RoadVitals

2002 Chance Opus 29 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Mar 19, 2003
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

03V056000

VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING

Mar 19, 2003
203 units potentially affected
The defect: ON CERTAIN DIESEL BUSES, THE TWO-SPEED WINDSHIELD WIPER SWITCH CAN CAUSE THE LOW SPEED WIPER RELAY TO CHATTER CAUSING THE WINDSHIELD WIPER MOTOR TO OVERHEAT.
The risk: WHEN THE WINDSHIELD WIPER MOTOR OVERHEATS, IT CAUSES THE 15 AMP WINDSHIELD WIPER FUSE TO OPEN PROTECTING THE CIRCUIT. THIS RESULTS IN THE LOSS OF WINDSHIELD WIPER OPERATION. LOSS OF VISIBILITY CAN INCREASE THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE WIPER SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT OPTIMA BUS AT 1-316-779-7700.
CHANCE COACH, INC.Manufacturer number SBR 03-002View on NHTSA.gov
03V009000

EQUIPMENT:OTHER:LABELS

Jan 2, 2003
201 units potentially affected
The defect: ON CERTAIN COACHES, THE FRONT AND REAR COACH DOORS ARE NOT MARKED AS AN "EMERGENCY EXIT."
The risk: WITHOUT THESE LABELS, THERE COULD BE CONFUSION IN LOCATING THE EMERGENCY EXITS IN THE EVENT OF A CRASH.
The remedy: OWNERS WILL BE PROVIDED WITH LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION WAS EXPECTED TO BEGIN JANUARY 7, 2003. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT CHANCE COACH AT 1-888-391-1777.
CHANCE COACH, INC.Manufacturer number SB111View on NHTSA.gov
02V232000

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Sep 19, 2002
27 units potentially affected
The defect: ON CERTAIN COACHES EQUIPPED WITH OPTIONAL WEBASTO HEATERS, THE HEATER LINES IN THE ENGINE COMPARTMENT, ABOVE THE ENGINE EXHAUST SYSTEM, ARE COVERED WITH INSULATION.
The risk: HEAT FROM THE EXHAUST MANIFOLD MELTS THE INSULATION CREATING SMOKE OR FIRE IN THE ENGINE COMPARTMENT.
The remedy: DEALERS WILL REMOVE THE INSULATION FROM THESE LINES. OWNER NOTIFICATION BEGAN AUGUST 19, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHANCE COACH AT 1-316-779-7712.
CHANCE COACH, INC.Manufacturer number SB-107View on NHTSA.gov
02V258000

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

Sep 16, 2002
126 units potentially affected
The defect: ON CERTAIN COACHES, CHAFFING OF THE DRIVER'S LEFT CONSOLE HEAT DUCT FLEXHOSE BETWEEN THE 300 AMP CIRCUIT BREAKER LUG AND THE BATTERY HOLD-DOWN WELDMENT OCCURS.
The risk: THIS INCREASES THE RISK OF FIRE IN THE BATTERY BOX AREA WHEN THE 300 AMP CIRCUIT BREAKER TERMINAL LUG IS SHORTED TO GROUND.
The remedy: A SAFETY BULLETIN CONTAINING INSTRUCTIONS AND THE PARTS REQUIRED TO INSULATE THE TERMINAL LUG ON THE 300A CIRCUIT BREAKER WILL BE PROVIDED TO THE OWNERS. OWNER NOTIFICATION BEGAN OCTOBER 7, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHANCE COACH AT 1-888-391-1777.
CHANCE COACH, INC.View on NHTSA.gov
02V004011

VEHICLE SPEED CONTROL

Sep 10, 2002
137 units potentially affected
The defect: ON CERTAIN BUSES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
The risk: IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
The remedy: CHANCE COACH RECOMMENDS THAT OWNERS INSPECT THEIR VEHICLES AND INSTALL THE PART KIT PROVIDED BY CHANCE COACH. OWNERS WHO DO NOT RECEIVE THE FREE PARTS AND INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT CHANCE COACH AT 1-888-391-1777.
CHANCE COACH, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources