributed the separations to an unexpected oxide layer on the magnesium framework. A total of eight separations were identified, six of which coincided with consumer complaints to NHTSA. Separations occurred at two per calendar year with the most recent taking place in late 2018.An additional twenty-one noise, fit/finish/ functionality claims were identified that did not lead to separations.ODI compared the separation rate in the subject vehicles to those in to two roof skin separation safety recalls involving the Corvette (06V181: 2005 - 2006 Corvette; 09V491: 2005 - 2007 Corvette) to find that the subject vehicles took over ten years of exposure to reach the failure rate that triggered the 06V181.Since PE19-001 opened, ODI has received only one additional consumer complaint which reported wind noise symptoms. The complainant has not responded to outreach efforts by ODI or GM.Based on a low failure rate, sporadic occurrence, and high detectability of the alleged defect in the subject vehicles, this investigation is closed. Further use of agency resources on this matter is not warranted. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist in the subject vehicles.The agency reserves the right to take further action if warranted by the circumstances. The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers: Separations: 11155574, 11101657, 11012176, 11012166, 10970736, 10970383, 10653304Note: ODI 11012176 & 11012166 pertain to the same incidentNot Separated: 11243947, 11194359, 11176647, 11173362, 11074433, 10985013 Note: 11176647 & 10985013 pertain to the same incident

STRUCTURE:BODY:ROOF AND PILLARS

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .