RoadVitals

2011 Champion M1235 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Feb 3, 2012
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

12V040000

EXTERIOR LIGHTING:TURN SIGNAL

Feb 3, 2012
30 units potentially affected
The defect: CHAMPION BUS (CHAMPION) IS RECALLING CERTAIN MODEL YEAR 2011-2012 ABC-M1235 TRANSIT BUSES MANUFACTURED FROM MARCH 9, 2011, TO NOVEMBER 18, 2011, BUILT ON A FREIGHTLINER CUSTOM CHASSIS. THE GRID HEATER GROUND WIRE MAY CONTACT THE RELAY POWER TERMINAL AND RUB AND CHAFE, POTENTIALLY RESULTING IN A SHORT CIRCUIT.
The risk: AN ELECTRICAL FAULT OR SHORT CIRCUIT COULD CAUSE A VEHICLE FIRE.
The remedy: FREIGHTLINER WILL NOTIFY THE OWNERS, AND INSPECT THE BUSES AND CORRECTLY ROUTE THE GROUND WIRE AS NECESSARY THE REPAIRS WILL BE PERFORMED BY FREIGHTLINER AUTHORIZED FACILITIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 2, 2012. OWNERS MAY CONTACT CHAMPION AT 1-810-724-6474.
CHAMPION BUS, INC.View on NHTSA.gov
11V518000

ENGINE AND ENGINE COOLING

Oct 18, 2011
3 units potentially affected
The defect: CHAMPION BUS (CHAMPION) IS RECALLING CERTAIN MODEL YEAR 2011 CTS AND M1235 TRUCKS MANUFACTURED FROM MARCH 9, 2011, THROUGH JUNE 29, 2011, EQUIPPED WITH A CUMMINS ISX OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
The risk: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.
The remedy: CHAMPION IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000.
CHAMPION BUS, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources